INC.
CHEMTRONICS MSDS #0605
Company Address:
8125 Cobb Center Drive
Kennesaw, GA 30144
Product Information: 800-TECH-401 Emergency: (Chemtrec) 800-424-9300
Customer Service: 800-645-5244 Revision Date: May 19, 1993
Prepared by: Michael S. Watkins
Product Identification
KONTACT RESTORER
Product Code: C610, C1610
Product Ingredient Information CAS# Wt. % Range
Carbon dioxide 124-38-9 1.0-5.0
804-47-5 1.0-5.0
Mineral Oil
Trichlorofluoromethane 75-69-4 90.0-95.0
Hazard Identification
Emergency Overview: Clear, colorless liquid with strong ethereal odor. This product is nonflammable. Liquid
will irritate eyes and skin under repeated or prolonged exposure. Breathing high concentrations of product vapor
may produce drowsiness and a headache.
Potential Health Effects:
Eyes: Liquid, aerosols and vapors of this product are irritating and can cause pain, tearing, reddening and
swelling accompanied by a stinging sensation.
kin: Contact causes skin irritation.
Ingestion:, Harmful if swallowed. Irritating to mouth, throat and stomach. May cause vomiting.
Inhalation:, Harmful if inhaled. High concentrations of vapors in immediate area can displace oxygen and can
cause dizziness, unconsciousness, and even death with longer exposure. Keep people away from such vapors
without self-contained breathing apparatus.
Pre-Existing Medical Conditions Aearavated by Exposure: Heart, lung, skin, eye.
First Aid
Eyes: Immediately flush with plenty of water. After initial flushing, remove any contact lenses and continue
flushing for at least 15 minutes. Have eyes examined and tested by medical personnel if irritation develops or
persists.
kin鈥? Wash skin with soap and water. Remove contaminated clothing. Get medical attention if irritation
develops or persist. Wash clothing separately before reuse.
Ingestion: Swallowing less than an ounce will not cause significant harm. For larger amounts, do not induce
vomiting, but give one or two glasses of water to drink and get immediate medical attention.
Inhalation: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen.
Get medical attention.
Page 1 of 4
CHEMTRONICS INC. MSDS #0605
and Explosion Information
Flash Point: None to boiling (TCC) LELIUEL: Not established (% by volume in air)
Extinguishing Media: Use alcohol foam, carbon dioxide, or water spray when fighting fires involving this
material.
Fire Fighting Instructions: As in any fire, wear self-contained breathing apparatus (pressure-demand,
MSHA/NIOSH approved or equivalent) and full protective gear.
Accidental Release Measures
Large Spills: Shut off leak if possible and safe to do so. Wear self-contained breathing apparatus and
appropriate personal protective equipment. Absorb spill with inert material (e.g. dry sand or earth), then place in
a chemical waste container for proper disposal. Do not flush to sewer. Avoid runoff into storm sewers and
ditches which lead to waterways.
Small Spills: Absorb spill with inert material (e.g. dry sand or earth), then place in a chemical waste container for
proper disposal.
Handling and Storage Information
Avoid prolonged or repeated contact with eyes, skin, and clothing. Wash hands before eating. Use with
adequate ventilation. Avoid breathing product vapor or mist. Do not reuse this container. Store in a cool dry
place away from heat, sparks and flame. Keep container closed when not in use. Do not store in direct sunlight.
KEEP OUT OF REACH OF CHILDREN.
posure Information/Personnel Protection
Exposure Guidelines:
ACGIH TWA OSHA PEL ACGIH STEL
CHEMICAL NAME
NA NA NA
Mineral Oil
NA NA C1,000ppm
Trichlorofluoromethane
Carbon dioxide 5,000ppm 30,000ppm 10,000 ppm
1,000ppm NA 1,000ppm
Chlorodifluoromethane
(All values listed are from the ACGIH Guide to Occupational Exposure Values - 1991).
Work/Hygienic Practices: Good general ventilation should be sufficient to control airborne levels. Local exhaust
ventilation may be necessary to control any air contaminants to within their TLVs during the use of this product.
This material does not have established exposure limits. Wear a positive pressure air-supplied respirator in
situations where there may be potential for airborne exposure. Wear safety glasses with side shields (or goggles)
and a full face shield. Wear rubber or other chemically resistant gloves when handling this material.
NFPA and HMI5 Codes:
NFPA HMIS
Health 1 1
Flammability 0 0
Reactivity 1
1
Personal Protection B
Page 2 of 4
MSDS #0605
Toxicological Information
Inhalation: Ingestion: No information available.
Trichlorofluoromethane TCLo/human 50,000ppm
(All values listed are from the NIOSH RTECS 1985-1986)
Physical and Chemical Properties
Physical State: Clear, colorless liquid Solubility in Water: Negligible
Odor: Faint solvent Specific Gravity: (Water =1) 1.48
pH NA Evaporation Rate: >1
Vapor Pressure: 36 mm Hg (Butyl acetate=l)
(Air = 1) Viscosity: NA
Vapor Density: 4.9 @ 77掳F (Air = 1)
(Air = 1) Percent Volatile: 100%
Boiling Point: 90掳F Melting Point: NA
Stability and Chemical Properties
Stability - This product is stable. Conditions to Avoid: Do not spray near
open flames, red hot surfaces or other
sources of ignition.
compatibility: Do not mix with powdered alkali and alkaline earth metals or strong oxidizing agents.
Products of Decomposition: Thermal decomposition may release carbon monoxide, carbon dioxide and
incompletely burned hydrocarbons.
Hazardous Polymerization: Will not occur
Conditions to Avoid: NA
Disposal Considerations
Dispose of in accordance with all federal, state and local regulations. Water runoff can cause environmental
damage.
Transportation Information
Proper Sub. Pkg. Hazard Pkg. Max.
Shipping Name UN Number Class Risk Group Label _ Instr. Quantity
2 NA III
Air: 75 k.g; 150k.g.
UN 1950 Non-flammable 203
Aerosols non-flammable n.o.s.
Gas Y203 30 kg
Ground: Consumer Commodity 173.306
NA ORM-D NA NA ORM-D Pkg.
ORM-D 173.150
Auth.
173.153
Page 3 of 4
CHEMTRONICS INC. MSDS #0605
gulatory Information
SECTION 313 SUPPLIER NOTIF ICATION
This product contains the following toxic chemicals subject to the reporting requirements of Section 313 of the
Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 372).
Chemical Name CAS# Wt. % Range
Trichlorofluoromethane 75-69-4 90.0-95.0
This information should be included on all MSDSs copied and distributed for this material.
TOXIC SUBSTANCES CONTROL ACT (TSCA).
All ingredients of this product are listed on the TSCA Inventory.
Other Information
Product is a Level 1 aerosol. Do not puncture or incinerate containers. Normal ventilation for standard
manufacturing practices is usually adequate. Local exhaust should be used when large amounts are released.
Label information: Carton should carry a Hazard Label: Nonflammable Gas
Environmental Impact Information Environmental Impact Data
(percent by weight)
Avoid runoff into storm sewers and ditches which lead to
waterways. Water runoff can cause environmental damage.
CFC 92.4% VOC 0.0.%
REPORTING HCFC 0.0% HFC 0.0%
US regulations require reporting spills of this material that Cl. Solv. ODP 0.92
0.0%
could reach any surface waters. The toll free number for
For more information call:
the US Coast Guard National Response Center is:
1-800-424-8802 1-800-645-5244
To the best of our knowledge, the information contained herein is accurate. However, all materials may present
unknown hazards and should be used with caution. In particular, improper use of our products and their
inappropriate combination with other products and substances may produce harmful results which cannot be
anticipated. Final determination of the suitability of any material is the sole responsibility of the user. Although
certain hazards are described herein, we cannot guarantee that these are the only hazards that may exist.
Page 4 of 4
|