LPS LABORATORIES
MSDS
MATERIAL SAFETY DATA SHEET
Section 1 - Product Identification and Use
Manufacturer's Name: Trade Name:
LPS Laboratories LPS Citrus Degreaser
Address (Number Street): Chemical Family:
4647 Hugh Howell Road Blended Compound
Address (City, State, Zip): Part Numbers:
Tucker, GA 30085-5052 05020,05001,05005,05055
Telephone Number: 770-243-8800
Emergency Telephone Number: 1-800-424-9300 Chemtrec
Outside U.S.: (703) 527-3887
Hazardous Materials Description and proper shipping name (49 CFR 172.101):
Aerosol: CONSUMER COMMODITY ORM-D
Bulk: NOT REGULATED NMFC 50093 SUB 2 BRL/BXS CL55
TSCA Inventory: HMIS Labeling: Health: 1
All of the ingredients are listed on the TSCA inventory. Flammability: 2
Reactivity: 0
Section 2 - Hazardous Ingredients / Identity Information
ACGIH OTHER
Ingredients CAS Numbers %WW OSHA PEL TLV LIMITS
Petroleum Distillate 8052-41-3 30-50 100 ppm 100 ppm 200 ppm STEL
d-Limonene 5989-27-5 30-50 N.E. N.E. None
Carbon dioxide propellant (aerosol only) 124-38-9 2-3 10,000 ppm 5,000 ppm 30,000 ppm STEL
Section 3 - Physical / Chemical Characteristics
Boiling point (F潞): Approx. 315潞F Specific gravity (H20 = 1): .813
Vapor pressure ( mmHg) @ 100潞F : <5 Percent volatile by volume (%): 100
Vapor density (Air = 1): 4.8-5.3 Evaporation rate (n-Butyl Acetate= 1): 0.15
Solubility in water: Slight
Appearance and odor: Clear, colorless liquid with mild citrus odor.
Section 4 - Fire and Explosion Hazard
Flash point (method used): 105潞F TCC
Flammable limits (by volume 25潞 C): LEL 0.7% UEL 6.0%
Extinguishing media: Foam, dry chemical, or carbon dioxide. Do not use a direct stream of water.
Special fire fighting procedures: Self-contained breathing apparatus should be provided to fire fighters. Water fog may be
used to cool closed containers.
Unusual fire and explosive hazards: Intensive heat created by fire will cause aerosols to burst.
N.E. = Not established
N.A. = Not applicable
Section 5 - Health Hazard Data
Primary route(s) of entry: Inhalation, eyes.
Health hazard/effects of over exposure:
Inhalation: Headache, dizziness, nausea and anesthetic effects.
Eyes: Irritation.
Skin: Repeated or prolonged contact may cause drying and defatting of skin.
Ingestion: Low order of oral toxicity; however, minute amount aspirated into lungs during ingestion may cause severe
pulmonary injury.
Medical conditions aggravated by exposure: Pre-existing eye, skin and respiratory disorders may be aggravated.
Chemicals listed as potential carcinogen: NTP: No IARC: No OSHA: No
Emergency and first aid procedures:
Inhalation: Move to fresh air and contact physician. Administer oxygen if breathing is difficult.
Eyes: Flush eyes with plenty of water, contact a physician.
Skin: Wash with soap and water; apply medicated skin cream.
Ingestion: Do not induce vomiting. If vomiting occurs spontaneously, keep head below hips to prevent aspiration of liquid into
lungs. Get medical attention.
Section 6 - Reactivity Data
Stability: Stable Conditions to avoid: Avoid sparks or open flames. See handling and storage precautions.
Incompatibility (Materials to avoid): Strong oxidizing agents.
Hazardous decomposition products: Thermal decomposition may yield carbon monoxide.
Hazardous polymerization: Will not occur.
Section 7 - Precautions for Safe Handling and Use
Steps to be taken in case material is released or spilled: Ventilate area by opening doors and windows. Remove ignition sources.
Remove leaking container and transfer remaining product to another vessel. Prevent product from going into sewers and water
sources by diking or impounding. Using appropriate safety equipment, mop up or soak up with absorbent material, such as sand or
clay.
Waste disposal methods: Dispose of in accordance with local, state and federal regulations for petroleum distillates.
RCRA Hazardous Waste No.: This material has the RCRA characteristic of ignitability and would have the hazardous
waste number D001.
CERCLA Reportable Quantity: N.A.
SARA TITLE III Chemicals: None
Precautions to be taken in handling and storage: Store as Level 3 Aerosol (NFPA 30B). Store away from ignition sources and
avoid breathing vapors. Store bulk below 150掳 F and above 32掳 F.
Section 8 - Control Measures
Respiratory Protection: None required if good ventilation is maintained. For enclosed areas, use NIOSH approved organic vapor
cartridge respirator or self-contained breathing apparatus.
Ventilation: Local exhaust is usually adequate. However, mechanical ventilation should be used when spraying in enclosed areas.
Vapor concentration should be minimized as much as possible.
Protective gloves: Use solvent resistant gloves for liquid handling.
Eye protection: For spraying or splashing of solvent, use face shield or goggles.
Other protective equipment: As necessary to prevent prolonged or repeated skin contact.
Work/hygienic practices: Wash hands with soap and water after use and/or before breaks, lunch and at the end of work periods.
Remove contaminated clothing and launder before reuse.
Section 9 - Preparation Date of MSDS
The foregoing technical information and recommendations are compiled from sources that are believed to be accurate and reliable.
However, they are supplied without warranty or guarantee of any kind either expressed or implied. The purchaser is responsible for
selecting and determining the suitability of products for purchaser鈥檚 particular needs and we disclaim any responsibility for improper
applications or misuse of our products in any manner whatsoever.
February 14, 2003
Fred Fugitt, Technical Services Chemist
Ed Williams, Manager of Research and Development Form # 3502
LPS Laboratories MSDS LPS Citrus Degreaser
|