MATERIAL SAFETY DATA SHEET
Texas Correctional Industry NFPA HAZARD RATING
T
A division of the Fire Hazard
4- SEVERE
C Texas Department of Criminal Justice
3- SERIOUS 1
I
Health Hazard Reactivity
2- MODERATE 1 0
Date Issued: February 2008 1- SLIGHT
Supersedes: December 2007 Specific Hazard
0- INSIGNFICANT
SECTION 1 - PRODUCT AND COMPANY IDENTIFICATION
Product Name: TAB 600
General Use: Antimicrobial liquid lotion hand soap Emergency Telephone Numbers
Manufacturer Name: Galveston Texas Poison Control: 1-800-764-7661
Texas Correctional Industry
Soap & Detergent Plant Soap & Detergent Plant Lab: 281-490-1111
One Circle Drive MSDS available at: www.tci.tdcj.state.tx.us
Sugar Land, Texas 77478 Monday thru Thursday: 7 a.m. - 3 p.m.
SECTION 2 - HAZARDOUS INGREDIENT
ACGIH/OSHA (TWA)
Chemical/Common Name CAS No. PERCENT TLV PEL WHMIS
Ethanol 64-17-5 1-2 1000 ppm 1000 ppm N/D
88-04-0 ~0.6 5 mg/m3 N/D
Chloroxylenol (PCMX) N/D
N/A= Not Applicable ND = Not Determined
WHMIS 鈥? minimum amount necessary in a mixture to trigger reporting: 1% (hazardous chemical); 0.1% (extremely hazardous chemical)
SECTION 3 - PHYSICAL PROPERTIES
Vapor Pressure : N/D
Specific Gravity (water = 1) : 1.02
Solubility in Water : Complete
pH : 5.0 - 6.0
Approximately 2000 F
Boiling Point :
Appearance and Odor : Opaque, pearlescent, white viscous liquid with medicinal odor
SECTION 4 - FIRE AND HAZARD DATA
Flash Point (T.C.C.) : Not flammable
Flammable Limit : N/D
Physical Hazard : None
Extinguishing Media : Water, Foam, Dry Chemicals, or Carbon Dioxide
Fire Extinguishing Procedure : Use of respiratory equipment is recommended in enclosed areas
Fire and Explosive Hazard : None
1
TAB 600, Issued Date: February 2008
SECTION 5 - REACTIVE DATA
Hazardous Decomposition : May produce nitrogen oxides and ammonia; may also produce sulfur oxides such as sulfur
dioxide
Stability : Stable
Incompatibility : May react with strong acids or oxidizing agents
SECTION 6 - HEALTH HAZARD
Primary Route of Exposure : Eyes, Skin, oral, or inhalation
Signs and Symptoms of Over Exposure (acute)
Eyes : May cause eye irritation
Skin : Not Likely
Ingestion : May cause gastrointestinal irritation
Inhalation : Not Likely
Signs and Symptoms of Over Exposure (chronic) : None known
Medical condition aggravated by over exposure : Not known
Carcinogen or suspect of carcinogen ingredients : None
SECTION 7 - EMERGENCY AND FIRST AID PROCEDURE
Eyes : Flush with plenty of water for at least 15 minutes, until irritation subsides
Skin : Flush with large amount of water
Ingestion : Rinse mouth thoroughly, drink plenty of water
Inhalation : Not Likely
SECTION 8 - SPECIAL PROTECTION INFORMATION
Respiratory Protection : None
Ventilation Requirement : Yes
Protective Gloves : None
Eye Protection : Chemical goggles
SECTION 9 - SPILL OR LEAK PROCEDURES
Steps to be taken if released or spilled : Gather all materials practical for salvage or disposal. Rinse residue with water.
Waste disposal method : Any unsalvageable material must be disposed in compliance with local, state, and
federal laws and regulations.
SECTION 10 - STORAGE AND HANDLING
鈥? Store in a cool, dry ventilated area. Do not store in direct sunlight.
鈥? Do not allow this product to freeze. Keep out of the reach of children.
Note: Product should be used as directed on the label. No warranty is implied expressly or otherwise regarding the accuracy of the
information in the product鈥檚 suitability for the consumer鈥檚 use and the outcome of its use. The technical accuracy of the information
submitted herein is based on the data submitted to TCI by the manufacturers for the materials used in this finished product.
2
|