Page 1 of 3
GraphLine Inc. 庐
1100 International Pkwy.
Suite 100 Sunrise FL 33323
MATERIAL SAFETY DATA SHEET
800-998-3200
IN CASE OF TRANSPORTATION EMERGENCY (Spill, Leak, Fire, Exposure, Accident)
Call CHEMTREC 1-800-424-9300 (24 Hour)
SECTION 1: IDENTIFICATION
Name: MITSUBISHI SDP-a OE DELETION PEN Revision 4/16/2004
Product Number 6018127005
Size 3 X 1 PENS Formula: PEN
SECTION 2: COMPOSITION / INFORMATION ON INGREDIENTS
C.A.S. # INGREDIENTS %
1- 5
141-82-2 MALONIC ACID
10- 20
7681-11-0 POTASSIUM IODIDE
50- 70
7732-18-5 WATER
20- 50
85959-68-8 DTPA - Fe (NH4) 2
EXPOSURE LIMITS OSHA ACGIH CANADA
TWA STEL TWA STEL TWA STEL
MALONIC ACID
POTASSIUM IODIDE None None None None None None
WATER None None None None None None
DTPA - Fe (NH4) 2
Source of Exposure Limit Data:
OSHA: Occupational Safety and Health Administration
ACGIH: American Conference of Governmental Industrial Hygienists
CANADA: Province of Alberta's Occupational and Health and Safety Act.
ADDITIONAL EXPOSURE INFORMATION
SKIN DESIGNATION * CARCINOGENS
CAS. NUMBER OSHA ACGIH CANADA IARC NTP OSHA PRIMARY HAZARD IDLH (ppm)
141-82-2 No No No
7681-11-0 No No No No No No Not classified None
7732-18-5 No No No No No No Not classified None
85959-68-8 No No No
* For substances designated as a 'Skin' hazard, protective measures are recommended to prevent or reduce skin absorbtion. These
measures may include the use of gloves, aprons, goggles or other equipment , as well as engineering controls or work practices.
SECTION 3: HAZARDS IDENTIFICATION
EYES CONTACT:
Irritant, may cause irritation-wear goggles.
SKIN CONTACT:
Irritant, prolonged exposure may cause irritation-wear rubber gloves.
INHALATION:
May cause nausea-wear protective mask. Mechanical exaust is recommended.
INGESTION:
ABBREVIATIONS: N/D= Not Determined - N/A= Not Applicable - N/E=Not Established
Product Number: 6018127005 REVISION: 4/16/200 Page 2 of 3
GraphLine
Acute toxicity data, may cause irritation of mucous membranes LD50 estimated by component over 2000 mg/kg (rat-
oral).
H.M.I.S. CODES: HEALTH: FIRE: REACTIVITY: PROTECTION:
SECTION 4: FIRST AID MEASURES
EYE CONTACT:
Immeditely wash with running water for at least 15 minutes. Call physician if necessary.
SKIN CONTACT:
Immediately wash with soap and water. Call physician if necessary.
INHALATION:
Take patient to fresh air.
INGESTION:
Wash mouth with water and call a physician immediately.
SECTION 5: FIRE FIGHTING MEASURES
NONE
Flash point (F) : FLAMMABILITY LEL- UEL-
Carbon dioxide, Dry chemical.
Extinguishing media:
Special fire fighting procedures :
Wear self-contained breathing apparatus and protective clothing to prevent contact with skin and eyes.
Unusual fire and explosion hazards :
Combustion will produce COx gas, iodine gas.
NATIONAL FIRE PROTECTION ASSOC. CODES
HEALTH: FIRE: SPECIAL:
REACTIVITY:
SECTION 6: ACCIDENTAL RELEASE MEASURES
SPILL RESPONSE:
Use appropriate protective equipment. Collect liquid into a suitable container and clean up with water.
SECTION 7: HANDLING AND STORAGE
Store in a cool dry place. Keep container tightly capped when not in use. Do not use hook, wear protective goggles,
mask and gloves. Keep out of reach of children.
SECTION 8: EXPOSURE CONTROLS / PERSONAL PROTECTION
VENTILATION: Ten room volumes is recommended under normal conditions. PROTECTIVE
EQUIPMENT: Chemical splash goggles, latex or neoprene gloves , mask , labcoat and eye wash station. Keep out of
reach of children.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
N/A 0 lbs./ Gallon
Boiling point (C) : Volatile Organic Compounds:
N/A N/A
Melting point: Vapor pressure:
N/A N/A
Percent volatile by volume : Vapor density:
Evaporation rate: N/A Good
Solubility in water:
Specific gravity (water = 1) : 1.196 pH: 3.1
Appearance : Dark brown viscous liquid Odor: Peculiar odor
SECTION 10: STABILITY AND REACTIVITY
ABBREVIATIONS: N/D= Not Determined - N/A= Not Applicable - N/E=Not Established
Product Number: 6018127005 REVISION: 4/16/200 Page 3 of 3
GraphLine
Stability: Stable Will not occur
Hazardous polymerization:
None
Incompatibility (materials to avoid):
Iodine gas.
Hazardous decomposition products:
SECTION 11: DISPOSAL CONSIDERATIONS
Treatment, storage transportation and disposal must be in accordance with Federal, State and local regulations. Burn in
a chemical incinerator equipped with an afterburner and scrubber.
SECTION 12: TRANSPORTATION INFORMATION
SHIPPING NAME: NOT REGULATED MATERIAL
UN ID-#: N/A PACKING GROUP: N/A
MAJOR CLASS: N/A PRIMARY LABEL: N/A
MINOR CLASS: N/A SECONDARY LABEL: N/A
REMARKS: NOT REGULATED MATERIAL
* Reference: CFR 49, Table 172.102 (highway)
SECTION 13: REGULATORY INFORMATION
CAS. NUMBER CERCLA SARA-EHS SARA-313 RCRA CAL-PROP 65 N.J. FLA.
141-82-2 No No No No No No Yes
7681-11-0 No No No No No No No
7732-18-5 No No No No No No No
85959-68-8 No No No No No No Yes
* Specific CAS Number references from these regulatory tables:
CERCLA: 40 CFR. Table 302.4 CAL-PROP 65: California Proposition 65, Developmental and Reproductiv
SARA-EHS: 40 CFR. 355 Appendices A B New Jersey Right to Know
SARA-313: 40 CFR. section 372.65 Florida Right to Know
RCRA: 40 CFR. section 261.3
SECTION 14: OTHER INFORMATION
None
Comments:
The data in this Material Safety Data form relates to the specific material designated herein and to the standard use of same in combination
with other materials or processes. The hazards covered are beleived to be those most likely to occur in the reasonable, contemplated, or
ordinary use of these chemicals. No warranty is made or implied in respect of other hazards which may occur as a result of unreasonable,
abnormal, or unusual usage, or non-standard application of these materials. The information accumulated herein is beleived to be accurate,
but GraphLine Inc. expressly denies any warranty to such effect. Customers or recipients are advised to confirm, in advance that the
information is current, applicable and suitable to their circumstances. This information is furnished as a service only.
ABBREVIATIONS: N/D= Not Determined - N/A= Not Applicable - N/E=Not Established
|