===================== Product Identification =====================
MSDS NAME:236B2534 BAR-RUST 236 MEDIUM GRAY BASE, DV236B20148
NIIN:00N093445
Status Code:A
MSDS Number: CJXZH
=== Responsible Party ===
Company:AMERON INTERNATIONAL PROTECTIVE COATINGS GROUP
Address:201 NORTH BERRY ST
City:BREA
State:CA
ZIP:92622-1020
Country:US
Info Phone Num:714-529-1951
Emergency Phone Num:800-424-9300 (CHEMTREC)
Preparer's Name:H. KLINE
Chemtrec Ind/Phone:(800)424-9300
CAGE:55849
=== Contractor Identification ===
Company:AMERON INTERNATIONAL PROTECTIVE COATINGS GROUP
Address:201 NORTH BERRY ST.
Box:City:BREA
State:CA
ZIP:92821
Country:US
Phone:714-529-1951
CAGE:55849
Company:FARWEST PAINT MANUFACTURING CO
Address:4522 S 133RD ST
City:TUKWILA
State:WA
ZIP:98168
Country:US
Phone:206-244-8844
CAGE:2F266
============= Composition/Information on Ingredients =============
Name:BISPHENOL A-BISPHENOL A DIGLYCIDYL ETHER POLYMER; (EPOXY
RESIN) (CONTAINS BENZENE AND EPICHLOROHYDRIN AS TRACE CONTAMINANTS)
(ALSO CAS # 67924-34-9). LD50: 20.000 G/KG.
CAS:25036-25-3
< Wt:25.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Name:BENZENE
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: <80% PPM
Other REC Limits:N/K
OSHA PEL:see 1910.1028
OSHA STEL:N/K
ACGIH TLV:32 MG/M3;10 PPM
ACGIH STEL:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Name:EPICHLOROHYDRIN; (EPCH)
CAS:106-89-8
RTECS #:TX4900000
Fraction by Wt: <1% PPM
Other REC Limits:N/K
OSHA PEL:19 MG/M3;5 PPM
OSHA STEL:N/K
ACGIH TLV:7.6 MG/M3;2 PPM
ACGIH STEL:N/K
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Name:QUARTZ; (SILICA (QUARTZ)) (CONTAINING BARIUM, LEAD,
CADMIUM, ARSENIC, ANTIMONY, SILVER, SELENIUM, AND MERCURY AS TRACE
CONTAMINANTS).
CAS:14808-60-7
RTECS #:VV7330000
< Wt:25.
Other REC Limits:N/K
OSHA PEL:see Table Z-3
OSHA STEL:N/K
ACGIH TLV:0.1 MG/M3
ACGIH STEL:N/K
Name:BARIUM
CAS:7440-39-3
RTECS #:CQ8370000
Fraction by Wt: 15% PPM
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:0.5 MG/M3
ACGIH STEL:N/K
Name:LEAD
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: <1% PPM
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:0.15 MG/M3
ACGIH STEL:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:CADMIUM
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: 0.5% PPM
Other REC Limits:N/K
OSHA PEL:see 1910.1027
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Name:ANTIMONY
CAS:7440-36-0
RTECS #:CC4025000
Other REC Limits:N/K
OSHA PEL:0.5 MG/M3
OSHA STEL:N/K
ACGIH TLV:0.5 MG/M3
ACGIH STEL:N/K
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:SILVER
CAS:7440-22-4
RTECS #:VW3500000
Fraction by Wt: <0.2% PPM
Other REC Limits:N/K
OSHA PEL:0.01 MG/M3
OSHA STEL:N/K
ACGIH TLV:0.1 MG/M3
ACGIH STEL:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:SELENIUM
CAS:7782-49-2
RTECS #:VS7700000
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:0.2 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:MERCURY
CAS:7439-97-6
RTECS #:OV4550000
Fraction by Wt: <0.1% PPM
Other REC Limits:N/K
OSHA PEL:see Table Z-2
OSHA STEL:N/K
ACGIH TLV:0.025 MG/M3
ACGIH STEL:N/K
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:TALC; (MAGNESIUM SILICATE) (CONTAINS QUARTZ SILICA AT <0.05
PPM)
CAS:14807-96-6
RTECS #:WW2710000
< Wt:20.
Other REC Limits:N/K
OSHA PEL:see Table Z-3
OSHA STEL:N/K
ACGIH TLV:2 MG/M3
ACGIH STEL:N/K
Name:MICA (CONTAINS >0.1% CRYSTALLINE SILICA)
CAS:12001-26-2
RTECS #:VV8760000
< Wt:10.
Other REC Limits:N/K
OSHA PEL:3 MG/M3
OSHA STEL:N/K
ACGIH TLV:3 MG/M3
ACGIH STEL:N/K
Name:LIGHT AROMATIC SOLVENT NAPHTHA (PETROLEUM); (HIGH FLASH
NAPHTHA) (CONTAINS BENZENE AS TRACE CONTAMINANT (<30 PPM)). VP: 2.7
MMHG @ 68F. LD50: 3.100 G/KG; LC50: 3670.000 PPM.
CAS:64742-95-6
RTECS #:WF3400000
< Wt:5.7
Other REC Limits:N/K
OSHA PEL:100 PPM
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Name:2,2-BIS(GLYCIDYLOXYPHENYL)PROPANE POLYMER; (EPOXY RESIN)
(CONTAINS EPICHLOROHYDRIN AS TRACE CONTAMINANT). LD50: 4.000 G/KG.
CAS:25085-99-8
< Wt:10.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Name:TITANIUM DIOXIDE (CONTAINS ALUMINUM HYDROXIDE AND AMORPHOUS
SILICA AS TRACE CONTAMINANTS). LD50: 10.000 G/KG; LC50: 6820.000
PPM. PIGMENT CONTENT IS DEPENDENT ON COLOR.
CAS:13463-67-7
RTECS #:XR2275000
< Wt:10.
Other REC Limits:N/K
OSHA PEL:15 MG/M3
OSHA STEL:N/K
ACGIH TLV:10 MG/M3
ACGIH STEL:N/K
Name:ALUMINUM HYDROXIDE
CAS:21645-51-2
RTECS #:BD0940000
= Wt:2.5
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:N/K
ACGIH STEL:N/K
Name:AMORPHOUS SILICA FUME; (AMORPHOUS SILICA)
CAS:69012-64-2
RTECS #:VV7312000
= Wt:3.
Other REC Limits:N/K
OSHA PEL:N/K
OSHA STEL:N/K
ACGIH TLV:2 MG/M3
ACGIH STEL:N/K
Name:1,2,4-TRIMETHYLBENZENE; (1, 2, 4-TRIMETHYL BENZENE). VP:
1.0 MMHG @ 68F.
CAS:95-63-6
RTECS #:DC3325000
< Wt:4.2
Other REC Limits:N/K
OSHA PEL:125 MG/M3; 25 PPM
OSHA STEL:N/K
ACGIH TLV:125 MG/M3; 25 PPM
ACGIH STEL:N/K
Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
< Wt:5.
Other REC Limits:N/K
OSHA PEL:5 MG/M3
OSHA STEL:N/K
ACGIH TLV:5 MG/M3
ACGIH STEL:N/K
Name:BUTYL ALCOHOL. VP: 4.3 MMHG @ 68F. LD50: 4.200 G/KG; LC50:
8000.000 PPM.
CAS:71-36-3
RTECS #:EO1400000
< Wt:2.6
Other REC Limits:N/K
OSHA PEL:300 MG/M3;100 PPM
OSHA STEL:N/K
ACGIH TLV:150 MG/M3; 50 PPM
ACGIH STEL:C152 MG/M3;C50 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENTS SECTION.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:VAP/SPRAY MIST/SPATTERED MATL CAN BE
HARMFUL. IRRITATING TO EYES, SKIN, & IF INHALED, TO NOSE & THROAT.
EXCESS/PRLNG INHAL CAN CAUSE HDCH, NAUS/DIZZ. RPTD & PRLNG OCCUP
OVEREXP TO SOLVS IS ASSOC W/PER M BRAIN & NERV SYS DMG. INTENTIONAL
ABUSE, MISUSE/OTHER MASSIVE EXPOS TO SOLVS MAY CAUSE MULTIPLE ORGAN
DMG &/OR DEATH. OVEREXP (PRLNG/RPTD USE) CAN AGGRAVATE/ACCENTUATE
ANY OF THESE EFTS. SKIN: IRRIT ANT. SENSIT/ALLERGIC RXN, SUCH AS
RASH/HIVES. CAN BE ABSORBED THRU SKIN. CAN CAUSE DEFAT & DRYING OF
SKIN. INHAL: IRRITANT. DELAYED LUNG INJURY. CNS DMG. RPTD EXPOS TO
SILICA DUST CAN CAUSE SILICOSIS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
MONOGRAPHS, VOLUME 68, 1998: GROUP 1. NTP 8TH ANNUAL REPORT ON
CARCINOGENS, 1998: REASONABLY ANTICIPATED TO BE HUMAN CARCINOGEN.
HUMAN: LUNG.
Effects of Overexposure:HLTH HAZS: CRYSTALLINE SILICA MAY CAUSE CANCER.
RISK OF CANCER DEPENDS ON DURATION & LEVEL OF EXPOS TO DUST FROM
SANDING SURFS/SPRAY MIST. SMOKING AGGRAVATES PROBLEMS. HIGH VAP
CONCS MAY CAUSE KIDNEY &/OR LIVER DMG. EYES: SEV IRRITANT. INGEST:
HARMFUL IF SWALLOWED. ASPIR INTO LUNGS CAN DMG LUNGS & CAUSE CHEM
PNEUM. TARGET ORGANS: KIDNEYS, LIVER, BLOOD, LUNGS, SKIN, EYES,
STOM, CNS. EPICHLOROHYDRIN , LEAD & MERCURY APPEAR ON THE NAVY
OCCUP CHEM REPRO HAZS LIST. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO .
Medical Cond Aggravated by Exposure:KIDNEYS, LIVER, SKIN, EYES,
RESPIRATORY, ALLERGIES, LUNGS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE NORMAL BREATHING.
TREAT SYMPTOMATICALLY. SEE PHYSICIAN. SKIN: WASH THOROUGHLY WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. CONSULT PHYSICIAN IF
IRRITATIO N PERSISTS. EYES: FLUSH IMMEDIATELY WITH PLENTY OF WATER
FOR AT LEAST 15 MINUTES AND GET MEDICAL ATTENTION. INGESTION: DRINK
1 OR 2 GLASSES OF WATER TO DILUTE. NEVER GIVE ANYTHING BY MOUTH TO
AN UNCON SCIOUS PERSON. DO NOT INDUCE VOMITING (UNLESS METHANOL;
LISTED IN INGREDIENTS SECTION). CONTACT PHYSICIAN OR POISON CONTROL
CENTER IMMEDIATELY. TREAT SYMPTOMATICALLY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:=42.2C, 108.F
Lower Limits:1.0%
Upper Limits:11.2%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE EQUIPMENT . WATER MAY BE USED TO COOL
CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP OR EXPLOSION WHEN
EXPOSED TO EXTRE ME HEAT.
Unusual Fire/Explosion Hazard:LOWEST FLASHING SOLVENT: 71-36-3.
FLAMMABILITY: OSHA: COMBUST - CLASS II. DOT: FLAMM. CLOSED CONTRS
MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT & PRESS BUILD-UP. MAY
PRODUCE FLOATING FIRE HAZ. ISOLATE FR OM ELECTRICAL EQUIP, SPARKS,
HEAT & OPEN FLAME. VAPS MAY SPREAD LONG DISTANCES, CAUSE FLASH
FIRE/IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. USE ABSORBENT, INERT, CLEANUP
MATERIALS. (DO NOT USE SAWDUST.) REMOVE ABSORBENT MATERIAL WITH
NON-SPARKING TOOLS. PLACE IN SEPAR ATE CONTAINER. KEEP OUT OF
SEWERS AND WATERWAYS. IF ENTRY IS THREATENED OR OCCURS, NOTIFY
LOCAL AUTHORITIES.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED, UPRIGHT WHEN
NOT IN USE. STORE IN COOL, DRY, WELL-VENTILATED AREA. AVOID
PROLONGED STORAGE TEMPERATURES ABOVE 100F.
Other Precautions:USE CAUTION WHEN POURING. AVOID BREATHING SANDING
DUST. DO NOT WELD OR FLAME CUT ON EMPTY CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH CERTIFIED RESP DESIGNED TO REMOVE
COMBINATION OF PARTICULATES (DUST/SPRAY MIST) & VAP. WHEN BRUSHING,
ROLLING/SPREADING SELECT APPROP RESP PROT FOR CNDTNS. FOR SPECIFIC
CNDTNS, REFER TO CUR RENT "NIOSH POCKET GUIDE TO CHEM HAZS". IN
CONFINED/RESTRICTED VENT AREAS USE AIR-LINE RESPS/HOODS. REFER TO
29 CFR, OSHA PARTS 1910.134 & 1915 FOR (SUP DAT)
Ventilation:IMPLEMENT ADMIN & ENGINEERING CTLS TO REDUCE EXPOS. PROVIDE
SUFFICIENT VENT IN VOL & PATTERN TO KEEP AIR CONTAM CONCS BELOW TLV
LIMS. REMOVE WELDING/ (SUP DAT)
Protective Gloves:WEAR IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYEWASH AND DELUGE SHWR MTG ANSI DESIGN
CRITERIA . DEPENDENT UPON APPLICATION WEAR RESISTANT COVERALLS,
GLOVES AND SHOE COVERINGS TO PREVENT SKIN CONTACT. USE EXPLOSION
AND SPARK-PROOF EQUIPMENT.
Work Hygienic Practices:CONSULT 29 CFR 1910.132, 133, 136, 138; ANSI
Z87.1, Z41. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING,
SMOKING OR USING TOILET. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. (OTHER INFO)
Supplemental Safety and Health
RESP PROT: COATING OPERATIONS; PART 1910.146 CONFINED SPACES; ANSI
Z88.2, PRACTICES FOR RESP PROT; 42 CFR, PART 84 PARTICULATE RESPS.
-- VENT: FLAME CUTTING DECOMP PRODS; FOLLOW CURRENT ANSI Z49.1, "S
FTY IN WELDING & CUTTING". REFER TO 29 CFR PARTS 1910 & 1915, FOR
COATING OPERATIONS; PART 1910.146, CONFINED SPACES.
================== Physical/Chemical Properties ==================
Boiling Pt:>100.C, 212.F
B.P. Text:212F TO 336F
Vapor Pres:SEE INGREDIENTS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Solubility in Water:NO
Appearance and Odor:LIQUID WITH SOLVENT ODOR.
Percent Volatiles by Volume:25.95
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS AND ALKALIES.
Stability Condition to Avoid:THIS PRODUCT IS STABLE UNDER NORMAL
STORAGE CONDITIONS. HEAT, OPEN FLAME, ARC OR SPARKS. AMINES UNDER
UNCONTROLLED CONDITIONS.
Hazardous Decomposition Products:BY FIRE, BURNING OR WELDING: CO, CO*2,
ALDEHYDES.
=================== Toxicological Information ===================
Toxicological Information:SEE INGREDIENTS SECTION. CRYSTALLINE SILICA
(RESPIRABLE SIZE, 10 MICRONS OR LESS). IARC MONOGRAPH ON THE
EVALUATION OF CARCINOGENIC RISK OF CHEMICALS TO HUMANS (VOL
42.1987) CONCLUDES THAT THERE IS SU FFICIENT EVIDENCE OF
CARCINOGENICITY TO EXPERIMENTAL ANIMALS AND LIMITED EVIDENCE OF
CARCINOGENICITY TO HUMANS - IARC CLASS 2A.
===================== Ecological Information =====================
Ecological:NO INFORMATION.
==================== Disposal Considerations ====================
Waste Disposal Methods:EPA WASTE NUMBER: D001. PLACE IN SEPARATE,
APPROPRIATE, CLOSED CONTAINER IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE, AND FEDERAL REGULATIONS. THIS MATERIAL HAS NOT BEEN
TESTED BY TOXICITY CHARACTE RISTIC LEACHING PROCEDURE (TCLP).
=================== MSDS Transport Information ===================
Transport Information:DOT PROPER SHIPPING NAME: PAINT. DOT HAZARD
CLASS: 3. HAZARD SUBCLASS: N/A. DOT UN/NA NUMBER: 1263. IMO: N/A.
PACKING GROUP: III.
===================== Regulatory Information =====================
SARA Title III Information:TOXIC CHEMICALS SUBJECT TO THE REPORTING
REQUIREMENTS OF SARA (40 CFR 355 AND 372): EPOXY RESIN, BENZENE,
1,2,4-TRIMETHYL BENZENE, BUTYL ALCOHOL.
Federal Regulatory Information:U.S. FEDERAL REGULATIONS: AS FOLLOWS -
TOXIC CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF CERCLA (40
CFR 302): HIGH FLASH NAPHTHA, 1,2,4-TRIMETHYL BENZENE, BUTYL
ALCOHOL. ALL INGREDIENTS ARE ON TSCA INVENTORY OR ARE EXEMPT.
OSHA: HAZARDOUS BY DEFINITION OF HAZARD COMMUNICATION STANDARD (29
CFR 1910.1200). INTERNATIONAL REGULATIONS: AS FOLLOWS - CANADIAN
WHMIS: THIS MSDS HAS BEEN PREPARED IN COMPLIANCE WITH CONTROLLED
PRODUCT REGULATIONS EXCEPT FOR USE OF THE 16 HEADINGS. CANADIAN
WHMIS CLA SS: NO INFORMATION AVAILABLE.
State Regulatory Information:CALIFORNIA TITLE 26: 22-12000 (PROP 65)
WARNING: THIS PRODUCT CONTAINS THE FOLLOWING CHEMICALS KNOWN TO THE
STATE OF CALIFORNIA TO CAUSE CANCER: BENZENE, SILICA
CRYSTALLINE-QUARTZ, LEAD, CADMIUM, ARSE NIC, ANTIMONY,
EPICHLOROHYDRIN. CALIFORNIA TITLE 26:22-12000 (PROP 65) WARNING:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICALS KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE BIRTH DEFECTS/OTHER REPRODUCTIVE HARM: LEAD,
MERCURY, BENZENE, EPICHLOROHYDRIN. NEW JERSEY RIGHT-TO-KNOW: NO
NON-HAZARDOUS MATERIALS ARE AMONG THE TOP FIVE INGREDIENTS.
PENNSYLVANIA RIGHT-TO-KNOW: NO NON-HAZARDOUS INGREDIENTS ARE
PRESENT AT >3%.
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|