SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET PP 159
Threshold Limited Value 3
Ethyl Alcohol TWA: 1000 ppm; 1800 mg/m (AIR). Methanol TWA: SKIN
ALDON 1533 W.Henrietta Rd. 3 3
200 ppm; 262 mg/m ; Ethyl Acetate TWA: 400 ppm; 1440 mg/m (AIR).
PP 159
Avon, New York 14414 MSDS No.
庐
CORPORATION December 31, 1996
Effective Date
(716) 226-6177
Effects of Overexposure INGESTION: Causes dizziness, drowsiness, decreased reaction, euphoria,
nausea, vomiting, staggering gait, and coma. SKIN ABSORPTION: No
evidence of adverse effects from available information. INHALATION: May
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE
cause dizziness, drowsiness, nausea and vomiting. SKIN CONTACT:
Product PHENOLPHTHALEIN 2% ALCOHOL SOLUTION Dehydration of skin. EYE CONTACT: May cause blindness.
CHEMTREC Health 1
800-424-9300
Chemical
Emergency and
Phenolphthalein pH Indicator Solution INGESTION: Do NOT give anything by mouth to an unconscious or very
Synonyms 3
Fire
Day 716-226-6177 drowsy person. If conscious, give two glasses of water to drink, induce
First Aid Procedures
Mixture.
Formula vomiting. Repeat until vomit fluid is clear. Call physician immediately.
1
Reactivity
NFPA SKIN: Flush with water. INHALATION: Remove to fresh air. Give artificial
HAZARD RATING HMIS *
up to 4 Lt.
Unit Size respiration if not breathing. Oxygen may be given by qualified personnel if
LEAST SLIGHT MODERATE HIGH EXTREME
breathing is difficult. Obtain medical attention. EYES: Immediately flush
0 1 2 3 4
Mixture.
C.A.S. No. eyes with plenty of water for at least 15 minutes, occasionally lifting upper
SECTION II INGREDIENTS OF MIXTURES and lower eyelids. Get medical attention.
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable
Phenolphthalein: (CAS No. 77-09-8) 2.1% None established. Heat, fire, ignition source.
Stable X
Water: (CAS No. 7732-18-5) 28.7% None established. Incompatibility
Concentrated nitric or sulfuric acid; strong oxidizing agents.
(Materials to Avoid)
Ethyl Alcohol, Denatured * : (CAS No. 64-17-5) 69.2% 1000 ppm (Air).
Hazardous Thermal decomposition or burning can produce carbon monoxide and/or
WARNING! FLAMMABLE! HARMFUL IF SWALLOWED.
carbon dioxide.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) Approx. -80掳C (-112掳F) Approx. 0.80 20掳/20掳
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) Approx. -80掳C (-112掳F) Ethyl Alc. 98%
by Volume (%) X
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) Ca 42 @ 68掳C (Ethyl Alc.) Butyl Alc. 4.1 Ethyl Alcohol
=1)
(
Steps to be taken in case
Vapor Density (Air=1) Ca 1.6 (Ethyl Alc.) Remove all sources of ignition, provide adequate ventilation. For
material is released or spilled small spills, dilute with water and flush to sewer with copious
Solubility in Water Complete. amounts of water or absorb with an inert dry material. Burn in an
approved incinerator or open pit away from buildings and people.
Appearance & Odor Clear, water white, mobile liquid; mild characteristic odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Dispose of in an approved incinerator or contract with a licensed waste
% by Volume
(Method Used) 21.6掳C (70掳F) TCC Ethyl Alc. 3.3 9.0
disposal agency.
Extinguisher
SECTION VIII SPECIAL PROTECTION INFORMATION
Water spray; carbon dioxide (CO ); dry chemical; alcohol-type, or universal-type foams.
Media 2
For normal laboratory use at room temperatures none should be needed with adequate
Respiration Protection
room ventilation. If required work in fume hood. Do not use in confined area.
(Specify Type)
SPECIAL FIREFIGHTING
Recommended. No.
Local Exhaust Special
PROCEDURES Ventilation
If involved in fire situation, wear a NIOSH/MSHA-approved Recommended. No.
Mechanical (General) Other
self-contained breathing apparatus and protective clothing.
Protective Gloves Eye Protection
Rubber. Chemical safety glasses.
Use flooding amounts of water in early stages of fire.
* Denaturants: Other Protective
Methanol: (CAS No. 67-56-1) Smock, apron, eye wash station, goggles, fire extinguisher, proper gloves.
Equipment
Ethyl Acetate: (CAS No. 141-78-6)
SECTION IX SPECIAL PRECAUTIONS
Aliphatic Hydrocarbons: Mixture
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry, well-ventilated area, away from any fire hazard.
in Handling & Storing
EXPLOSION HAZARDS Use with adequate ventilation. Do not take internally.
Keep container tightly closed when not in use.
Flame may not be visible in daylight. Fire or excessive heat Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
may produce hazardous decomposition products; can react
vigorously with oxidizing materials. Wash thoroughly after handling.
Remove and wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
(1993 EMERGENCY RESPONSE GUIDEBOOK, DOT P 5800.6, GUIDE PAGE NO. 26) Approved
Revision Date
No. 4 12/31/96 Michael Raszeja MR
Coordinator
D.O.T. DENATURED ALCOHOL, (SOLUTION), 3, NA 1987, PG II The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|