SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET MM 585
5 mg/m3 for oil mist in air (OSHA Regulation 29 CFR 1910.1000);
Threshold Limited Value
ALDON 1533 W.Henrietta Rd. (ACGIH 1983-84).
MM 585
Avon, New York 14414 MSDS No.
庐
CORPORATION September 18, 1995
Effective Date
(716) 226-6177
Effects of Overexposure
A bland product. Low hazard at room temperatures.
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE
Product MINERAL OIL, (KLEAROL) 庐 CHEMTREC
1 1
Health
800-424-9300
Chemical
Emergency and
0 0
White Mineral Oil
Synonyms 1
Fire
Day 716-226-6177
First Aid Procedures INGESTION: If swallowed, if conscious, do NOT induce vomiting.
Formula A mixture of liquid hydrocarbons refined from petroleum. 0
Reactivity Call physician. Never give anything by mouth to an unconscious
NFPA
person. EYES: Flush thoroughly with water for at least 15 minutes,
HAZARD RATING HMIS *
Unit Size up to 5 gallon
lifting upper and lower eyelids occasionally. If irritation persists, get
LEAST SLIGHT MODERATE HIGH EXTREME
0 1 2 3 4 medical attention. SKIN: Flush with soap and water.
C.A.S. No. 8042-47-5
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable Excessive temperature or heat.
Mineral Oil, (Klearol) 庐 100% See Section V.
Stable X
Incompatibility
Strong oxidants like: hydrogen peroxide, bromine and chromic acid.
(Materials to Avoid)
CAUTION! LOW HAZARD. STORE AWAY FROM FIRE HAZARDS
Hazardous
AND STRONG OXIDIZING MATERIALS; NON-TOXIC. Carbon monoxide and carbon dioxide.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) Not applicable. < 1 @ 15掳C
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) > 230掳C (450掳F) 0 @ 25掳C X
by Volume (%)
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) < .005 0 @ 25掳C
=1)
(
Steps to be taken in case
Vapor Density (Air=1) Not applicable. Add absorbent (sand, earth, sawdust, vermiculite) to spill area.
material is released or spilled Do not allow to go to sewer or water courses. Wash spill area
Solubility in Water Negligible at 25掳C.
with soap and water.
Viscous, clear, colorless liquid; no odor.
Appearance & Odor
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Dispose of in an approved incinerator or contract with a licensed waste
% by Volume
130掳C (265掳F) No data -------- --------
(Method Used)
disposal service.
Extinguisher Foam; dry chemical (ABC); carbon dioxide (CO2 ); water fog; sand, earth. SECTION VIII SPECIAL PROTECTION INFORMATION
Media
None needed in normal laboratory handling. If misty conditions prevail, work in
Respiration Protection
ventilation hood or wear a NIOSH/MSHA-approved respirator.
(Specify Type)
SPECIAL FIREFIGHTING
Not needed. No.
Local Exhaust Special
PROCEDURES Ventilation Not needed. No.
Mechanical (General) Other
Water or foam may cause frothing. Use water to keep fire exposed
containers cool. Water spray may be used to flush spills away from
Protective Gloves Eye Protection
Normally not needed. Chemical safety glasses.
exposure. Wear a NIOSH/MSHA-approved self-contained
Other Protective
breathing apparatus. Avoid breathing vapors or fumes. Lab coat, eye wash station, fire extinguisher.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND in Handling & Storing Do not handle or store near heat, sparks, flame or strong oxidants.
EXPLOSION HAZARDS Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
Fire or excessive heat may produce hazardous decomposition
Avoid breathing oil mist. Remove oil-soaked clothing and launder before
products. Do not mix or store with strong oxidants.
reuse. Discard oil-soaked shoes. Wash skin with soap and water after
handling.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date 9/18/95 MR
No. 1 Michael Raszeja Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|