MATERIAL SAFETY DATA SHEET 24 HOUR EMERGENCY
芒
PortionPac Chemical Corporation RESPONSE PHONE:
400 N. Ashland Avenue, Chicago, IL 60622-6382
1-800-535-5053
Voice: 312/226-0400 Fax: 312/226-5400
Internet: www.portionpaccorp.com
n SECTION 01 IDENTIFICATION
MSDS NO. 200 Series DATE: October 2000
Germicidal Detergent No. 201, 202, 204, 205 & 264
TRADE NAME:
NOTE: CAS Registry numbers are not applicable to formulated products.
n SECTION 02 PHYSICAL & HEALTH HAZARDOUS INGREDIENTS
Hazardous Material as defined by 29 CFR 1910.1200 Reportable under CERCLA or SARA TITLE III Sec. 304 Regulations.
Common Names: ethanolamine, MEA, monoethanolamine CAS# 141-43-5
Chemical Names: monoethanolamine, 2-aminoethanol
Hazard % in Formula: in concentrate: 7.95% in working/use solution: 0.031%
Hazard Reference: 3 ppm ACGIH 85/86 Ref. (1) Sec. IX LD50 rats 10.2g/Kg J. Ind. Hyg. Toxicol 23, 259 (1941)
Common Names: butyl cellosolve, Poly Solv EB CAS# 111-76-2
Chemical Name: 2-butoxyethanol
Hazard % in Formula: in concentrate: 2.0% in working/use solution: 0.008%
Hazard Reference: 50 ppm OSHA PEL 25 ppm ACGIH TLV IDLH 700 ppm
n SECTION 02A OTHER INGREDIENTS NOT CONSIDERED HAZARDOUS IN FORMULATION
NOTE: Germicidal detergents contain germicidal active agents. By definition, these agents are biologically active so that they can kill
bacteria and viruses on contact. Even though they are not listed by OSHA et. al. as hazardous materials, safe handling
procedures and common sense should be used in their use and handling.
water CAS# 7732-18-5
n-alkyl dimethyl benzyl ammonium chloride CAS# 68424-85-1
nonylphenoxy poly (ethyleneoxy) ethanol CAS# 9016-45-9
tetrapotassium pyrophosphate CAS# 7320-34-5
EDTA CAS# 64-02-8
trace colorant
n SECTION 03 PHYSICAL & CHEMICAL CHARACTERISTICS
Boiling Point: 190 deg. F.
Vapor Pressure: 19mm Hg
Vapor Density (air=1): Not determined.
Water Solubility: Complete.
Melting/Freezing point: < 0 deg. F.
Appearance: Red liquid, slightly more viscous than water.
Specific Grav. (water=1): 1.056
Percentage Volatiles in Concentrate: Approx. 65% due to water in formulation.
Evaporation Rate: Much slower than 1 (n-butyl acetate = 1)
pH: in concentrate: 11.9 卤 .2 in working/use solution: 8.9 卤 .3
Odor: Fresh, antiseptic odor.
n SECTION 04 PHYSICAL HAZARD DATA
Flash Point: 214 deg. F Closed cup.
Flammable Limits: Not determined.
Fire Fighting Media: Water spray, CO2, dry chemical;-- Treat primary cause of fire.
Special Fire Fighting Procedures: N/A.
Fire/Explosion Hazards: No unusual hazards known.
n SECTION 05 REACTIVITY DATA
Stability: Stable.
Hazardous Polymerization: Will not occur.
Conditions to Avoid: Long exposure to materials containing copper, aluminum and strong oxidizing agents may cause discoloration.
Incompatible Materials: Strong oxidizing or reducing agents.
Hazardous Decomposition Products: If heated to decomposition, CO, CO2, NOx and ammonia may be produced.
n SECTION 06 HEALTH HAZARD DATA
Oral Toxicity: Not determined for formulation.
Carcinogenicity: None of the individual materials in this formulation are listed as carcinogens in NTP, IARC
Monographs, or are OSHA Regulated carcinogens.
n SECTION 07 SYMPTOMS OF OVEREXPOSURE
Symptoms of Ingestion: When concentrate is ingested, immediate burning pain in the mouth, throat, abdomen and possible severe swelling
of the larynx. Possible skeletal muscle paralysis affecting the ability to breath with circulatory shock if large
quantities are ingested. Possible convulsions. May cause red blood cell hemolysis and possible liver and kidney
injury. May be fatal.
Symptoms of Inhalation: If misted in concentrated form, which is improper use, can cause irritation of mucous membrane, nose, eye and
throat.
Symptoms of Skin Contact: May cause dermatitis or irritation in some individuals upon prolonged contact. Localized skin defatting can be
expected from concentrated material on long contact. Harmful if absorbed through skin.
Symptoms of Eye Contact: Causes painful stinging or burning of eyes and lids, watering of eye, conjunctivitis and, in concentrated undiluted
form, may cause opaqueness of cornea, possibly leading to loss of sight. Corrosive.
n SECTION 08 EMERGENCY FIRST AID PROCEDURES
For Ingestion: DO NOT attempt to induce vomiting. Have the individual drink one or more full glasses of milk or water. If vomiting
occurs, give fluids again. NEVER give anything to an unconscious person. Call a physician or your local Poison
Control Center. Treatment should be directed at the control of symptoms and the clinical condition of the patient.
There is no specific antidote. Possible mucosal damage may contraindicate the use of gastric lavage.
For Skin: As for all foreign materials, wash off with copious amounts of water. Remove clothing, which has been saturated by
concentrate. Thoroughly wash affected clothing and shoes.
For Eyes: PROMPTLY flush with large amount of water for at least 15 minutes, occasionally lifting the lower and upper lids.
See a physician if irritation persists.
Medical Conditions
Aggravated by Exposure: No data found.
n SECTION 09 OCCUPATIONAL CONTROL PROCEDURES
Ventilation: Use with adequate ventilation. Working solution should not present any specific hazard. If misted or aerosol
generated, local or mechanical exhaust recommended to maintain vapor concentration below TLV. This level
should not be reached under normal working conditions.
Respiratory Protection: Not required under normal working/use conditions.
Eye Protection: EPA recommends use of goggles to handle germicidal products.
Skin Protection: EPA recommends use of gloves to handle germicidal products.
Personal Hygiene: As in handling any germicidal detergent, wash thoroughly after using.
n SECTION 10 PRECAUTIONS FOR SAFE HANDLING STORAGE AND USE
Precautionary Measures: Avoid contact with eyes and prolonged contact of concentrate with skin. Use with adequate ventilation. Do not
store at elevated temperatures.
Spills Clean-up Procedures: Concentrated materials are packed in unit-dosed bags limiting any spills to very small quantities. Paper toweling or
mopping is usually sufficient.
Disposal Method: Bags should be triple rinsed before disposal.
Food Contamination: Foods contaminated by germicides should be discarded and utensils, etc. should be rinsed with potable water
before use.
n GENERAL NOTE ABOUT PRODUCTS
PortionPac芒 Germicidal Detergent formulation is not substantially different from any other commercially available germicides. The unique packaging of these materials
in unit dosed bags limits the amount of exposure of the concentrate to very small amounts. These can be cleaned up with paper toweling or plain mopping. These are in
fact products for mopping as well as other maintenance chores requiring disinfectants. We know of no serious hazards associated with the proper use and handling of this
product.
PortionPac Chemical Corporation makes no warranty, expressed or implied, as to the accuracy, completeness or reliability of this information, except that such
information is, to the best of our knowledge and belief, accurate as of the date indicated.
24 HOUR EMERGENCY RESPONSE PHONE: 1-800-535-5053
MSDS 201/202/204/205/264 REVISED: 10/00
In Concentrate: In Dilution:
Fire Hazard Fire Hazard
1 0
Health Hazard Health Hazard
1 0 1 0
Reactivity Reactivity
Specific Hazard Specific Hazard
PortionPac芒 and the 鈥淧ac餂? Family鈥? names and images are the intellectual property of PortionPac Chemical Corp. Chicago, IL 60622 茫1999 PortionPac Chemical Corp. All rights reserved.
|