MATERIAL SAFETY DATA SHEET
MANUFACTURER鈥橲 NAME
Star brite EMERGENCY TELEPHONE NO.
4041 S.W. 47th Ave. (800) 424-9300 or 703-527-3887 (Chemtrec)
Ft. Lauderdale, FL 33314
DATE OF PREPARATION INFORMATION TELEPHONE NO.
June 18, 2005 (800) 327-8583
Section I - PRODUCT IDENTIFICATION
PRODUCT NUMBER
82812 HMIS CODES
Health 2
PRODUCT NAME Flammability 4
SUPER ENGINE DEGREASER AEROSOL Reactivity 0
PRODUCT CLASS
Aerosol Specialty Product
Section II - HAZARDOUS INGREDIENTS
INGREDIENT ACGIH OSHA
CAS NO. % by WT TLV PEL UNITS V.P.
Propane 8 2500 1000 PPM 760.00
74-98-6
d-Limonene. 30 Not Established 2.00
5989-27-5
2-Propanol 4 400 400 PPM 33.00
67-63-0 STEL 500 500 PPM
2-Butoxyethanol 7 20 20PPM (Skin) 0.88
111-76-2
Section III - PHYSICAL DATA
PRODUCT WEIGHT 7.22 lb/gal 865 g/l
SPECIFIC GRAVITY 0.87
BOILING POINT <0掳 - 343掳 F < - 18掳 - 172掳 C
MELTING POINT Not Available
VOLATILE VOLUME 99 %
EVAPORATION RATE Faster than ether
VAPOR DENSITY Heavier than air
SOLUBILITY IN WATER N.A.
VOLATILE ORGANIC COMPOUNDS (VOC Theoretical)
Volatile Weight 48.73 % Less Federally Exempt Solvents
HMIS B 2 4 0
Section IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT LEL UEL
69掳 F TCC 0.7 12.07
EXTINGUISHING MEDIA
Carbon Dioxide, Dry Chemical, Alcohol Foam
UNUSUAL FIRE AND EXPLOSION HAZARDS
Closed containers may explode (due to the build-up of pressure) when exposed to extreme heat.
SPECIAL FIRE FIGHTING PROCEDURES
Full protective equipment including self-contained breathing apparatus should be used. Water spray may
be ineffective. If water is used, fog nozzles are preferable. Water may be used to cool closed containers to prevent
pressure build-up and possible autoignition or explosion when exposed to extreme heat.
MATERIAL SAFETY DATA SHEET
PRODUCT NO. : 82812 June 18, 2005
Section V - HEALTH HAZARD DATA
ROUTES OF EXPOSURE
Exposure may be by INHALATION and/or SKIN or EYE contact, depending on conditions of use. To
minimize exposure, follow recommendations for proper use, ventilation, and personal protective equipment.
ACUTE Health Hazards
EFFECTS OF OVEREXPOSURE
Irritation of eyes, skin and respiratory system. May cause nervous system depression. Extreme
overexposure may result in unconsciousness and possibly death.
SIGNS AND SYMPTOMS OF OVEREXPOSURE
Headache, dizziness, nausea, and loss of coordination are indications of excessive exposure to vapors or
spray mists. Redness and itching or burning sensation may indicate eye or excessive skin exposure.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE
None generally recognized.
EMERGENCY AND FIRST AID PROCEDURES
If INHALED: If affected, remove from exposure. Restore breathing. Keep warm and quiet.
If on SKIN: Wash affected area thoroughly with soap and water. Remove contaminated
clothing and launder before re-use.
If in EYES: Flush eyes with large amounts of water for 15 minutes. Get medical attention.
If SWALLOWED: Get medical attention.
CHRONIC Health Hazards
No ingredient in this product is an IARC, NTP or OSHA listed carcinogen. Prolonged overexposure to
solvent ingredients in Section II may cause adverse effects to the liver, urinary and blood forming systems. Reports
have associated repeated and prolonged overexposure to solvents with permanent brain and nervous system damage.
Section VI - REACTIVITY DATA
STABILITY B Stable
CONDITIONS TO AVOID
None known.
INCOMPATIBILITY
None Known.
HAZARDOUS DECOMPOSITION PRODUCTS
By fire: Carbon Dioxide, Carbon Monoxide
HAZARDOUS POLYMERIZATION
Will not occur
Section VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
Remove all sources of ignition. Ventilate and remove with inert absorbent.
WASTE DISPOSAL METHOD
Waste from this product may be hazardous as defined under the Resource Conservation and Recovery Act
(RCRA) 40 CFR 261.
Waste must be tested for ignitability to determine the applicable EPA hazardous waste numbers.
Do not incinerate. Depressurize container. Dispose of in accordance with Federal, State, and Local
regulations regarding pollution.
MATERIAL SAFETY DATA SHEET
PRODUCT NO. : 82812 June 18, 2005
Section VIII - PROTECTION INFORMATION
PRECAUTIONS TO BE TAKEN IN USE
Use only with adequate ventilation. Avoid breathing vapor and spray mist. Avoid contact with skin and
eyes. Wash hands after using.
VENTILATION
Local exhaust preferable. General exhaust acceptable if the exposure to materials in Section II is
maintained below applicable exposure limits. Refer to OSHA Standards 1910.94, 1910.107, 1910.108.
RESPIRATORY PROTECTION
If personal exposure cannot be controlled below applicable limits by ventilation, wear a properly fitted
organic vapor/particulate respirator approved by NIOSH/MSHA for protection against materials in Section II.
PROTECTIVE GLOVES
None required for normal application of aerosol products where minimal skin contact is expected. For long
or repeated contact, wear chemical resistant gloves.
EYE PROTECTION
Wear safety spectacles with unperforated sideshields.
Section IX - PRECAUTIONS
DOL STORAGE CATEGORY
1A
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Keep away from heat, sparks, and open flame. During use and until all vapors are gone: Keep area
ventilated - Do not smoke - Extinguish all flames, pilot lights, and heaters - Turn off stoves, electric tools and
appliances, and any other sources of ignition. Consult NFPA Code. Use approved Bonding and Grounding
procedures. Contents under pressure. Do not puncture, incinerate, or expose to temperature above 120掳F.
Heat from sunlight, radiators, stoves, hot water, and other heat sources could cause container to burst, do not take
internally. Keep out of the reach of children.
OTHER PRECAUTIONS
Intentional misuse by deliberately concentrating and inhaling the contents can be harmful or fatal.
Section X - OTHER REGULATORY INFORMATION
SARA 313 (40 CFR 372.65C) SUPPLIER NOTIFICATION
CAS NO. CHEMICAL/COMPOUND % by WT % Element
Glycol Ethers 7
Section XI - TRANSPORTATION
Call for information
|