MATERIAL SAFETY DATA SHEET
MSDS Ref. No: 4283 RTU
KDS 2 LOOK Glass
Date Prepared: 10/08/2003
Cleaner Ready-to-Use
Date Revised: 10/08/2003
1. PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME/USE: KDS 2 LOOK Glass Cleaner Ready-to-Use
A 1:20 dilution of KDS LOOK Glass Cleaner Concentrate
MANUFACTURER
The Butcher Company Butcher Telephone Number: 800-225-9475
8310 16th St. Emergency Telephone (24 hours): 800-228-5635
Sturtevant, WI 53177-0902 CHEMTREC (U.S./Can.): 800-424-9300
CHEMTREC (Int'l): +1 703-527-3887
2. COMPOSITION / INFORMATION ON INGREDIENTS
INGREDIENT(S) CAS# % BY WEIGHT
Ammonium hydroxide 1336-21-6 0.1 - 0.5
See Section 8 for Exposure Limits NA - Not Applicable
OSHA REGULATORY STATUS: This product is classified as not hazardous under OSHA regulations.
WHMIS CLASS: Not controlled.
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Clear, Light Blue Liquid . Mild, Ammonia Odor. Product Does Not Present a Significant Immediate Concern for
Emergency Response Personnel.
POTENTIAL HEALTH EFFECTS (See Section 11 for Toxicological Information)
PRIMARY ROUTE(s) OF EXPOSURE: X Eye X Skin Contact Skin Absorption
X Inhalation Ingestion
EFFECTS OF ACUTE EXPOSURE
EYES: Non-irritating to the eyes, but may cause temporary redness or discomfort.
SKIN: Non-irritating to the skin.
INHALATION: High concentrations of vapor or mist may cause nose, throat and respiratory tract irritation. Symptoms may include
coughing.
INGESTION: May cause temporary mouth, throat and stomach discomfort. Symptoms may include nausea.
EFFECTS OF CHRONIC EXPOSURE: None known.
MEDICAL CONDITIONS AGGRAVATED: None known.
Page 1 of 4
KDS 2 LOOK Glass Cleaner Ready-to-Use
4. FIRST AID MEASURES
EYES: Flush eyes with plenty of water while holding eyelids apart. After initial flushing, remove any contact lenses and continue flushing for at
least 15 minutes. Do not put any medication in the victim's eyes unless instructed by a physician. Get medical attention if irritation develops.
SKIN: Flush with water, then wash with soap and water. Remove saturated clothing. Get medical attention if irritation develops.
INHALATION: Remove to fresh air. Get medical attention if symptoms persist.
INGESTION: Do not induce vomiting. Drink large quantities of water. Get medical attention.
5. FIRE FIGHTING MEASURES
FLASH POINT AND METHOD: > 93掳C (200掳F)TCC
FLAMMABLE LIMITS: Not applicable.
AUTOIGNITION TEMPERATURE: Not applicable.
EXTINGUISHING MEDIA: Use extinguishing media appropriate for surrounding fire.
HAZARDOUS COMBUSTION PRODUCTS: Normal products of combustion (carbon monoxide and carbon dioxide).
FIRE AND EXPLOSION HAZARDS: None known.
FIRE FIGHTING INSTRUCTIONS: This product is not flammable. As in any fire, MSHA/NIOSH approved self-contained breathing
apparatus (SCBA) and full protective gear should be worn.
6. ACCIDENTAL RELEASE MEASURES
Contain spill. Use mop, absorbent, or wet vacuum to collect material for proper disposal. Rinse area with water.
7. HANDLING AND STORAGE
HANDLING: Follow label use directions. Do not mix with other chemicals unless instructed by label directions. Use with adequate ventilation.
Avoid breathing vapor or mist. Wash thoroughly after handling.
STORAGE: No special storage practices are required. Keep container closed when not in use.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
PERSONAL PROTECTIVE EQUIPMENT (PPE)
EYE: Not required under normal conditions of use.
SKIN: Not required under normal conditions of use.
RESPIRATORY: Not required under normal conditions of use.
ENGINEERING CONTROLS: Good general room ventilation is expected to be adequate.
EXPOSURE LIMITS:
INGREDIENT(S) OSHA PEL/STEL ACGIH TLV/STEL
Ammonium hydroxide 50 ppm 35 mg/m3 / 25 ppm 17 mg/m3 /
35 ppm 27 mg/m3 35 ppm 24 mg/m3 (NH3)
NA - Not Available
9. PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: Liquid
ODOR: Mild, Ammonia
Page 2 of 4
KDS 2 LOOK Glass Cleaner Ready-to-Use
APPEARANCE: Clear, Light Blue
pH: 10.3
PERCENT VOLATILE BY WEIGHT: 99.5
VAPOR PRESSURE: Not Available
VAPOR DENSITY: Not Available
BOILING POINT: Not Available
FREEZING/MELTING POINT: Not Available
SOLUBILITY IN WATER: Complete
EVAPORATION RATE: Not Available
SPECIFIC GRAVITY: 1.00
VISCOSITY: Water Thin
OCTANOL/WATER PARTITION COEFFICIENT: Not Available
ODOR THRESHOLD: Not Available
10. STABILITY AND REACTIVITY
STABILITY (CONDITIONS TO AVOID): Stable.
POLYMERIZATION: Will not occur.
HAZARDOUS DECOMPOSITION: None known.
INCOMPATIBLE MATERIALS: None known.
11. TOXICOLOGICAL INFORMATION
ACUTE DATA: This product is typically non-irritating to skin and eyes at recommended use dilution.
PRODUCT/INGREDIENT ORAL LD 50 (rat) DERMAL LD 50 (rabbit) INHALATION LC 50 (rat)
Ammonium hydroxide 350 - mg/kg Not Available 3670 - ppm (4-hr)
SENSITIZATION DATA: No data available.
CHRONIC DATA:
No data available.
REPRODUCTIVE/TERATOGENIC DATA: No data available.
CARCINOGENIC/MUTAGENIC DATA: Not listed as carcinogenic by NTP, IARC, or ACGIH or regulated as a carcinogen by OSHA.
SYNERGISTIC MATERIALS: No data available.
12. ECOLOGICAL INFORMATION
No data available.
13. DISPOSAL CONSIDERATIONS
Disposal of this material should be in accordance with local, state or provincial and federal regulations. The unused product, at its recommended
use dilution, is a RCRA non-hazardous waste in accordance with 40 CFR 261. The product has not been evaluated by the Toxicity Characteristic
Leachate Procedure (TCLP). According to RCRA, it is the responsibility of the waste generator to ensure proper disposal.
14. TRANSPORT INFORMATION
DOT/TDG HAZARDOUS MATERIAL DESCRIPTION: Not regulated
15. REGULATORY INFORMATION
Not meant to be all-inclusive---selected regulations represented.
UNITED STATES
Page 3 of 4
KDS 2 LOOK Glass Cleaner Ready-to-Use
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT)
311/312 HAZARD CATEGORIES: Under 40 CFR 370.2, this product meets the following hazard categories: None.
313 REPORTABLE INGREDIENTS: Ingredients in this product are not currently subject to notification.
CERCLA (COMPREHENSIVE RESPONSE, COMPENSATION, AND LIABILITY ACT)
CERCLA REGULATORY: Not reportable under CERCLA.
TSCA (TOXIC SUBSTANCE CONTROL ACT)
TSCA STATUS: This product complies with all TSCA inventory requirements.
MASSACHUSETTS, NEW JERSEY, PENNSYLVANIA RIGHT-TO-KNOW:
INGREDIENT(S) CAS NO. STATE LISTING
Water 7732-18-5 Not Listed
NA - Not Applicable
STATE REGULATIONS: Product contains a mixture of surfactant and cleaning agents below State reporting requirements.
CANADA
WHMIS (WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM): Not controlled by WHMIS. This product has been
classified in accordance with the hazard criteria of the Canadian Controlled Products Regulations (CPR) and the MSDS contains all the
information required by the CPR.
16. OTHER INFORMATION
NFPA CODES:
HMIS RATING
-0
HEALTH
0
0
FLAMMABILITY
0 0
0
REACTIVITY
---
-
PERSONAL PROTECTION
APPROVED BY: Product Safety & Regulatory
MSDS STATUS
Revision No: 1
Revision #: 1
This MSDS replaces the November 30, 2000 MSDS. Any changes in information are as follows:
In Section 1
Approved by Date Prepared
APPROVAL DATE: 10/08/2003
The information on this data sheet represents our current data and best opinion as to the proper use in handling of the product under normal
foreseeable conditions. Any use of this product which is not in conformance with this data sheet or product label, or which involves using the
product in combination with any other product or any other process is the responsibility of the user.
Page 4 of 4
|