MEGUIAR'S D170 - DETAILER HYPER DRESSING
ChemWatch Material Safety Data Sheet CHEMWATCH 4827-25
Issue Date: Tue 15-Mar-2005 CD 2005/1 Page 1 of 6
Section 1 - CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME
MEGUIAR'S D170 - DETAILER HYPER DRESSING
SYNONYMS
Manufacturer's Code: D170
PRODUCT USE
Maintenance product.
SUPPLIER
Company: Meguiar's Australia P/L
Address:
35 Slough Business Park
Holker St, Silverwater
NSW, 2128
AUSTRALIA
Telephone: (+61 2) 9737 9422
Telephone: 1800 804 182
Fax: 02 9737 9414
Section 2 - HAZARDS IDENTIFICATION
STATEMENT OF HAZARDOUS NATURE
NON-HAZARDOUS SUBSTANCE. NON-DANGEROUS GOODS.
According to the Criteria of NOHSC, and the ADG Code.
POISONS SCHEDULE
None
RISK
SAFETY
Section 3 - COMPOSITION / INFORMATION ON INGREDIENTS
NAME CAS RN %
no hazardous ingredients present [Meguiar's]
Section 4 - FIRST AID MEASURES
SWALLOWED
鈥? Immediately give a glass of water.
鈥? First aid is not generally required. If in doubt, contact a Poisons
Information Centre or a doctor.
continued...
MEGUIAR'S D170 - DETAILER HYPER DRESSING
ChemWatch Material Safety Data Sheet CHEMWATCH 4827-25
Issue Date: Tue 15-Mar-2005 CD 2005/1 Page 2 of 6
Section 4 - FIRST AID MEASURES
EYE
If this product comes in contact with eyes:
鈥? Wash out immediately with water.
鈥? If irritation continues, seek medical attention.
鈥? Removal of contact lenses after an eye injury should only be undertaken by
skilled personnel.
SKIN
If skin or hair contact occurs:
鈥? Flush skin and hair with running water (and soap if available).
鈥? Seek medical attention in event of irritation.
INHALED
鈥? If fumes or combustion products are inhaled remove from contaminated area.
鈥? Other measures are usually unnecessary.
NOTES TO PHYSICIAN
Treat symptomatically.
Section 5 - FIRE FIGHTING MEASURES
EXTINGUISHING MEDIA
鈥? There is no restriction on the type of extinguisher which may be used.
Use extinguishing media suitable for surrounding area
FIRE FIGHTING
鈥? Use water delivered as a fine spray to control fire and cool adjacent area.
鈥? Do not approach containers suspected to be hot.
鈥? Cool fire exposed containers with water spray from a protected location.
鈥? If safe to do so, remove containers from path of fire.
鈥? Equipment should be thoroughly decontaminated after use.
FIRE/EXPLOSION HAZARD
鈥? Non combustible.
鈥? Not considered a significant fire risk, however containers may burn.
Decomposition may produce toxic fumes of
carbon dioxide (CO2)
other pyrolysis products typical of burning organic material
FIRE INCOMPATIBILITY
Avoid contamination with oxidising agents i.e. nitrates, oxidising acids,
chlorine bleaches, pool chlorine etc. as ignition may result
HAZCHEM
None
Section 6 - ACCIDENTAL RELEASE MEASURES
EMERGENCY PROCEDURES
MINOR SPILLS
鈥? Clean up all spills immediately.
continued...
MEGUIAR'S D170 - DETAILER HYPER DRESSING
ChemWatch Material Safety Data Sheet CHEMWATCH 4827-25
Issue Date: Tue 15-Mar-2005 CD 2005/1 Page 3 of 6
Section 6 - ACCIDENTAL RELEASE MEASURES
鈥? Avoid breathing vapours and contact with skin and eyes.
鈥? Control personal contact by using protective equipment.
鈥? Contain and absorb spill with sand, earth, inert material or vermiculite.
鈥? Wipe up.
鈥? Place in a suitable labelled container for waste disposal.
MAJOR SPILLS
鈥? Clear area of personnel and move upwind.
鈥? Alert Fire Brigade and tell them location and nature of hazard.
鈥? Control personal contact by using protective equipment.
鈥? Prevent spillage from entering drains, sewers or water courses.
鈥? Recover product wherever possible.
鈥? Put residues in labelled containers for disposal.
鈥? If contamination of drains or waterways occurs, advise emergency services.
Personal Protective Equipment advice is contained in Section 8 of the MSDS.
Section 7 - HANDLING AND STORAGE
PROCEDURE FOR HANDLING
鈥? Limit all unnecessary personal contact.
鈥? Wear protective clothing when risk of exposure occurs.
鈥? Use in a well-ventilated area.
鈥? Avoid contact with incompatible materials.
鈥? When handling, DO NOT eat, drink or smoke.
鈥? Keep containers securely sealed when not in use.
鈥? Avoid physical damage to containers.
鈥? Always wash hands with soap and water after handling.
鈥? Work clothes should be laundered separately.
鈥? Use good occupational work practice.
鈥? Observe manufacturer's storing and handling recommendations.
鈥? Atmosphere should be regularly checked against established exposure standards
to ensure safe working conditions are maintained.
SUITABLE CONTAINER
鈥? Polyethylene or polypropylene container.
鈥? Packing as recommended by manufacturer
鈥? Check all containers are clearly labelled and free from leaks.
STORAGE INCOMPATIBILITY
Avoid contamination of water, foodstuffs, feed or seed.
Avoid reaction with oxidising agents
STORAGE REQUIREMENTS
鈥? Store in original containers.
鈥? Keep containers securely sealed.
鈥? Store in a cool, dry, well-ventilated area.
鈥? Store away from incompatible materials and foodstuff containers.
鈥? Protect containers against physical damage and check regularly for leaks.
鈥? Observe manufacturer's storing and handling recommendations.
continued...
MEGUIAR'S D170 - DETAILER HYPER DRESSING
ChemWatch Material Safety Data Sheet CHEMWATCH 4827-25
Issue Date: Tue 15-Mar-2005 CD 2005/1 Page 4 of 6
Section 8 - EXPOSURE CONTROLS / PERSONAL PROTECTION
EXPOSURE CONTROLS
Not available. Refer to individual constituents.
PERSONAL PROTECTION
EYE
鈥? Safety glasses with side shields
鈥? Chemical goggles.
鈥? Contact lenses pose a special hazard; soft lenses may absorb irritants and all
lenses concentrate them.
HANDS/FEET
Wear general protective gloves, eg. light weight rubber gloves.
OTHER
No special equipment needed when handling small quantities.
OTHERWISE:
鈥? Overalls.
鈥? Barrier cream.
鈥? Eyewash unit.
The local concentration of material, quantity and conditions of use determine
the type of personal protective equipment required. For further information
consult site specific CHEMWATCH data (if available), or your Occupational
Health and Safety Advisor.
ENGINEERING CONTROLS
General exhaust is adequate under normal operating conditions. If risk of
overexposure exists, wear SAA approved respirator. Correct fit is essential to
obtain adequate protection. Provide adequate ventilation in warehouse or closed
storage areas.
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE
Purple mildly alkaline liquid with a woody odour; mixes with water.
PHYSICAL PROPERTIES
Liquid.
Mixes with water.
Molecular Weight: Not Applicable Boiling Range (掳C): 100
Melting Range (掳C): Not Available Specific Gravity (water=1): 1.0
Solubility in water (g/L): Miscible pH (as supplied): 9
pH (1% solution): Not Available Vapour Pressure (kPa): 1.21 @ 20C
Volatile Component (%vol): Not Available Evaporation Rate: <1 BuAC = 1
Relative Vapour Density (air=1): >1 Flash Point (掳C): Not Applicable
Lower Explosive Limit (%): Not Applicable Upper Explosive Limit (%): Not Applicable
Autoignition Temp (掳C): Not Applicable Decomposition Temp (掳C): Not Available
continued...
MEGUIAR'S D170 - DETAILER HYPER DRESSING
ChemWatch Material Safety Data Sheet CHEMWATCH 4827-25
Issue Date: Tue 15-Mar-2005 CD 2005/1 Page 5 of 6
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
State: Liquid
Section 10 - CHEMICAL STABILITY AND REACTIVITY INFORMATION
CONDITIONS CONTRIBUTING TO INSTABILITY
鈥? Presence of incompatible materials.
鈥? Product is considered stable.
鈥? Hazardous polymerisation will not occur.
Section 11 - TOXICOLOGICAL INFORMATION
POTENTIAL HEALTH EFFECTS
ACUTE HEALTH EFFECTS
SWALLOWED
(No Oral LD50, any animal species) The material has NOT been classified by EC
Directives or other classification systems as "harmful by ingestion". This is
because of the lack of corroborating animal or human evidence. The material may
still be damaging to the health of the individual, following ingestion,
especially where pre-existing organ (eg. liver, kidney) damage is evident.
Present definitions of harmful or toxic substances are generally based on doses
producing mortality rather than those producing morbidity (disease, ill-health).
Gastrointestinal tract discomfort may produce nausea and vomiting. In an
occupational setting however, ingestion of insignificant quantities is not
thought to be cause for concern.
EYE
Although the liquid is not thought to be an irritant (as classified by EC
Directives), direct contact with the eye may produce transient discomfort
characterised by tearing or conjunctival redness (as with windburn).
SKIN
The material is not thought to produce adverse health effects or skin irritation
following contact (as classified by EC Directives using animal models).
Nevertheless, good hygiene practice requires that exposure be kept to a minimum
and that suitable gloves be used in an occupational setting.
INHALED
The material is not thought to produce adverse health effects or irritation of
the respiratory tract (as classified by EC Directives using animal models).
Nevertheless, good hygiene practice requires that exposure be kept to a minimum
and that suitable control measures be used in an occupational setting.
CHRONIC HEALTH EFFECTS
Long-term exposure to the product is not thought to produce chronic effects adverse to the
health (as classified by EC Directives using animal models); nevertheless exposure by all
routes should be minimised as a matter of course.
Meguiar's D170 - Detailer Hyper Dressing
Not available. Refer to individual constituents.
unless otherwise specified data extracted from RTECS - Register of Toxic Effects
continued...
MEGUIAR'S D170 - DETAILER HYPER DRESSING
ChemWatch Material Safety Data Sheet CHEMWATCH 4827-25
Issue Date: Tue 15-Mar-2005 CD 2005/1 Page 6 of 6
Section 11 - TOXICOLOGICAL INFORMATION
of Chemical Substances
Section 12 - ECOLOGICAL INFORMATION
Section 13 - DISPOSAL CONSIDERATIONS
鈥? Recycle wherever possible.
鈥? Consult manufacturer for recycling options or consult local or regional waste
management authority for disposal if no suitable treatment or disposal facility
can be identified.
鈥? Dispose of by: Burial in a licenced land-fill or Incineration in a licenced
apparatus (after admixture with suitable combustible material)
鈥? Decontaminate empty containers. Observe all label safeguards until containers
are cleaned and destroyed.
Section 14 - TRANSPORTATION INFORMATION
Shipping Name:
None
Dangerous Goods Class: None
UN/NA Number: None
ADR Number: None
Packing Group: None
Labels Required:
Additional Shipping Information:
International Transport Regulations:
IMO: None
HAZCHEM
None
Section 15 - REGULATORY INFORMATION
POISONS SCHEDULE
None
Section 16 - OTHER INFORMATION
This document is copyright. Apart from any fair dealing for the purposes of
private study, research, review or criticism, as permitted under the Copyright
Act, no part may be reproduced by any process without written permission from
CHEMWATCH. TEL (+61 3) 9572 4700.
Issue Date: Tue 15-Mar-2005
Print Date: Wed 16-Mar-2005
|