Material Safety Data Sheet
Food Shield Anti-Seize
TELEPHONE 715-832-4557
1. Product Identification
Product Name Food Shield Anti-Seize
Chemical Family Anti-Seize Lubricating Compounds
2. Composition
Ingredients CAS# HAZARD OSHA/PEL TLV STEL
White Mineral Oil 0042-47-5 Irritant 5mg/m3$2 5mg/m3$1 10mg/m3$
Calcium Carbonate 1317-65-3 Irritant Not Est. Not Est. Not Est.
Zinc Oxide 1314-13-2 Irritant Not Est. Not Est. Not Est.
3. Hazards Identification
Boiling Point (F) >450 IBP Specific Gravity (H20) 1.16
Vapor Pressure (mmhg) <0.1 Color White
Vapor Density(Air=1) >1 Odor Petroleum
PH @ 100% N/A Clarity Opaque
% Volatile by Volume 60-65 Evaporation Rate(Bu A/C=1) <0.1
Solubility in water Negligible Viscosity Viscous
4. Fire and Explosion Data
Flash Point Non-Flam / C.O.C.
Flammable Limits N/A UEL: N/A
Extinguishing Media Foam, CO2, Dry Chemical
Special Fire Fighting Procedures Firefighters should wear a self contained breathing apparatus and full protective gear.
Unusual Fire and Explosive Hazards: Do not spray direct stream of water into product
as frothing and splattering may occur.
NFPA Hazard Rating (0=Insignificant, 1=Slight, 2=Moderate, 3=High, 4=Extreme)
Health: 1 Flammability: 1 Reactivity: 0 Special:
5. Physical Hazards
Threshold Limit Value 5 mg/m3 as oil mist. 1
Effects of Overexposure
Acute (short Term Exposure)
Eye contact May cause irritation seen as tearing and redness.
Skin Contact May cause mild irritation to sensitive individuals seen as itching and redness.
Ingestion May cause irritation with possible nausea, vomiting, and diarrhea.
Chronic (Long term exposure) No chronic data available. Medical conditions aggravated by exposure and pre-existing
respiratory and skin conditions such as asthma, emphysema, and dermatitis.
Target organs None known. There is no primary route of entry into the body, the primary route of
exposure is skin and eye contact.
Emergency First Aid Procedures
Inhalation Remove from the area to fresh air. Seek medical attention if respiratory irritation
develops or if breathing becomes difficult.
Eye Contact Rinse the eyes with water. Remove and contact lenses and continue flushing with plenty
of water for several minutes. Seek medical attention if irritation develops.
Skin Contact Wash effected areas with plenty of soap and water for several minutes. Seek medical
attention if irritation develops.
Ingestion Give three to four glasses of water, but do not induce vomiting. If vomiting occurs,
give fluids again. Seek medical attention if discomfort occurs.
Notes to Physician There is no specific antidote, treat the patient symptomatically.
6. Toxicity Information
Product contains chemicals listed as carcinogen or potential carcinogen by: IARC: No, NTP: No, OSHA: No, ACGIH: No, Other: No
White mineral oil Calcium Carbonate Zinc Oxide
Orl-Rat LD50: 92g/kg/92D-C 4 ORL-RAT LD50: 6450 mg/kg 3 ORL-RAT LD50: > 5000 mg/kg 3
SKN-RBT: 500 mg/24H MOD **3 IHL - RAT LC50: > 200 mg/Liter/Hr **3
EYE-RBT: 750 UG/24H SEV **3 SKN- RBT: 500 mg/24H MOD **3
EYE-RBT: 500 mg/24H MOD **3
**These values are for inhalation of dust. Due to the fact that the product has a greasy consistency, inhalation during normal use is very unlikely.
7. Reactivity Data
Stability: Stable
Conditions to Avoid None Known
Incompatibility ( Materials to avoid) Strong Oxidizers such as chlorine bleach and concentrated oxygen, strong acids and bases.
Hazardous Decomposition Products Oxides of carbon and acrid smoke fumes.
Hazardous Polymerization Will Not Occur
Conditions to Avoid N/A
8. Special Precautions and Spill Procedures
Steps to be taken if Material is
released or spilled Transfer solid into a properly labeled container for disposal.
Waste Disposal Methods Dispose of in accordance with all federal, state, and local regulations.
Neutralizing Agent N/A
9. Special Protection Information
Requires Ventilation General ventilation is normally adequate.
Respiratory Protection None required under normal conditions of use.
Protective Gloves None under normal conditions of use.
Eye Protection None under normal conditions of use.
Other Protection None under normal conditions of use.
10. Storage and Handling Information
Storage Temperature - Indoors
Minimum Temperature 32
Maximum Temperature 120
Handling and Storing Precautions Always store material in its original container. Keep container tightly closed when not in use.
Other Precautions Keep out of reach of children. Read the entire label before using the product. Follow
the label directions.
11. Regulatory Information
Chemical Name Cas Number Upper % Limit
Zinc Compounds N/A 15
Those ingredients listed above are subject to the reporting requirements of 313 of Title III & of the superfund Amendments and
Reauthorization Act of 1986 and 40 CFR part 372
Please call 1-588-260-6225 for additional information if you are a California customer. This MSDS is not intended for the state of
California.
12. References
1. Threshold limit values for chemical substances and physical agents and biological exposure indices, ACGIH, 1999.
2. OSHA PEL
3. Registry of toxic effects of chemical substances, CCINFODisc, 1999
4. Vendor鈥檚 MSDS.
All components in this product can be found in the current TSCA inventory.
IRR: Irritant, Flam/Flamm: Flammable, Comb: Combustible, Corr: Corrosive, Carc: carcinogenic, Tox:Toxic, N/A: Not Applicable,
N/E: Not Established, COC: Cleveland open cup, PMCC: Pensky-Martin Closed Cup, TCC: Tangliabue Closedcup, LEL: Lower
explosion limit, UEL:Upper Explosion Limit, NFPA: National Fire Protection Association, IARC: International Agency for the research
of Cancer, NTP: National Toxicology Program, Osha: Occupational Safety & Health Administration, ACHGIH:American Conference of
Governmental Industrial Hygienists, TLV: Threshold Limit Value, PEL: Permissible Exposure Level, STEL: ShortTerm Exposure Limit,
MLD:MIld, Mod: Moderate, Sev: Severe, Mut: Mutagenic, ASPHYX: Asphyxiate, PNOC: Particulates Not Otherwise Classified.
We believe the information contained herein is current and accurate as of this date of this Material Safety Data Sheet. Since the use of this information and these opinions and the
conditions of use of this product are not under the control of Anti-Seize R&D庐, Inc. or it鈥檚 agents or distributors, it is the user鈥檚 obligation to determine the conditions of safe use
of this product. The buyer should conduct its own tests of this product before use to determine proper preparation technique and suitability for proposed application. Anti-Seize
R&D庐, Inc. warrants that the product conforms with Anti-Seize R&D庐鈥檚 written specifications, and is free from defects and disclaims all other warranties, expressed or implied and
is not responsible for loss claim of damages resulting from the use of it鈥檚 products.
Rev 01/03
|