Page 1 of 3
Product Safety Data Sheet
1. PRODUCT AND COMPANY IDENTIFICATION 3. HAZARDS IDENTIFICATION
Product Numbers/Series: Emergency Overview
COHRLASTIC Silicone Rubber鈥擲ponge Rubber
Potential Health Hazards:
Other/Generic Names: SKIN: Wash hands with soap and water
Sponge Silicone Rubber
EYES: Not a likely route of entry
Manufacturer: INHALATION: Not a likely route of entry
Saint-Gobain Performance Plastics
INGESTION: Not a likely route of entry
14 McCaffrey St., PO Box 320
DELAYED EFFECTS: None known
Hoosick Falls, NY 12090-0320
For More Information: Ingredients found on one of the OSHA-designated
Product Safety Department: (518) 686-7301 carcinogen lists are listed below:
(8 AM to 5 PM, Eastern Time)
Ingredient Name NTP Status IARC Status OSHA Standard
N/A N/A N/A N/A
2. COMPOSITION / INFORMATION ON INGREDIENTS
4. FIRST AID MEASURES
Ingredient Name CAS # Weight %
Methylvinylpolysiloxane 68083-19-2 20鈥?80 N/A for material as supplied at room temperature.
Silicon dioxide 7631-86-9 15鈥?35
Woven fiberglass fabric N/A 10 5. FIRE FIGHTING MEASURES
(R10450)
Metal oxide non-toxic N/A FLASH POINT: N/A
0鈥?35
compound (R10404) AUTO IGNITION
Inorganic pigment N/A TEMPERATURE: 1500掳 F
0鈥?10
Iron oxide FLAMMABLE LIMITS
1309-37-1 0鈥?2
IN AIR (% BY VOL.): N/A, solid material
Methylvinylfluorosiloxane N/A 70
(R10490) EXTINGUISHING MEDIA: Use media appropriate to primary
source of fire.
Polyacrylate adhesive N/A 0鈥?10
UNUSUAL FIRE HAZARDS: Material is incombustible under
Polysiloxane adhesive N/A 0鈥?10
recommended conditions/toxic fluorine
Note: The above product(s) are considered 鈥渁rticles鈥? according to gasses form during combustion (R10490).
OSHA Hazard Communication Standard 29 CFR 1910.1200 and, as
such, are exempt from the material safety data sheet provisions of
6. ACCIDENTIAL RELEASE MEASURES
29 CFR 1910.1200 (G) (6). As a courtesy to the customer, Saint-Gobain
Performance Plastics has prepared this product safety data sheet to
N/A, solid material
provide appropriate safety and handling information. These products
are considered nonhazardous when used according to accepted practices
for the intended use. 7. HANDLING AND STORAGE
Store and handle using good warehouse practices.
Avoid excessive temperatures and high humidity.
AFF-1327-PDF-0604-SGCS
COHRLASTIC Silicone Rubber鈥擲ponge Rubber Page 2 of 3
8. EXPOSURE CONTROLS / PERSONAL PROTECTION 11. TOXICOLOGICAL INFORMATION
ENGINEERING CONTROLS: N/A IMMEDIATE (ACUTE) EFFECTS: No acute effects have been identified.
PERSONAL PROTECTIVE EQUIPMENT DELAYED (SUBCHRONIC
AND CHRONIC) EFFECTS: No delayed or chronic effects have
RESPIRATORY PROTECTION: Use appropriate NIOSH-approved
been identified.
respirator in presence of
decomposition fumes or dust. OTHER DATA: N/A
EYES AND FACE: Use of safety glasses is
recommended. 12. ECOLOGICAL INFORMATION
HANDS, ARMS, AND BODY: N/A
These materials are chemically unreactive, non-toxic, non-water
OTHER CLOTHING AND
soluble, and non-biodegradable.
EQUIPMENT: N/A
Exposure Guidelines
13. DISPOSAL CONSIDERATIONS
Guidelines exist for the following ingredients:
Ingredient Name ACGIH TLV OSHA PEL Other Limit OTHER DISPOSAL CONSIDERATIONS:
Dispose in an approved landfill or by incineration, in compliance with
N/A N/A N/A N/A
federal, state, and local regulations.
Other exposure limits for the decomposition products normally
associated with product use are as follows: N/A
14. TRANSPORT
9. PHYSICAL AND CHEMICAL PROPERTIES
US DOT HAZARD CLASS: N/A
US DOT ID NUMBER: N/D
APPEARANCE: Orange-tan, black, gray, red, brown, blue,
blue-gray, green, with or without adhesive.
PHYSICAL STATE: Solid 15. REGULATORY INFORMATION
MOLECULAR WEIGHT: N/A
Toxic Substances Control Act (TSCA)
CHEMICAL FORMULA: N/A
TSCA INVENTORY STATUS: All components are listed
ODOR: Odorless
on the TSCA Inventory.
SPECIFIC GRAVITY: N/D
OTHER TSCA ISSUES: None
SOLUBILITY IN WATER: Insoluble
SARA Title III / CERCLA
pH: N/A
Reportable Quantities (RQs) and/or Threshold Planning Quantities
BOILING POINT: N/A
(TPQs) exist for the following ingredients:
MELTING POINT: N/A
Ingredient Name SARA/CERCLA SARA EHS
VAPOR PRESSURE: N/A
N/A N/A N/A
VAPOR DENSITY: N/A
EVAPORATION RATE: N/A Spills/releases resulting in the loss of any ingredient at or above its
RQ requires immediate notification to the National Response Center
% VOLATILES: N/D
(1 (800) 424-8802) and to your Local Emergency Planning Committee.
FLASH POINT: N/A
SECTION 311 HAZARD CLASS: N/D
10. STABILITY AND REACTIVITY SARA 313 Toxic Chemicals
This product contains the following toxic chemicals subject to the
NORMALLY STABLE? Stable reporting requirements of section 313 of the Emergency Planning and
Community Right-To-Know Act of 1986 and of 40 CFR 372:
INCOMPATIBILITIES: N/A
CAS# Chemical Name % by Weight
HAZARDOUS
DECOMPOSITION PRODUCTS: Under commonly recommended None N/A N/A
conditions decomposition
State Right to Know
is not anticipated.
In addition to the ingredients found in section 2, the following are
HAZARDOUS POLYMERIZATION? Hazardous polymerization
listed for state right-to-know purposes:
will not occur.
CAS# Chemical Name % by Weight
N/A N/A N/A
AFF-1327-PDF-0604-SGCS
COHRLASTIC Silicone Rubber鈥擲ponge Rubber Page 3 of 3
ADDITIONAL REGULATORY INFORMATION: N/A
WHMIS CLASSIFICATION (CANADA): N/D
FOREIGN INVENTORY STATUS: N/D
16. OTHER INFORMATION
CURRENT ISSUE/REVIEW DATE: 4/1/04
PREVIOUS ISSUE/REVIEW DATE:
CHANGES TO MSDS FROM PREVIOUS
ISSUE DATE ARE DUE TO THE FOLLOWING:
4/1/04 consolidation of similar products
PUBLISHED BY: Document Control Department,
Saint-Gobain Corporation
PSDS NO. AFF-1327 N/D=not determined
N/A=not applicable Issue/Review date: 6/04
Saint-Gobain Performance
NOTE: The information in this document is provided free of charge and is based on technical data that
Plastics Corporation
Saint-Gobain Performance Plastics Corporation believes to be reliable. It is intended for use by persons having
14 McCaffrey Street.
technical skill, at their own discretion and risk. Because conditions of product use are outside our control, we
Hoosick Falls, New York 12090-0320
make no warranties, express or implied, and assume no liability in connection with any use of this
Customer Service: (800) 962-2666
information. Suitability for use in a particular application is the ultimate responsibility of the end-user.
Tel: (518) 686-7301
Fax: (800) 562-8479, (518) 686-4840
COHRlastic is a registered trademark.
漏2004 Saint-Gobain Performance Plastics Corporation
www.fff.saint-gobain.com
AFF-1327-PDF-0604-SGCS
|