MATERIAL SAFETY DATA SHEET
Emergency Telephone No.: CHEMTREC (800) 424-9300 or (703) 527-3887
Emergency Information Centers are located in the U.S.A. International collect calls accepted.
Information No.: Star brite (800) 327-8583 (954) 587-6280 Date: June 18, 2005
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Name: Synthetic 80W90 Lower Unite Gear Lube Product Number: 27232, 27200, 27205, 27255
GENERIC NAME: GEAR OIL
CAS NUMBER: MIXTURE
SYNONYMS / GENERAL NAMES: GEAR LUBRICANT
Company Identification
Star brite Distributing, Inc.
4041 S. W. 47 Ave.
Ft. Lauderdale, FL 33314
2. COMPOSITION / INFORMATION ON INGREDIENTS / HAZARDOUS INGREDIENTS
COMPONENTS CAS NO. % HAZARD DATA
1) HIGHLY-REFINED PARAFFINIC PETROLEUM OILS
2) PETROLEUM ADDITIVES
64741-88-4
MIXTURE
>85
<15
ORAL (LD50): >5000 mg/kg
DERMAL (LD50): >2000 mg/kg
HAZARDOUS INGREDIENTS: NONE
HAZARDOUS PER 29 CFR 1916.1200: NO
3. HAZARDOUS IDENTIFICATION
ROUTES OF ENTRY: SKIN CONTACT
TARGET ORGANS: SKIN
IRRITANCY: THIS PRODUCT CAN CAUSE MILD, TRANSIENT, EYE IRRITATION WITH SHORT-TERM
CONTACT WITH LIQUID OR SPRAYS.
REPRODUCTIVE EFFECTS: N/A
CANCER INFORMATION: THIS PRODUCT DOES NOT CONTAIN ANY COMPONENTS AT
CONCENTRATIONS ABOVE 0.1% WHICH ARE CONSIDERED CARCINOGENIC BY OSHA, IARC, OR NTP.
4. FIRST AID MEASURES
EYES: CHECK FOR AND REMOVE CONTACT LENSES. FLUSH EYES WITH COOL, CLEAN, LOW-
PRESSURE WATER WHILE OCCASIONALLY LIFTING AND LOWERING EYELIDS. SEEK MEDICAL
ATTENTION IF EXCESSIVE TEARING, REDNESS, OR PAIN PERSISTS.
DERMAL: REMOVE CONTAMINATED SHOES AND CLOTHING. WIPE OFF EXCESS MATERIAL. WASH
EXPOSED SKIN WITH SOAP AND WATER. SEEK MEDICAL ATTENTION IF TISSUE APPEARS DAMAGED
OR IF IRRITATION PERSISTS. THOROUGHLY CLEAN CONTAMINATED CLOTHING BEFORE REUSE.
DISCARD CONTAMINATED LEATHER GOODS.
INGESTION: DO NOT INDUCE VOMITING UNLESS DIRECTED TO BY A PHYSICIAN. DO NOT GIVE
ANYTHING TO DRINK UNLESS DIRECTED TO BY A PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO A
PERSON WHO IS NOT FULLY CONSCIOUS. SEEK MEDICAL ATTENTION IMMEDIATELY.
Product Name: Synthetic 80W90 Lower Unite Gear Lube Product Number: 27232, 27200, 27205, 27255
4. FIRST AID MEASURES cont鈥檇
INHALATION: MOVE VICTIM TO FRESH AIR. IF VICTIM IS NOT BREATHING, IMMEDIATELY BEGIN
RESCUE BREATHING. IF BREATHING IS DIFFICULT, 100 PERCENT HUMIDIFIED OXYGEN SHOULD BE
ADMINISTERED BY A QUALIFIED INDIVIDUAL. SEEK MEDICAL ATTENTION IMMEDIATELY. KEEP THE
AFFECTED INDIVIDUAL WARM AND AT REST.
INJECTION: INJECTION OF PRESSURIZED HYDROCARBONS CAN CAUSE SEVERE, PERMANENT TISSUE
DAMAGE. INITIAL SYMPTOMS MAY BE MINOR. INJECTION OF PETROLEUM HYDROCARBONS REQUIRES
IMMEDIATE MEDICAL ATTENTION.
NA - NOT APPLICABLE ND - NO DATA NE - NOT ESTABLISHED.Revision: 11/5/2001 Page 2 of 4
5. FIRE FIGHTING MEASURES
FLASH POINT, 掳C( 掳F): 207掳C( 405掳F)
FLAMMABLE LIMITS (% BY VOLUME): LOWER: NO DATA UPPER: NO DATA
EXTINGUISHING MEDIA: USE DRY CHEMICAL, FOAM, CARBON DIOXIDE OR WATER FOG.
SPECIAL FIRE FIGHTING PROCEDURES: N/A
AUTOIGNITION TEMPERATURE: 398掳C
EXPLOSION DATA: N/A
NFPA RATING: HEALTH: 1 FLAMMABILITY: 1 REACTIVITY 0
6. ACCIDENTAL RELEASE MEASURES
SPILL PROCEDURES: DO NOT TOUCH DAMAGED CONTAINERS OR SPILLED MATERIAL UNLESS
WEARING APPROPRIATE PROTECTIVE EQUIPMENT. SLIPPING HAZARD; DO NOT WALK THROUGH
SPILLED MATERIAL. STOP LEAK IF YOU CAN DO SO WITHOUT RISK. FOR SMALL SPILLS, ABSORB OR
COVER WITH DRY EARTH, SAND, OR OTHER INERT NON-COMBUSTIBLE ABSORBENT MATERIAL AND
PLACE INTO WASTE CONTAINERS FOR LATER DISPOSAL. CONTAIN LARGE SPILLS TO MAXIMIZE
PRODUCT RECOVERY OR DISPOSAL. PREVENT ENTRY INTO WATERWAYS OR SEWERS. IN URBAN
AREA, CLEANUP SPILL AS SOON AS POSSIBLE. IN NATURAL ENVIRONMENTS, SEEK CLEANUP ADVICE
FROM SPECIALISTS TO MINIMIZE PHYSICAL HABITAT DAMAGE. THIS MATERIAL WILL FLOAT ON
WATER. ABSORBENT PADS AND SIMILAR MATERIALS CAN BE USED. COMPLY WITH ALL LAWS AND
REGULATIONS.
7. HANDLING AND STORAGE
HANDLING PROCEDURES: AVOID WATER CONTAMINATION AND EXTREME TEMPERATURES TO
MINIMIZE PRODUCT DEGRADATION. EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUES THAT
CAN IGNITE WITH EXPLOSIVE FORCE. DO NOT PRESSURIZE, CUT, WELD, BRAZE SOLDER, DRILL,
GRIND OR EXPOSE CONTAINERS TO FLAMES, SPARKS, HEAT OR OTHER POTENTIAL IGNITION
SOURCES. CONSULT APPROPRIATE FEDERAL, STATE AND LOCAL AUTHORITIES BEFORE REUSING,
RECONDITIONING, RECLAIMING, RECYCLING OR DISPOSING OF EMPTY CONTAINERS AND/OR
WASTE RESIDUES OF THIS PRODUCT.
STORAGE PROCEDURES: KEEP CONTAINER CLOSED. DO NOT STORE WITH STRONG OXIDIZING
AGENTS. DO NOT STORE AT TEMPERATURES ABOVE 120掳F OR IN DIRECT SUNLIGHT FOR EXTENDED
PERIODS OF TIME. CONSULT APPROPRIATE FEDERAL, STATE AND LOCAL AUTHORITIES BEFORE
REUSING, RECONDITIONING, RECLAIMING, RECYCLING OR DISPOSING OF EMPTY CONTAINERS OR
WASTE RESIDUES OF THIS PRODUCT.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
ENGINEERING CONTROLS: PROVIDE EXHAUST VENTILATION OR OTHER ENGINEERING CONTROLS TO
KEEP THE AIRBORNE CONCENTRATIONS OF MISTS AND/OR VAPORS BELOW THE RECOMMENDED
EXPOSURE LIMITS. AN EYE WASH STATION AND SAFETY SHOWER SHOULD BE LOCATED NEAR THE
WORK-STATION.
Product Name: Synthetic 80W90 Lower Unite Gear Lube Product Number: 27232, 27200, 27205, 27255
8. EXPOSURE CONTROLS / PERSONAL PROTECTION cont鈥檇
GLOVES PROTECTION: USE GLOVES CONSTRUCTED OF CHEMICAL RESISTANT MATERIALS SUCH AS
NEOPRENE OR HEAVY NITRILE RUBBER IF FREQUENT OR PROLONGED CONTACT IS EXPECTED. USE
HEAT PROTECTIVE GLOVES WHEN HANDLING PRODUCT AT ELEVATED TEMPERATURES.
EYE PROTECTION: SAFETY GLASSES EQUIPPED WITH SIDE SHIELDS SHOULD BE ADEQUATE
PROTECTION UNDER MOST CONDITIONS OF USE. WEAR GOGGLES AND/OR FACE SHIELD IF
SPLASHING OR SPRAYING IS LIKELY, ESPECIALLY IF MATERIAL IS HEATED ABOVE 125掳 F (OR 51掳 C).
HAVE SUITABLE EYE WASH WATER AVAILABLE.
RESPIRATORY PROTECTION: VAPORIZATION OR MISTING IS NOT EXPECTED AT AMBIENT
TEMPERATURES. THEREFORE, THE NEED FOR RESPIRATORY PROTECTION IS NOT ANTICIPATED
UNDER NORMAL USE CONDITIONS AND WITH ADEQUATE VENTILATION. IF ELEVATED AIRBORNE
CONCENTRATIONS ABOVE APPLICABLE WORKPLACE EXPOSURE LEVELS ARE ANTICIPATED, A NIOSH-
APPROVED ORGANIC VAPOR RESPIRATOR EQUIPPED WITH A DUST/MIST PREFILTER SHOULD BE
USED. PROTECTION FACTORS VARY DEPENDING UPON THE TYPE OF RESPIRATOR USED.
RESPIRATORS SHOULD BE USED IN ACCORDANCE WITH OSHA REQUIREMENTS (29 CFR 1910.134).
CLOTHING RECOMMENDATION: AVOID PROLONGED AND/OR REPEATED SKIN CONTACT, ESPECIALLY
AFTER THIS PRODUCT HAS BEEN USED IN A CRANKCASE. IF SPLASHING OR SPRAYING IS EXPECTED,
CHEMICAL-RESISTANT (TYVEK , NITRILE, OR NEOPRENE) PROTECTIVE CLOTHING SHOULD BE WORN.
THIS MIGHT INCLUDE LONG-SLEEVES, APRON, SLICKER SUIT, BOOTS, AND ADDITIONAL FACIAL
PROTECTION. IF GENERAL CONTACT OCCURS, PROMPLY REMOVE SOAKED CLOTHING AND TAKE A
SHOWER.
NA - NOT APPLICABLE ND - NO DATA NE - NOT ESTABLISHED.Revision: 11/5/2001 Page 3 of 4
9. PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE: DARK LIQUID
ODOR: PUNGENT ODOR
pH: N/A
VAPOR PRESSURE, mm Hg (25 掳C): 6
VAPOR DENSITY: ND(AIR =1)
MELTING POINT: NOT AVAILABLE.
BOILING POINT, 760 mm Hg, 掳C: NOT AVAILABLE
SOLUBILITY IN WATER: INSOLUBLE IN COLD WATER.
SPECIFIC GRAVITY: .91 (WATER = 1)
EVAPORATION RATE: N/A
VISCOSITY 40掳C (100掳C) 127 CST @ 40掳 C
MOLECULAR WEIGHT: N/A
PERCENT VOLATILE: NEGLIGIBLE VOLATILITY
10. STABILITY AND REACTIVITY
STABILITY: STABLE
INCOMPATIBILITY: STRONG OXIDIZERS
POLYMERIZATION: NOT EXPECTED TO OCCUR
THERMAL DECOMPOSITION: CO2 , CO, SMOKE, FUMES, UNBURNED HYDROCARBONS AND TRACE
OXIDES OF SULFUR, NITROGEN, PHOSPHORUS AND ZINC.
11. TOXICOLOGICAL INFORMATION
EYE IRRITATION: THIS PRODUCT CAN CAUSE MILD, TRANSIENT, EYE IRRITATION WITH SHORT-TERM
CONTACT WITH LIQUID OR SPRAYS.
DERMAL IRRITATION: THIS MATERIAL CAN CAUSE MILD, TRANSIENT SKIN IRRITATION WITH SHORT-
TERM EXPOSURE.
INHALATION TOXICITY: NO SIGNIFICANT ADVERSE HEALTH EFFECTS ARE EXPECTED TO OCCUR
UPON SHORT-TERM EXPOSURE TO THIS PRODUCT. ASPIRATION OF LIQUID INTO THE LUNGS CAN
CAUSE SEVERE LUNG DAMAGE OR DEATH.
Product Name: Synthetic 80W90 Lower Unite Gear Lube Product Number: 27232, 27200, 27205, 27255
11. TOXICOLOGICAL INFORMATION cont鈥檇
INGESTION IRRITATION: IF SWALLOWED, NO SIGNIFICANT ADVERSE HEALTH EFFECTS ARE
ANTICIPATED. INGESTION CAN CAUSE MILD IRRITATION TO THE DIGESTIVE TRACT OR CAUSE A
LAXATIVE EFFECT.
INJECTION SENSITATION: INJECTION UNDER THE SKIN, IN MUSCLE, OR INTO THE BLOOD STREAM
CAN CAUSE IRRITATION, INFLAMMATION, SWELLING, FEVER, AND SYSTEMIC EFFECTS AND MILD
CENTRAL NERVOUS SYSTEM DEPRESSION. INJECTION OF PRESSURIZED HYDROCARBONS CAN
CAUSE SEVERE, PERMANENT TISSUE DAMAGE. INITIAL SYMPTOMS MAY BE MINOR. INJECTION OF
PETROLEUM HYDROCARBONS REQUIRES IMMEDIATE MEDICAL ATTENTION.
CHRONIC EXPOSURE SYMPTOMS PROLONGED OR REPEATED CONTACT CAN CAUSE MILD SKIN
IRRITATION AND INFLAMMATION CHARACTERIZED BY DRYING, CRACKING, (DERMATITIS) OR OIL
ACNE.
12. HEALTH INFORMATION
HMIS CODE: HEALTH: 1 FIRE: 1 REACTIVITY: 0
No HIGHLY TOXIC No SENSITIZER
No TOXIC No REPRODUCTIVE EFFECTS
No CORROSIVE No MUTAGEN
No IRRITANT
13. DISPOSAL CONSIDERATIONS
WASTE DISPOSAL: It is the responsibility of the user to determine if the material is a hazardous waste at the
time of disposal. Determine compliance status with all applicable requirements prior to disposal.
NA - NOT APPLICABLE ND - NO DATA NE - NOT ESTABLISHED.Revision: 11/512001 Page 4 of 4
14. TRANSPORT INFORMATION
Call for information
15. REGULATORY INFORMATION
SARA SECTION 313 - TOXIC CHEMICALS:
This product does not contain toxic chemicals under SARA Section 313 and 40 CFR Part 372.
COMPONENTS CAS # %
SARA SECTION 311 - HAZARD CATEGORIES:
This product may meet one or more of the criteria for the hazard categories defined in 40 CFR Part 370 as
established be Sections 311 and 312 of SARA as indicated below:
YES IMMEDIATE (ACUTE) HEALTH HAZARD NO SUDDEN RELEASE OF PRESSURE HAZARD
NO DELAYED (CHRONIC) HEALTH HAZARD NO REACTIVE HAZARD
NO FIRE HAZARD
SARA SECTION 302 - EXTREMELY HAZARDOUS WASTE:
This product is not known to contain any components in concentrations greater than one percent that are listed as
Extremely Hazardous Substances in 40 CFR Part 355 pursuant to the requirements of Section 302(a) of SARA.
CLEAN WATER ACT (CWA):
Under the CWA, discharges of crude oil and petroleum products to surface water without proper Federal and
State permits must be reported immediately to the National Response Center at (800) 424-8802.
Product Name: Synthetic 80W90 Lower Unite Gear Lube Product Number: 27232, 27200, 27205, 27255
15. REGULATORY INFORMATION cont鈥檇
CERCLA HAZARDOUS SUBSTANCES:
AS DEFINED BY CERCLA, THE TERM 鈥淗AZARDOUS SUBSTANCE鈥? DOES NOT INCLUDE PETROLEUM,
INCLUDING CRUDE OIL OR ANY FRACTION THEREOF WHICH IS NOT OTHERWISE SPECIFICALLY
LISTED OR DESIGNATED AS A HAZARDOUS SUBSTANCE.
U.S. TSCA INVENTORY
ALL COMPONENTS OF THIS MATERIAL ARE ON THE U.S. TSCA INVENTORY OR ARE NOT REQUIRED TO
BE LISTED ON THE U.S. TSCA INVENTORY
16. OTHER INFORMATION
THE INFORMATION IN THIS MATERIAL SAFETY DATA SHEET SHOULD BE PROVIDED TO ALL WHO WILL
USE, HANDLE, STORE, TRANSPORT, OR OTHERWISE BE EXPOSED TO THIS PRODUCT. THIS
INFORMATION HAS BEEN PREPARED FOR THE GUIDANCE OF PLANT ENGINEERING, OPERATIONS AND
MANAGEMENT AND FOR PERSONS WORKING WITH OR HANDLING THIS PRODUCT. STAR BRITE
BELIEVES THIS INFORMATION TO BE RELIABLE AND UP TO DATE AS OF THE DATE OF PUBLICATION,
BUT MAKES NO WARRANTY THAT IT IS.
NFPA HAZARD RATING least - 0 slight - 1 moderate - 2 high - 3 extreme - 4
HMIS HEALTH RATING least - 0 slight - 1 moderate - 2 high - 3 extreme - 4
NA - NOT APPLICABLE ND - NO DATA NE - NOT ESTABLISHED
|