MATERIAL SAFETY DATA SHEET
Johnsens Smoke Eliminator
Trade Name:
4626
MSDS NO.
Revision Date: 11/30/2000
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Trade Name: Johnsens Smoke Eliminator
Chemical Family: PETROLEUM HYDROCARBON OIL
Synonyms: None
Emergency Telephone (24 hr.): CHEMTREC 1-800-424-9300
Supplier:
Technical Chemical Company, P.O. Box 139, Cleburne, Texas 76033
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredient/CAS No. wt. % OSHA PEL OSHA PEL ACGIH TLV ACGIH TLW
TWA Ceiling Limits TWA STEL
Heavy Hydrotreated Naphthenic 90-97 Not known Mist 5 mg/m3 TLV Mist 5 mg/m3 8 Not Known
Distillates (petroleum) HR.
64742-52-5
Proprietary Oil Soluble Polymer 3-10 None Known None Known None Known None Known
Blend
Proprietary
3. HAZARDS IDENTIFICATION
Emergency Overview: Primary Route of entry is Skin. Tests on similar materials suggest that no eye or skin short-term exposure effects are
expected. Personnel with pre-existing skin disorders should avoid contact with this product. Tests on similar materials
indicate no significant adverse effects expected by ingestion. This material is practically non-toxic.
4. FIRST AID MEASURES
Eye Contact: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical attention if irritation
persists.
Ingestion: Product is practically non-toxic. If swallowed, do NOT induce vomiting. Call a physician immediately. Never give
anything by mouth to an unconscious person.
Inhalation: Not likely to occur except a mist. If inhaled, remove to fresh air. If not breathing give artificial respiration, preferably
mouth-to-mouth. If breathing is difficult give oxygen. Get medical attention.
Skin Contact: Wash with soap and water. Remove contaminated clothing and launder before reuse. Get medical attention if irritation
persists.
5. FIRE FIGHTING MEASURES
Flammable Properties
Flash Point 掳F(掳C): >360 F
Flash Point Method: COC
Flammable Limits in Air - Lower (%): Not Determined
Flammable Limits in Air - Upper (%): Not Determined
Autoignition Temperature 掳F(掳C): >650 A
Extinguishing Media: Water fog, carbon dioxide, foam, dry chemical Water fog and foam may cause frothing and
spattering.
Protection Of Fire-Fighters:
Special Fire-Fighting Procedures: Wear approved positive-pressure self-contained breathing apparatus and protective clothing. This
product is slightly combustible. If heated above its flash point will release flammable vapors which
can burn in the open or be expolosive in confined spaces if exposed to ignition source. Mists or
sprays may be flamable below oil's normal flash point. Keep away from extreme heat or open flame.
Hazardous Combustion Products: Carbon Dioxide. Fumes and Smoke.
Aerosol Comments: Not Applicable
6. ACCIDENTAL RELEASE MEASURES
Personal Precautions: Wear appropriate protective clothing and equipment to prevent skin and eye contact.
Spill Procedures: Avoid all sources of ignition; heat, sparks and open flames. Contain any liquid from leaking containers. Ventilate spill
area. Soak up material with absorbent and place in chemical waste container.
Wipe, scrape or soak up in an inert material and put in a container for disposal. Wear proper protective equipment as
specified in the protective equipment section.
Environmental Precautions: Do not allow to enter sanitary drains, sewer or surface and subsurface waters.
Page 1 of 3
Trade Name: Johnsens Smoke Eliminator MSDS NO. 4626
7. HANDLING AND STORAGE
Handling and Keep away from heat and open flame. Wash thoroughly with soap and water after handling. Wash hands before eating, drinking,
Storage: chewing gum, using tobacco or using the toilet. Avoid extreme temperatures. Keep container closed when not in use. Remove
clothing immediately if the product gets inside. Then, wash thoroughly and put on clean clothing.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering Controls: Use local exhaust. Showers. Eyewash stations.
Eyes: Wear safety glasses or goggles to protect against exposure.
Skin Protection: Use chemical resistant gloves for prolonged skin contact. PVC coated apron or clothing. Nitrile coated apron or
clothing. Neoprene coated apron or clothing.
Respiratory Protection: Use in a well ventilated area. Appropriate respiratory protection shall be worn when applied engineering controls
are not adequate to protect against inhalation exposure.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Colorless to light yellow liquid
Odor: SLIGHT PETROLEUM pH Value: Neutral
Vapor Pressure: <.001 mm Hg @ 20C Vapor Density (Air=1): >5
Boiling Point (掳F): >500 F Melting/Freezing Point: Not determined.
Solubility in Water: NEGLIGIBLE Bulk Density at 20掳C: Not Determined
Molecular Weight: Mixture Evaporation Rate: 1000 X slower than ethyl ether
Viscosity: 900 cst @ 100 C Specific Gravity (H20=1): .90
VOC Content(%): Negligible Decomposition Temperature: Not Known
10. STABILITY AND REACTIVITY
Chemical Stability: STABLE.
Conditions to Avoid: Avoid any source of ignition.
Materials to Avoid: Strong oxidizers
Hazardous Decomposition Products: Carbon dioxide. and other asphxiants.
Hazardous Polymerization: WILL NOT OCCUR
11. TOXICOLOGICAL INFORMATION
Toxicological Data:
Ingredient/CAS No. wt. % Route Species Dose
Heavy Hydrotreated Naphthenic 90-97 NA NA Not known.
Distillates (petroleum)
64742-52-5
Proprietary Oil Soluble Polymer 3-10 NA NA Not known.
Blend
Proprietary
Carcinogenicity:
Ingredient/CAS No. wt. % IARC NTP OSHA
Heavy Hydrotreated Naphthenic 90-97 Not Listed Not Listed Not Listed
Distillates (petroleum)
64742-52-5
Proprietary Oil Soluble Polymer 3-10 Not Listed Not Listed Not Listed
Blend
Proprietary
12. ECOLOGICAL INFORMATION
Ecological testing has not been conducted on this product.
13. DISPOSAL CONSIDERATION
Waste Classification: This product is not a RCRA hazardous waste if uncontaminated. If "used" RCRA criteria must be determined.
Page 2 of 3
Trade Name: Johnsens Smoke Eliminator MSDS NO. 4626
Waste Management: Not determined.
Disposal should be made in accordance with federal, state and local regulations. Incineration recommended in
approved incinerator according to federal, state, and local regulations.
14. TRANSPORTATION INFORMATION
U.S. DOT:
Proper Shipping Name: Not Applicable
Hazard Class: Not Regulated
UN/NA Number: Not Applicable
DOT Packing Group: Not Applicable
IMDG:
Proper Shipping Name: Not Applicable
Hazard Class: Non-hazardous
Hazard Subclass: Not Applicable
UN No.: Not Applicable
Packing Group: Not Applicable
Marine Pollutant: No
15. REGULATORY INFORMATION
US Federal Regulations:
Ingredient/CAS No. wt. % SARA 313 SARA 302 RQ TPQ
Heavy Hydrotreated Naphthenic 90-97 Not Listed Not Listed NA NA
Distillates (petroleum)
64742-52-5
Proprietary Oil Soluble Polymer 3-10 Not Listed Not Listed NA NA
Blend
Proprietary
SARA 311/312 Hazard Catagories: Immediate (Acute) Health Effects - NO, Delayed (Chronic) Helath Effects - NO.
State Regulations:
Ingredient/CAS No. wt. % California Prop. 65 California Prop. 65 California Prop. 65 California Prop. 65
Cancer list Developmental Reproductive Female Reproductive Male
Toxicity
Heavy Hydrotreated Naphthenic 90-97 Not Listed Not Listed Not Listed Not Listed
Distillates (petroleum)
64742-52-5
Proprietary Oil Soluble Polymer 3-10 Not Listed Not Listed Not Listed Not Listed
Blend
Proprietary
U.S. TSCA: The components of this product are listed on the TSCA Inventory.
16. OTHER INFORMATION
General Notes: Do not allow undiluted material or large quantities to reach groundwater, bodies of water or sewer system.
Disclaimer:
The information and recommendations contained herein are based upon tests believed to be reliable. However, Technical Chemical Company does not
guarantee their accuracy or completeness NOR SHALL ANY OF THIS INFORMATION CONSTITUTE A WARRANTY, WHETHER EXPRESSED OR
IMPLIED, AS TO THE SAFETY OF THE GOODS, THE MERCHANTABILITY OF THE GOODS, OR THE FITNESS OF THE GOODS FOR A
PARTICULAR PURPOSE. Adjustment to conform to actual conditions of usage may be required. Technical Chemical Company assumes no
responsibility for results obtained or for incidental or consequential damages, including lost profits, arising from the use of these data. No warranty
against infringement of any patent, copyright or trademark is made or implied.
Page 3 of 3
|