Material Safety Data Sheet HMIS铮?
May be used to comply with OSHA's HEALTH 2 REACTIVITY 0
Hazard Communication Standard,
29 CFR 1910.1200. Standard must be consulted for
specific requirements. PERSONAL PROTECTION
FLAMMABILITY 1 B
Note: Blank spaces are not permitted. If any item is not applicable, or no
Identity (As Used on Label and List) information is available, the space must be marked to indicate that.
33320 Anti-Static/Anti-Soil Glass & Utility Cleaner & Coating
SECTION I
Manufacturer's Name Emergency Telephone Number
ITW Dymon 1-800-535-5053
Address (Number, Street, City, State, and ZIP Code) Telephone Number for Information
805 East Old 56 Highway 1-913- 397-9889
Date Prepared
Olathe, Kansas 66061 April 3, 2000
Signature of Preparer (Optional)
Regulatory Dept.
SECTION II - Hazardous Ingredients/Identity
Information
Hazardous Components (Specific Other Limits
Chemical Identity, Common Name(s)) CAS No. OSHA PEL ACGIH-TLV Recommended %(Opt.)
Isopropanol 67-63-0 400 ppm 400 ppm 500 ppm-STEL 5 鈥? 10 %
*2-Butoxyethanol 111-76-2 50 ppm (skin) 25 ppm(skin) 0.5 - 2.0 %
Propane 74-98-6 1000 ppm Asphyxiant 0.5 鈥? 1.5 %
Isobutane 75-28-5 800 ppm 800 ppm 1鈥?5%
* This product contains 2-Butoxyethanol (a glycol ether compound) which is listed and may require reporting under
SARA Title III Sec. 313 if used over the threshold reporting quantity. This information must be included in all MSDSs
that are copied and distributed for this material.
TSCA: All ingredients are on the TSCA inventory or are not required to be listed on the TSCA inventory.
Any substance listed as hazardous by the States of California, Florida, Illinois, Michigan, New Jersey, Ohio, Pennsylvania or
Texas is described above if known present in regulated concentrations.
SECTION III Physical/Chemical
Characteristics
Boiling Point Specific Gravity (H 2 O = 1) 0.987
180 o F
Concentrate Concentrate
o
Melting Point 30掳 F
Pressure (psig. @ 70 F)
60 卤 5
Vapor Density (AIR = 1) Greater than Evaporation Rate (Butyl Acetate = 1)
one (1) No Data
Solubility in Water pH
Complete 9 + 0.5
Appearance and Odor
Clear colorless liquid with a floral bouquet in an aerosol can.
SECTION IV - Fire and Explosion Hazard Data
USA Flame Projection Test (ASTM D- Flammable Limits LEL UEL
3065) No Data No Data No Data
0", No flashback; Not flammable
Extinguishing Media -
Water spray, dry chemical, foam, carbon dioxide.
Special Fire Fighting Procedures -
Use water spray to keep containers cool and vapors down. Do not allow runoff to enter sewers or public watercourses. Wear self-contained
breathing apparatus in chemical fires.
Unusual Fire and Explosion Hazards -
Aerosol container (pressurized) may burst if heated over 120o F.
April 3, 2000
33320
SECTION V - Reactivity Data
Stability Unstable Conditions to Avoid - Extreme heat, direct sunlight
Stable X
Incompatibility (Materials to Avoid) - Strong oxidizers and alkalies, zinc, acetaldehyde, chlorine, ethylene oxide, hydrogen-
palladium combination, hydrogen peroxide-sulfuric acid combination, potassium tert-butoxide, hypochlorous acid, isocyanates,
nitrofoam, phosgene, oleum and perchloric acid.
Hazardous Decomposition or Byproducts -
Oxides of carbon, nitrogen oxides, various hydrocarbons.
Hazardous May Occur Conditions to Avoid - None known
P o l y m e r i z a t i o n Will Not Occur X
SECTION VI - Health Hazard Data
Route(s) of Entry Eyes?
Inhalation? Skin? Ingestion?
Yes Yes Yes Yes
Health Hazards (Acute and Chronic) - Warning. Causes eye irritation. May cause skin and respiratory tract irritation. May be
absorbed through intact skin. May be harmful if swallowed. Central nervous system effects if inhaled at high vapor concentrations.
Direct contact with eyes can cause burns on corneal, iris and conjunctival tissues. Direct skin contact may cause corrosive effects. Follow
good chemical hygiene practices to avoid these hazards.
Carcinogenicity: NTP? IARC Monographs? OSHA Regulated?
None known No No No
Signs and Symptoms of Exposure - Redness, tearing, burning of eyes. Redness, drying and cracking of skin. Drowsiness, loss of
coordination, headache if over exposed to vapors. Nausea, diarrhea and gastrointestinal disturbances if ingested.
Medical Conditions Generally Aggravated by Exposure - Pre-existing skin and lung disorders may be adversely affected.
Follow good chemical hygiene practices to avoid these hazards.
Emergency and First Aid Procedures: - Eyes - Flush with plenty of water for at least 15 minutes lifting eyelids to insure
complete removal. Get immediate medical attention. Ingestion - Drink several glasses of water. Contact a physician or poison
control center immediately. Inhalation - Get to fresh air. If breathing has stopped, qualified personnel should administer artificial
respiration. Skin - Wash with soap and water. If irritation arises and persists consult a physician.
SECTION VII - Precautions for Safe Handling and Use
Steps to be Taken in Case Material is Released or Spilled - Caution. Slip hazard. For large spills, isolate traffic and
ventilate area. Eliminate all ignition sources. Wear protective gear as necessary. Dike to prevent spread. Pick up on absorbent material
and put in suitable container for proper disposal.
Waste Disposal Method - Consult local, state and federal regulations. Do not puncture or incinerate container. Replace
cap on empty can, wrap, then discard container if allowed by applicable statutes.
Precautions to be Taken in Handling and Storing - Do not get in eyes. Avoid contact with skin and clothing. Avoid inhaling
o
mist or vapors. Do not swallow. Wash thoroughly after handling. Store in a cool (under 120 F) dry location away from heat, sparks,
open flame, and direct sunlight. Direct spray away from face.
Other Precautions - Follow label directions carefully. Keep out of reach of children. Do not deliberately concentrate and
inhale vapors. Replace cap when not in use. Do not use around ignition sources such as heat, sparks, open flame, welding
arcs, static electricity, etc.
SECTION VIII - Control Measures
Respiratory Protection (Specify Type) - Not usually necessary. Use with adequate ventilation. If PELs or TLVs are
exceeded (see Section II), use an approved NIOSH\MSHA respirator.
Ventilation Local Exhaust Not necessary Special None
Mechanical (General) Acceptable Other None
Protective Gloves - Eye Protection -
Yes, impervious. Yes, safety glasses or goggles (ANSI Z87)
Other Protective Clothing or Equipment -
As needed to avoid direct contact with skin and clothing (i.e. apron, boots).
Work/Hygienic Practices -
Normal. Wash thoroughly before eating, drinking, smoking, using restrooms, etc.
WARNING! The use of this product is beyond the control of the manufacturer; therefore, no guarantee, expressed or implied, is made as to the effects of such or the results to be obtained if not used in accordance with directions or established safe
practice. The user must assume all responsibility, including injury or damage, resulting from its misuse as such, or in combination with other materials.
The manufacturer warrants only that this product meets the manufacturer's specifications for such product. THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR IMPLIED, AS TO DESCRIPTION , QUALITY, MERCHANTABILITY. FITNESS FOR ANY PARTICULAR
PURPOSE, PRODUCTIVENESS, OR ANY OTHER MATTER, OF THIS PRODUCT. THE MANUFACTURER SHALL BE IN NO WAY RESPONSIBLE FOR THE PROPER USE OF THIS PRODUCT. The sole and exclusive remedy against the manufacturer for breach of warranty shall be
reimbursement of the purchase price of the product in the event that a defective condition of the product shall be found to exist. NO OTHER REMEDY (INCLUDING BUT NOT LIMITED TO INCIDENTAL OR CONSEQUENTIAL DAMAGES FOR INJURY TO PERSON OR PROPERTY OR ANY OTHER INCIDENTAL OR
CONSEQUENTIAL LOSS) SHALL BE AVAILABLE.
|