Dymax Corporation
51 Greenwoods Rd, Torrington, CT 06790 Phone: (860) 482-1010 Fax: (860) 482-1308
MATERIAL SAFETY DATA SHEET
PRODUCT 6-602-Gel
I. PRODUCT IDENTIFICATION
NFPA Est: HMIS Est:
Product Name: 6-602-Gel Health: 2 Health 2
Synonyms: Polyurethane Oligomer Mixture Fire: 1 Flam: 1
React: 1 React: 1
II. COMPOSITION
Ingredient Concentration C.A.S. ACGIH TLV
% Number
High Boiling (Meth)Acrylate 30-40 PROPRIETARY --
Maleic Acid 1-4 110-16-7 --
Acrylic Acid 1-4 79-10-7 2 ppm
Acrylic Impact Modifier 6-10 PROPRIETARY --
Photoinitiator 0-1.0 24650-42-8 --
Polyurethane Oligomer 30-40 PROPRIETARY --
Silica Gel 1-4 67762-90-7 --
t-Butyl Perbenzoate 1-5 614-45-9 --
III. CHEMICAL AND PHYSICAL PROPERTIES
Vapor Pressure: 6 mm Hg at 30*C Vapor Density: Heavier Than Air
Solubility in Water: Specific Gravity: 1.11
Boiling Point: N.A. Appearance: Pale Yellow Paste
Odor: Mild
IV. FLAMMABILITY AND EXPLOSIVE PROPERTIES
Flash Point: > 200*F (P.M.C.C.)
Recommended Extinguishing Agents: Use water spray, foam, dry chemical, or CO2.
Hazardous Products Formed by Fire
or Thermal decomposition: Toxic fumes (oxides of carbon and nitrogen) may be
evolved upon exposure to heat or open flame.
Unusual Fire or Explosion Hazards: None
Compressed Gasses: None Pressure at Room Temp:
V. REACTIVITY DATA
Stability: Stable Hazardous Polymerization: May occur
Hazardous Decomp. Prod.: None
Incompatibility: Oxidizers, amines, strong Lewis or mineral acids,
thiosulfates. Smoke and toxic fumes may be evolved as a
result of uncontrolled exothermic reaction of large masses of
material reacting with curing agents, such as peroxides,
amines, or exposure to light.
VI. SPILL OR LEAK PROCEDURES
Dike area to prevent spreading. Absorb on vermiculite, sand or other
inert absorbing material. Dispose of as a chemical waste in accordance
with current local, state, and federal regulations.
VII. STORAGE AND HANDLING PROCEDURES
Storage: Avoid storage over 100* F, exposure to light, loss of dissolved air,
loss of polymerization inhibitor, contamination with incompatible
materials.
Handling: Avoid prolonged or repeated breathing of vapor.
Page 1
Dymax Corporation
51 Greenwoods Rd, Torrington, CT 06790 Phone: (860) 482-1010 Fax: (860) 482-1308
MATERIAL SAFETY DATA SHEET
PRODUCT 6-602-Gel
VIII. SHIPPING REGULATIONS
DOT and IATA Hazard Classification: Not Restricted Article
Proper DOT Shipping Name: Unrestricted
Identification Number: DOT - None IATA - None
IX. EMERGENCY TREATMENT PROCEDURES
Eye Irritation: Immediately flush eyes with plenty of water for at least 15
minutes. Get medical attention.
Skin Contact: In case of skin contact, wash thoroughly with soap and water.
Do not use organic solvents for cleanup as they may dry or
irritate the skin and act as a carrier for chemical absorption.
Inhalation: Remove affected person to fresh air.
Ingestion: Low toxicity; Get medical attention.
X. PERSONAL PROTECTION
Respiratory: Positive fresh air exhaust should be provided in the work area;
respiratory equipment is unnecessary in normal use.
Skin: Avoid skin contact. Wear gloves and impervious protective
clothing if frequent direct contact is likely.
Eyes: Do not wear contact lenses. Chemical safety goggles are
recommended.
XI. HEALTH HAZARD DATA
Potential Routes of Entry: Skin, eyes, inhalation.
Symptoms of Overexposure: Possible skin and eye irritation on contact.
Inhalation of vapors in an unventilated area may,
over time, induce headaches.
Exposure Limits: ACGIH OSHA OTHER
(TLV) (PEL)
Ingredients
Acrylic Acid 2 ppm -- --
Target Organs: Carcinogen:
NTP IARC OSHA
High Boiling (Meth)Acrylate -- NO NO NO
Maleic Acid -- NO NO NO
Acrylic Acid -- NO NO NO
Acrylic Impact Modifier -- NO NO NO
Photoinitiator -- NO NO NO
Polyurethane Oligomer -- NO NO NO
Silica Gel -- NO NO NO
t-Butyl Perbenzoate -- NO NO NO
Abbreviations:
N/A Not Applicable ALG Allergen
IRR Irritant KID Kidney
LIV Liver REP Reproductive
Page 2
Dymax Corporation
51 Greenwoods Rd, Torrington, CT 06790 Phone: (860) 482-1010 Fax: (860) 482-1308
MATERIAL SAFETY DATA SHEET
PRODUCT 6-602-Gel
XII. REGULATORY INFORMATION
Sara Listed Ingredients:
ACRYLIC ACID
TSCA Inventory: All Ingredients
STATE RIGHT-TO-KNOW
CALIFORNIA Proposition 65
This product does not contain materials which the State of California has
found to cause cancer, birth defects, or other reproductive harm.
MASSACHUSETTS Right-To-Know, Substance List (MSL) Hazardous Substances
and Extraordinary Hazardous Substances on the MSL must be identified when
present in products. Components present in this product at a level which
could require reporting under the statute are:
** NONE **
PENNSYLVANIA Right-To-Know, Hazardous Substance List Hazardous Substances
and Special Hazardous Substances on the List must be identified when
present in products. Components present in this product at a level which
could require reporting under the statute are:
** NONE **
OTHER REGULATORY INFORMATION:
** NONE **
ABBREVIATIONS:
ACGIH = American Conference of Governmental Industrial Hygienists
OSHA = Occupational Safety and Health Administration
TLV = Threshold Limit Value
PEL = Permissible Exposure Limit
NTP = National Testing Program
IARC = International Agency for Research on Cancer
NFPA = National Fire Protection Association
HMIS = Hazardous Materials Identification System
-- = No Data / Not Available
XIII. PREPARATION INFORMATION
Prepared By: Stephen E. Cantor, Ph.D.
Title: Laboratory Manager
24 Hr. Telephone: CHEMTREC 1-800-424-9300
REVISION DATE: January 26, 2001
================================================================================
To the best of our knowledge, the information contained herein is accurate.
However, Dymax Corporation does not assume any liability whatsoever for the
accuracy or completeness of the information contained herein. Final
determination of suitability of any material is the sole responsibility of the
user. All materials may present unknown health hazards and should be used with
caution. Although certain hazards are described herein, we cannot guarantee
that these are the only hazards that exist.
Page 3
|