This MSDS complies with OSHA'S Hazard Communication standard 29 CFR 1910.1200 and OSHA Form 174 PWWB
IDENTITY AND MANUFACTURER'S INFORMATION
NFPA Rating: Health- ; Flammability- ; Reactivity ; Special- HMIS Rating: Health- ; Flammability- ; Reactivity- ; Personal Protection-
DOT Hazard Classification: Consumer Commodity ORMD 48580 Sub 3 (4x1)
Manufacturer's Name: DYNAFLUX, INC.
241 Brown Farm Rd. 5 gal up: Flammable Liquid, N.O.S., (Petroleum Distillates),3, UN1993,III
Identity (trade name as used on label):
Cartersville, GA 30120 CRACK CHECK PWW PENETRANT
Date Prepared: 5/1/96 Prepared By: GS MSDS Number: PWWB Revision: 15-Aug-02
Information Calls: (800)334-4420 NOTICE: JUDGMENT BASED ON INDIRECT TEST DATA
Emergency Response Number: CHEMTEL 1(800)255-3924
SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATION
COMPONENTS-CHEMICAL NAMES AND COMMON NAMES CAS SARA OSHA PEL ACGIH Carcinogen
(Hazardous Components 1% or greater; Carcinogens 0.1% or greater) NUMBER III LIST (PPM) TLV (ppm) Ref. source*
Aromatic Hydrocarbons 8030-30-6 100 100 d
Aliphatic Hydrocarbons 64742-96-7 500 500 d
Xylol 1330-20-7 100 100 d
Disazo Dye Blend Not Assigned NE NE d
NA NA d
SECTION 2 - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: 360 degrees Specific Gravity (H2O=1): 0.9695
Vapor Pressure:(PSIG @ 70 F (Aerosols): Vapor Pressure:(Non-Aerosols)(mm Hg and Temperature): NA
Vapor Density:(Air=1): Evaporation Rate (BUAC=1):
NA NA
Solubility in Water: Negligible Water Reactive: None
Appearance and Odor: red liquid with hydrocarbon odor
SECTION 3 - FIRE AND EXPLOSION HAZARD DATA
FLAMMABILITY as per USA FLAME Auto Ignition Temperature Flammability Limits in Air by % in Volume:
PROJECTION TEST (aerosols) NA %LEL: 0.8 %UEL: --
FLASH POINT AND METHOD USED (non-aerosols): 148 F TCC
EXTINGUISHER MEDIA: CO2, Foam, Dry Chemical
SPECIAL FIRE FIGHT PROCEDURES: Wear self-contained breathing apparatus
Unusual Fire & Explosion Hazards: Vapors are heavier than air. Vapors can be ignited from flames or other sources of heat at locations
at distance from material handling point.
SECTION 4 - REACTIVITY HAZARD DATA
STABILITY: [ ] STABLE [X] UNSTABLE HAZARDOUS POLYMERIZATION [ ] WILL [X] WILL NOT OCCUR
Incompatibility (Mat. to Avoid): Strong oxidizing agents Conditions to Avoid: Sparks, heat, open flames
Hazardous Decomposition Products: Carbon monoxide
SECTION 5 - HEALTH HAZARD DATA
PRIMARY ROUTES OF ENTRY: [ ] INHALATION [ ] INGESTION [ ] SKIN ABSORPTION [ ] EYE [ ] NOT HAZARDOUS
ACUTE EFFECTS:
Inhalation: Nausea, respiratory irritation, dizziness
Eye contact: Mild irritant
Skin contact: Mild irritant
Ingestion: Irritant
CHRONIC EFFECTS:
Medical conditions Generally Aggravated by Exposure: None
EMERGENCY FIRST AID PROCEDURES
Eye Contact: Rinse eyes with water for fifteen minutes
Skin Contact: Rinse skin with water for fifteen minutes
Inhalation: Primary route of entry. Get fresh air
Ingestion: Do not induce vomiting. Call a physician
SECTION 6 - CONTROL AND PROTECTIVE MEASURES
Respiratory Protection (specify type): NIOSH/MSHA approved air supplied respirator in confined areas.
Eye Protection: Splash goggles
Protective Gloves: Nitrile rubber
Ventilation Requirements: Positive air movement to provide ventilation below TLV.
Other Protective Clothing & Equipment: For continuous use, wear protective clothing and boots.
Hygienic Work Practices: No smoking in use area.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken if Material Is Spilled Or Released: Small - Absorb on paper, floor absorbent. Large - eliminate all ignition sources.
Waste Disposal Methods: With a licensed disposal service in compliance with local, state and federal regulations.
Precautions To Be Taken In Handling & Storage: Wear protective clothing. Store in well ventilated area. do not puncture or incinerate
containers. Do not store at temperatures above 120 F. KEEP OUT OF REACH OF CHILDREN
Other Precautions &/or Special Hazards: KEEP OUT OF REACH OF CHILDREN.
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty
or guarantee of any kind.
*Chemical Listed as Carcinogen or Potential Carcinogen. [a] NPT [b] IARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only
|