Sodium Methylate Solution MSDS
I. MANUFACTURER鈥橲 NAME
Green Catalysts, Inc. Emergency Tel No. Address:
(201) 506-9109
55 Chipper Drive
Kendall Park, NJ 08824
Tel: (201) 506-9109
Chemical Name & Synonyms SODIUM METHYLATE
Trade Name & Synonynms SODIUM METHOXIDE SOLUTION
Formula CH3ONa
CAS No. 124-41-4
Chemical Family SODIUM ALKYLATES
II. HAZARDOUS INGREDIENTS
Materials or Components % Hazard Data (TLV, LD50, LC50, etc.)
Paints, Preservatives - N/A
& Solvents
Alloys & Metallic Coatings - N/A
Hazardous Mixtures of - Solution in Methanol
other liquids, solids, or gases
III. PHYSICAL DATA
Boiling Point (oC) 87oC for 25% Solution
Vapor Pressure 46
Vapor Density (Air=1) Not Established
Solubility in Water Reacts, highly soluble
Melting Range N/A
Speci铿乧 Gravity 0.94-0.96
Appearance & Odor White to pale yellow colored, clear
solution with methanolic caustic odor
Present Volatile, by Vol.(%) 71-75
Evaporation Rate N/A
pH of 0.5% Aq.Soln. 14
ISSUE DATE: August 24, 1998 MSDS No. :FP-002
Ref: FORM OSHA-20, U.S. Dept. of Labour 1 of 3
Sodium Methylate Solution MSDS
IV. FIRE & EXPLOSION HAZARD DATA
Flash Point 29oC
Ignition Temp. (Dust) N/A
Extinguishing Media Co2/Dry Chemical Powder
Unusual Fire & Explosion Hazards Avoid contact with moisture
Method Used Closed Cup
Flammable Limits(%V/V) Lower-5.6
Upper-26.6
Special Fire-铿乬hting procedures None Required
V. REACTIVITY DATA
Stability Stable under selective conditions
Incompatibility (materials to avoid) Water/O2/CO2/Acids
Hazardous Decomposition Products NaOH and Methanol
Hazardous Polymerization Will not occur
Conditions to avoid Exposure to high temp/Water/O2/CO2
Conditions to avoid N/A
VI. TOXICITY IDENTIFICATION
Oral Caustic Burns
Dermal-Acute Causes Burning
Eye Causes burning and redness,
can cause visual impairment
Carcinogenicity Not Reported
Parenteral Toxic
Chronic Causes Burning
Inhalation Irritant
Lethal Dose 30 ml+
VII. HEALTH HAZARD INFORMATION
EFFECTS OF EXPOSURE
Oral Ingestion Headache, nausea, burning sensation,
convulsions and death by poisoning
Eye Contact Burning sensation, can lead to blindness
and poisoning
Skin Contact Burning sensation, can lead to poisoning
Inhalation Irriation, burning sensation, pneumonitis,
poisoning
ISSUE DATE: August 24, 1998 MSDS No. :FP-002
Ref: FORM OSHA-20, U.S. Dept. of Labour 2 of 3
Sodium Methylate Solution MSDS
EMERGENCY FIRST AID
Oral Ingestion Wash mouth thoroughly; drink plenty of water;
seek medical advice
Eye Contact Flush eye with plenty of water; seek medical
attention, if irriation persists
Skin Contact Wash contacted area with water; remove
contaminated clothing & launder before re-use
Inhalation Wash externally a铿?ected part; seek source of
fresh air
VIII. SPILL OR LEAK PROCEDURES
Steps to be taken in case material is released or spilled:
Remove by sand and shovel into recovery drums. Wash area with dilute Acetic Acid to remove 铿乶al traces.
Waste Disposal Method
(Comply with applicable Federal / State / Local Regulations): Consider incineration.
IX. SPECIAL PROTECTION INFORMATION
Respiratory protection Mask (Alkali-resistant) or SCBA
Ventilation Local Exhaust - Normal ventilator;
Special - Flameproof;
Mechanical - general;
Others - not needed
Protective Gloves Rubber
Eye Protection Safety Glasses
Other Protective Equipment Apron, Safety Shoes
X. SPECIAL PRECAUTIONS
Precautions to be taken in Handling & Storing:
Store and handle in MS Tanks or Barrels which are designed to minimize leakage. Avoid entry of moisture and air;
keep away from source of heat and naked 铿俛mes; Handle under dry N2 only.
Other Precautions:
Explosion - proof equipment recommended for use with solution.
IMPORTANT NOTE (DISCLAIMER)
This MSDS is based on a limited review of literature and standard toxicology handbooks. This information is without warrant of any kind;
it may be used only as a supplement to literature or information already in your possession concerning this product. The determination
of whether and under what conditions the product should be used by your employees, is yours only to make.
ISSUE DATE: August 24, 1998 MSDS No. :FP-002
Ref: FORM OSHA-20, U.S. Dept. of Labour 3 of 3
|