MINOLTA CORPORATION -- TONER (MAGENTA)
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CJGRW
MSDS NAME: TONER (MAGENTA)
Responsible Party
Name: MINOLTA CORPORATION
Address: 101 WILLIAMS DRIVE
City: RAMSEY NJ 07446-1217
Info Phone: 201-825-4000
Emergency Phone Number: LOC POIS CTL CTR
Resp. Party Other MSDS No.: ICP-027
Proprietary Ind: Y
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: MINOLTA CORPORATION
Address: 101 WILLIAMS DRIVE
City: RAMSEY NJ 07446
Phone: 201-825-4000
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Name: *** PROPRIETARY ***
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50:(ORAL,RAT) >2 G/KG.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: FOR HUMAN HEALTH: THIS TONER IS NOT CLASSIFIED AS A HUMAN
CARCINOGEN. NO SYMPTOMS EXPECTED WITH INTENDED USE. SEE TOXICOLOGICAL
INFORMATION.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS & TOXICOLOGICAL
INFORMATION.
First Aid: INHAL:IF SYMPS ARE EXPERIENCED, REMOVE SOURCE OF CONTAM OR MOVE
VICTIM TO FRESH AIR & OBTAIN MED ADVICE. SKIN:FLUSH W/GENTLY FLOWING
WATER (PREFERABLY LUKEWARM) & SOAP FOR 15 MINS OR UNTIL PARTICLE IS
REMOVED. IF IRRIT DOES OCCUR, OBTAIN MED ADVICE. EYES:DO NOT ALLOW VICTIM TO
RUB EYE(S). FLUSH W/GENTLY FLOWING WATER (PREFERABLY LUKEWARM) FOR AT LST 15
MINS OR UNTIL PARTICLE IS REMOVED. HAVE VICTI M LOOK RIGHT & LEFT, AND,
THEN UP & DOWN. IF IRRIT DOES OCCUR, OBTAIN MED ATTN. DO NOT ATTEMPT TO
MANUALLY REMOVE ANYTHING STUCK TO EYE(S). INGEST: IF IRRIT OR DISCOMFORT
OCCURS, OBTAIN MED ATTN IMMED . NOTE TO MD:NONE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PERSONAL PRECAUTIONS & ENVIRONMENTAL PRECAUTIONS:
NONE. METHODS FOR CLEANING UP: WIPE OFF WITH PAPER OR CLOTH. DO NOT USE
VACUUM CLEANER WHEN A LARGE AMOUNT IS RELEASED. IT, LIKE MOST FINELY DIVIDED
O RGANIC POWDERS, MAY CREATE A DUST EXPLOSION.
Waste Disposal Methods: PREPARATION (COMMUNITY PROVISIONS) & CONTAMINATED
PACKAGING: WASTE MAY BE DISPOSED OR INCINERATED UNDER CONDITIONS WHICH MEET
ALL FEDERAL, STATE & LOCAL ENVIRONMENTAL REGULATIONS.
Handling And Storage Precautions: SAFE HANDLING ADVICE: TRY NOT TO DISPERSE THE
PARTICLES. STORAGE CONDITIONS: KEEP CONTAINER CLOSED. STORE IN A COOL &
DRY PLACE. PACKING MATERIALS: BOTTLES OR CARTRIDGE DESIGNATED BY MINOLTA.
TECHNICA L MEASURES, PRECAUTIONS & INCOMPATIBLE PRODUCTS: NONE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Autoignition Temp Text: N/D/A
Lower Limits: NOT AVAIL
Upper Limits: NOT AVAIL
Extinguishing Media: CO*2, WATER SPRAY, FOAM & DRY CHEMICAL. EXTINGUISHING
MEDIA TO AVOID: FULL WATER JET.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). NO SPECIAL FIREFIGHTING PROCEDURES.
Unusual Fire/Explosion Hazard: IF DISPERSED IN AIR, LIKE MOST FINELY DIVIDED
ORG PWDRS, MAY FORM EXPLO MIXT. F LAMMABILITY:NO DATA AVAIL. OXIDIZING
PROPERTIES:NO DATA AVAIL. NFPA HAZ RATING(NATL FIRE PROT AGENCY(U.S.A.):
HLTH: 1; F LAMMABILITY: 1; REACTIVITY: 0. RATING(NATL PAINT & COATING
ASSOC(U.S.A): HLTH: 1; FLAMMABILITY: 1; REACTIVITY: 0.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT. FOR USE OTHER THAN NORMAL CUSTOMER-OPERATING PROCEDURES (SUCH AS
IN BULK TONER PROCESSING FACILITIES), NIOSH APPROVED RESPIRATORS MAY BE REQUI
RED.
Ventilation: NONE REQD W/INTENDED USE. CONTROL PARAMETERS (AS TDUST): OSHA PEL
(USA):15 MG/M3. ACGIH-TLV (USA):10 MG/M3. DFG-MAK (EC):6 MG/M3. WORKSAFE-TWA
(AUSTL):10 MG/M3.
Protective Gloves: IMPERVIOUS GLOVES (FP N).
Eye Protection: ANSI APPROVED CHEMICAL WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N). SKIN
PROTECTION: NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA EQUIPMENT.
Work Hygienic Practices: WASH HANDS AFTER HANDLING.
Supplemental Safety and Health: TOX INFO:EXPOS GRP & MIN TO MILD DEGREE OF
FIBROSIS WAS NOTED IN 22% OF ANIMALS IN MIDDLE (4 MG/M3) EXPOS GRP. BUT NO
PULM CHANGE WAS REPORTED IN LOWEST (1 MG/M3) EXPOS GRP, MOST RELEVANT LEVEL
TO POT ENTIAL HUMAN EXPOSURES. CARCINOGENICITY: IARC MONOGRAPHS, NTP (USA),
OSHA REGULATED (USA): NOT LISTED.
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: NO DATA AVAILABLE
Spec Gravity: 1.2; (BULK) 0.4.
Solubility in Water: NEGLIGIBLE
Appearance and Odor: SOLID, RED POWDER; FAINT ODOR. PARTICLE SIZE (U M): 5-15.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELECTRONIC DISCHARGE, THROWING INTO FIRE.
HAZARDOUS REACTIONS: DUST EXPLOSION, LIKE MOST FINELY DIVIDED ORGANIC
POWDERS.
Materials To Avoid: OXIDIZING MATERIALS.
Hazardous Decomposition Products: CO, CO*2.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
Toxicological Information: ACUTE TOX:LC50:(INHAL) NO DATA AVAIL. LD50:(DERMAL)
N/A. EYE IRRIT:MIN IRRIT (RABBITS). SKIN IRRIT:NOT IRRIT (RABBITS). SKIN
SENSITIZER:NO SIGNS (GUINEA PIG). MUTAGENICITY:NEG (AMES TEST). LOC EFTS:SE E
CHRONIC TOX. CHRONIC TOX:PRLNG INHAL OF EXCESSIVE DUST MAY CAUSE LUNG DMG. IT
IS ATTRIBUTED TO "LUNG OVERLOADING", GENERIC RESPONSE TO EXCESSIVE AMOUNTS OF
ANY DUST RETAINED IN LUNGS FOR PRLNG INTER VAL. USE OF THIS PROD, AS
INTENDED, DOES NOT RSLT IN INHAL OF EXCESSIVE DUST. IN STUDY IN RATS BY
CHRONIC INHAL EXPOS TO TYPICAL TONER, MILD TO MOD DEGREE OF LUNG FIBROSIS WAS
OBSERVED IN 92% OF RATS IN HIGH CONC (16 MG/M3) (SUPP DATA)
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
Transport Information: SPECIAL PRECAUTIONS: NONE. INFORMATION ON CODE AND
CLASSIFICATIONS ACCORDING TO INTERNATIONAL REGULATIONS: UN CLASSIFICATION:
NONE. LAND: RID (EC): NONE. ADR (EC): NONE. DOT (USA): NONE. INLAND WATERW
AYS: ADNR (RHINE R): NONE. SEA: IMDG: NONE. AIR: ICAO-TI: NONE. IATA-DGR:
NONE.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: 302 EXTREME HAZARDOUS SUBSTANCE: NONE. 311/312
HAZARD CATEGORIES: NONE. 313 REPORTABLE INGREDIENTS: NONE.
Federal Regulatory Information: U.S. INFORMATION: INFORMATION ON LABEL: NOT
REQUIRED. TSCA (TOXIC SUBSTANCES CONTROL ACT): ALL CHEMICAL SUBSTANCES IN
THIS PRODUCT COMPLY WITH ALL APPLICABLE RULES OR ORDER UNDER TSCA. EU
INFORMATION: INFORMATION ON LABEL (88/379/EEC & 67/548/EEC): SYMBOL
& INDICATION: NOT REQUIRED. R-PHRASE: NOT REQUIRED. S-PHRASE: NOT
REQUIRED. 76/769/EEC: ALL CHEMICAL SUBSTANCES IN THIS PRODUCT COMPLY WITH ALL
APPLICABLE RULES OR ORDER UNDER 76/769/EEC.
State Regulatory Information: CALIFORNIA PROPOSITION 65: THIS PRODUCT CONTAINS
NO CHEMICAL SUBSTANCES SUBJECT TO CALIFORNIA PROPOSITION 65.
=======================================================
Other Information
=======================================================
Other Information: SOFTENING POINT:85-100C. PARTITION COEFFICIENT,
N-OCTAGONAL/WATER:N/A. LITERATURE REFERENCES:ANSI Z400.1-1993. TRGS
220:SINCGERHEITSDATENBLATT FUR GEFAHRLICHE STOFFE UND ZUBEREITUNGEN. ISO
11014-1. CO MMISSION DIRECTIVE 91/155/EC. MSDS:PRACTICAL GUIDE TO FIRST
AID:CANADIAN CENTRE FOR OSHA'S PUBLICATION. IMPLEMENTATION MANUAL:NATL PAINT
& COATINGS ASSOC. H. MUHLE, B. BELLMANN, O. CREUTZENBERG, C. DASENBROCK,
H. ERNST, R. KILPPER, J.C. MACKENZIE, P. MORROW, U. MOHR, S. TAKENAKA &
R. MERMELSTEIN (1991). PULM RESPONSE TO TONER UPON CHRONIC INHAL EXPOS IN
RATS. FUNDAMENTAL & APPLIED TOX 17, PP. 280-299.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: TONER (MAGENTA)
Company: MINOLTA CORPORATION
Street: 101 WILLIAMS DRIVE
City: RAMSEY NJ
Zipcode: 07446
Health Emergency Phone: LOC POIS CTL CTR
Label Required IND: Y
Date Of Label Review: 03/31/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: NO SYMPTOMS EXPECTED WITH INTENDED USE. CHRONIC:
PROLONGED INHALATION OF EXCESSIVE DUST MAY CAUSE LUNG DAMAGE. IT IS
ATTRIBUTED TO "LUNG OVERLOADING", A GENERIC RESPONSE TO EXCESSIVE AMOUNTS O F
ANY DUST RETAINED IN LUNGS FOR A PROLONGED INTERVAL.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|