MATERIAL SAFETY DATA SHEET
SECTION 1 - CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME: STAR BRITE TROPICAL TEAK OIL/SEALER INTERIOR/EXTERIOR TEAK FURNITURE)
IDENTIFICATION NO: #52532
MANUFACTURER: STAR BRITE
4041 S. W. 47 AVENUE
FT. LAUDERDALE, FL 33314
INFORMATION PHONE: 954-587-6280 EMERGENCY PHONE: 800-434-9300 or 703-527-3887
PREPARER: JEFF TIEGER PREPARED: June 26, 2006 REVISED: October 7, 2006
SECTION 2 - COMPOSITION/INFORMATION ON INGREDIENTS
WT/WT %
ITEM NO. CHEMICAL NAME CAS NUMBER EQUAL TO
01 OGANOCLAY 8001-78-3 3%
02 ISO ALKYD RESIN SOLUTION MIXTURE 32%
03 MINERAL SPIRITS RULE 66 8052-41-3 63%
- - - - - - - - - - EXPOSURE LIMITS- - - - - - - - - - -
ACGIH OSHA PEL- COMPANY
ITEM NO. TLV-TWA TLV-STEL PEL-TWA CEILING TLV-TWA SKIN
01 N.E N.E. N.E. N.E. NO
02 N.E. N.E. N.E. N.E. NO
03 100 PPM 100 PPM* N.E. N.E. NO
(SEE SECTION 16 FOR ABBREVIATION LEGEND) * - CEILING VALUE
SECTION 3 - HAZARDS IDENTIFICATION
***EMERGENCY OVERVIEW***: IN CASE OF EYE CONTACT, IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF LOW
PRESSURE WATER FOR AT LEAST 15 MINUTES. CALL A PHYSICIAN IMMEDIATELY. SKIN, WASH WITH MILD SOAP AND
RUNNING WATER. MOLTEN RESIN: IF MOLTEN RESIN COMES IN CONTACT WITH SKIN, COOL UNDER A RUNNING
STREAM OF WATER. DO NOT ATTEMPT TO REMOVE THE RESIN FROM THE SKIN. REMOVAL COULD RESULT IN SEVERE
TISSUE DAMAGE. IN CASE OF EYE CONTACT - FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES AND GET MEDICAL ATTENTION. FOR SKIN: WASH THOROUGHLY WITH SOAP AND WATER. IF AFFECTED BY
INHALATION OF VAPORS OR SPRAY MIST, REMOVE TO FRESH AIR. IF SWALLOWED, GET MEDICAL ATTENTION
IMMEDIATELY.
EFFECTS OF OVEREXPOSURE - EYE CONTACT: CAUSES EYE, SKIN, NOSE AND THROAT IRRITATION. THIS MATERIAL
MAY BE AN EYE IRRITANT.
EFFECTS OF OVEREXPOSURE - SKIN CONTACT: THIS MATERIAL MAY CAUSE SKIN IRRITATION OR RASH UPON
PROLONGED OR REPEATED CONTACT. MAY CAUSE ALLERGIC REACTION.
EFFECTS OF OVEREXPOSURE - INHALATION: EXCESSIVE INHALATION OF VAPORS CAN CAUSE RESPIRATORY
IRRITATION, DIZZINESS, HEADACHE, NAUSEA AND ASPHYXIATION.
EFFECTS OF OVEREXPOSURE - INGESTION: MAY CAUSE MOUTH, THROAT, ESOPHAGUS AND STOMACH IRRITATION,
NAUSEA, VOMITING AND DIARRHEA.
EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS: NO INFORMATION.
PRIMARY ROUTE(S) OF ENTRY: SKIN CONTACT, INHALATION, INGESTION, EYE CONTACT.
PRODUCT NAME: STAR BRITE TROPICAL TEAK OIL/SEALER INTERIOR/EXTERIOR TEAK FURNITURE)
IDENTIFICATION NO: #52532
SECTION 4 - FIRST AID MEASURES
FIRST AID - EYE CONTACT: IN CASE OF EYE CONTACT, FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES AND GET MEDICAL ATTENTION IMMEDIATELY. RINSE WITH WATER FOR 15 MINUTES.
FIRST AID - SKIN CONTACT: WASH WITH SOAP AND WATER IMMEDIATELY. WASH EFFECTED AREA WITH SOAP AND
WATER. REMOVE CONTAMINATED CLOTHING. CONSULT A PHYSICIAN IF IRRITATION PERSISTS.
FIRST AID - INHALATION: REMOVE VICTIM TO FRESH AIR IMMEDIATELY. IF COUGHING, DIFFICULT BREATHING OR ANY
OTHER RESPIRATORY SYMPTOMS DEVELOP, SEEK MEDICAL ATTENTION AT ONCE. REMOVE TO FRESH AIR IF
DIFFICULTY IN BREATHING.
FIRST AID - INGESTION: IF SWALLOWED, GET MEDICAL ATTENTION IMMEDIATELY.
SECTION 5 - FIRE FIGHTING MEASURES
FLASH POINT: 113掳 F (32.2掳 C) LOWER EXPLOSIVE LIMIT: 1.0%
(CLEVELAND OPEN CUP) UPPER EXPLOSIVE LIMIT: 7.0%
AUTOIGNITION TEMPERATURE:
EXTINGUISHING MEDIA: ALCOHOL, FOAM, CO2, DRY CHEMICAL, FOAM, WATER FOG
UNUSUAL FIRE AND EXPLOSION HAZARDS: VAPORS MAY CAUSE FLASH FIRE. KEEP CONTAINER TIGHTLY CLOSED AND
ISOLATE FROM HEAT. ELECTRICAL EQUIPMENT, SPARKS AND FLAME. NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN IGNITE EXPLOSIVELY.
SPECIAL FIRE FIGHTING PROCEDURES: FIRE FIGHTERS AND OTHERS EXPOSED TO VAPORS OR PRODUCTS OF
COMBUSTION SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS.
SECTION 6 - ACCIDENTAL RELEASE MEASURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES, AND ELECTRICAL, STATIC, OR FRICTIONAL SPARKS). AVOID BREATHING VAPORS. VENTILATE AREA.
CONTAIN AND REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS. REMOVE ALL SOURCES OF IGNITION.
VENTILATE AREA. ABSORB SPILL WITH AN ABSORBENT MATERIAL SUCH AS SAWDUST, VERMICULITE OR SAND AND
PLACE MATERIAL INTO A CLOSED CONTAINER. IF LARGE SPILL, DIKE AREA TO PREVENT THIS MATERIAL FROM
ENTERING WATER SYSTEMS OR SEWERS. WEAR PROTECTIVE EQUIPMENT DURING CLEANUP.
SECTION 7 - HANDLING AND STORAGE
HANDLING: PROTECT AGAINST PHYSICAL DAMAGE. OUTSIDE OR DETACHED STORAGE PREFERRED.
STORAGE: KEEP AWAY FROM EXCESSIVE HEAT, SPARKS AND OPEN FLAME. KEEP CLOSURES TIGHT WHEN NOT IN USE.
KEEP CONTAINERS UPRIGHT TO PREVENT LEAKAGE.
SECTION 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS: EFFICIENT LOCAL EXHAUST VENTILATION IS REQUIRED.
RESPIRATORY PROTECTION: USE SUPPLIED AIR RESPIRATORY PROTECTION IN CONFINED OR ENCLOSED SPACES IF
NEEDED.
SKIN PROTECTION: CHEMICAL RESISTANT NITRILE, NEOPRENE OR RUBBER GLOVES REQUIRED.
EYE PROTECTION: CHEMICAL GOGGLES OR FACE SHIELD RECOMMENDED.
PRODUCT NAME: STAR BRITE TROPICAL TEAK OIL/SEALER INTERIOR/EXTERIOR TEAK FURNITURE)
IDENTIFICATION NO: #52532
SECTION 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION cont鈥檇
OTHER PROTECTIVE EQUIPMENT: WEAR PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT. EYE WASH STATION
AND SAFETY SHOWER SHOULD BE AVAILABLE.
HYGIENIC PRACTICES: WASH HANDS BEFORE EATING OR SMOKING. SMOKE IN DESIGNATED AREAS ONLY.
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES
BOILING RANGE: 334 - 390掳 F VAPOR DENSITY: IS HEAVIER THAN AIR
ODOR: SLIGHT TO NONE ODOR THRESHOLD:
APPEARANCE: LIGHT BROWN LIQUID EVAPORATION RATE: IS SLOWER THAN ETHER
SOLUBILITY IN H20: NO
FREEZE POINT: SPECIFIC GRAVITY:
VAPOR PRESSURE: pH @ 0.0%:
PHYSICAL STATE: VISCOSITY :
COEFFICIENT OF WATER/OIL DISTRIBUTION
(See Section 16 for abbreviation legend)
SECTION 10 - STABILITY AND REACTIVITY
CONDITIONS TO AVOID: NO INFORMATION.
INCOMPATIBILITY: NO INFORMATION.
HAZARDOUS DECOMPOSITION PRODUCTS: NO INFORMATION.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR UNDER NORMAL CONDITIONS.
STABILITY: THIS PRODUCT IS STABLE UNDER NORMAL STORAGE CONDITIONS.
SECTION 11 - TOXICOLOGICAL PROPERTIES
NO PRODUCT OR COMPONENT TOXICOLOGICAL INFORMATION IS AVAILABLE.
SECTION 12 - ECOLOGICAL INFORMATION
ECOLOGICAL INFORMATION: NO INFORMATION
SECTION 13 - DISPOSAL CONSIDERATIONS
DISPOSAL METHOD: PREFERRED DISPOSAL METHODS WOULD BE BY SUPERVISED INCINERATION AT AN APPROVED
CHEMICAL DISPOSAL AREA UNDER FEDERAL, STATE AND LOCAL AUTHORITY. USE WITH CARE.382.
SECTION 14 - TRANSPORTATION INFORMATION
Call for information
PRODUCT NAME: STAR BRITE TROPICAL TEAK OIL/SEALER INTERIOR/EXTERIOR TEAK FURNITURE)
IDENTIFICATION NO: #52532
SECTION 15 - REGULATORY INFORMATION
THIS PRODUCT CONTAINS THE FOLLOWING NON-HAZARDOUS COMPONENTS:
- - - - - - - - - CHEMICAL NAME- - - - - - - - - - CAS NUMBER WT/WT %
YELLOW IRON OXIDE PIGMENT 133-07-03 1.6%
U. S. FEDERAL REGULATIONS: AS FOLLOWS -
OSHA: HAZARDOUS BY DEFINITION OF HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA "HAZARD CATEGORIES" PROMULGATED UNDER
SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS
CONSIDERED, UNDER APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
IMMEDIATE HEALTH HAZARD CHRONIC HEALTH HAZARD FIRE HAZARD
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313
OF TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
- - - - - - - - - - - CHEMICAL NAME- - - - - - - - - - - CAS NUMBER WT/WT %
MINERAL SPIRITS RULE 66 8052-41-3 63%
TOXIC SUBSTANCES CONTROL ACT:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE REPORTING REQUIREMENTS OF
TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
- - - - - - - - - - CHEMICAL NAME- - - - - - - - - - - CAS NUMBER
NO INFORMATION IS AVAILABLE
INTERNATIONAL REGULATIONS: AS FOLLOWS -
CANADIAN WHMIS: THIS MSDS HAS BEEN PREPARED IN COMPLIANCE WITH CONTROLLED PRODUCT REGULATIONS
EXCEPT FOR USE OF THE 16 HEADINGS.
CANADIAN WHMIS CLASS: NO INFORMATION IS AVAILABLE.
SECTION 16 - OTHER INFORMATION
HMIS RATINGS - HEALTH: 2 FLAMMABILITY: 1 REACTIVITY: 0
VOLATILE ORGANIC COMPOUNDS (VOCS): 4.47 LBS/GAL. 535 GRAMS/LTR
LEGEND: N.A. - NOT AVAILABLEN.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
THE INFORMATION CONTAINED ON THIS MSDS HAS BEEN CHECKED AND SHOULD BE ACCURATE. HOWEVER, IT IS THE
RESPONSIBILITY OF THE USER TO COMPLY WITH ALL FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
|