MATERIAL SAFETY DATA SHEET
SECTION 1 PRODUCT AND COMPANY IDENTIFICATION
Manufacturer: Star brite Distributor HMIS Codes
4041 S.W. 47 Ave Health 2
Ft. Lauderdale, FL 33314 Flammability 4
Product Name: Super Lubricant Reactivity 0
Product Number: 83013
Date Of Preparation: June 18, 2005 Emergency Telephone No.
(800) 424-9300 or 703-527-3887
Information Telephone No.
(800) 327-8583
SECTION 2 COMPOSITION/INFORMATION ON INGREDIENTS
% By Wt. CAS No. Ingredient Units Vapor Pressure
9 74-98-6 Propane
ACGIH TLV 2500 ppm 760 mm
OSHA PEL 1000 ppm
9 106-97-8 Butane
ACGIH TLV 800 ppm 760 mm
OSHA PEL 800 ppm
70 68511-20-2 Heavy Aliphatic Naptha
ACGIH TLV Not Available 0.5
OSHA PEL Not Available
6 64741-73-7 Distillates, petroleum, alkylate
5 mg/m3 as Mist
ACGIH TLV
5 mg/m3 as Mist
OSHA PEL
SECTION 3 HAZARDS IDENTIFICATION
ROUTES OF EXPOSURE
Exposure may be by INHALATION and/or SKIN OR EYE contact, depending on conditions of use. To minimize exposure,
follow recommendations for proper use, ventilation, and personal protective equipment.
EFFECTS OF OVEREXPOSURE
Irritation of eyes, skin and upper respiratory system. May cause nervous system depression. Extreme overexposure may
result in unconsciousness and possibly death.
SIGNS AND SYMPTOMS OF OVEREXPOSURE
Headache, dizziness, nausea, and loss of coordination are indications of excessive exposure to vapors or spray mists.
Redness and itching or burning sensation may indicate eye or excessive skin exposure.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE
None generally recognized.
CANCER INFORMATION
For complete discussion of toxicology data refer to SECTION 11.
SECTION 4 FIRST AID MEASURES
If Inhaled: If affected, remove from exposure. Restore breathing. Keep warm and quiet.
If on Skin: Wash affected area thoroughly with soap and water. Remove contaminated clothing and launder before re-use.
If in Eyes: Flush eyes with large amounts of water for 15 minutes. Get medical attention.
If Swallowed: Do not induce vomiting. Get medical attention immediately.
Material Safety Data Sheet Product 83013
SECTION 5 FIRE FIGHTING MEASURES
FLASH POINT LEL UEL
Propellant < 0 F 0.6 9.5
EXTINGUISHING MEDIA
Carbon Dioxide, Dry Chemical, Foam
UNUSUAL FIRE AND EXPLOSION HAZARDS
Containers may explode with exposed to extreme heat. Application to hot surfaces requires special
precautions. During emergency conditions overexposure to decomposition products may cause a health
hazard. Symptoms may not be immediately apparent. Obtain medical attention.
SPECIAL FIRE FIGHTING PROCEDURES
Full protective equipment including self-contained breathing apparatus should be used.
Water spray may b e ineffective. If water is used, fog nozzles are preferable. Water may be used to cool
closed containers to prevent pressure build-up and possible autoignition or explosion when exposed to
extreme heat.
SECTION 6 ACCIDENTAL RELEASE MEASURES
STEP TO BE TAKEN IN CASE MATERIAL RELEASE OR SPILLED
Remove all sources of ignition. Ventilate the area.
Remove with inert absorbent.
SECTION 7 HANDLE AND STORAGE
STORAGE CATEGORY
NFPA 30B Level 3 Aerosol
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE
Keep away from heat, sparks, and open flame. Vapors will accumulate readily and may ignite explosively.
During use and until all vapors are gone: Keep area ventilated, do not smoke, extinguish all flames, pilot
Lights, and heaters, turn off stoves, electric tools and appliance, and any other sources of ignition.
Consult NFPA Code. Use approved Bonding and Grounding procedures.
Contents under pressure. Do not puncture, incinerate, or expose to and other heat sources could cause
container to burst. Do not take internally. Keep out of the reach of children.
SECTION 8 EXPOSURE CONTROLS/PERSONAL PROTECTION
PRECAUTIONS TO BE TAKEN IN USE
Use only with adequate ventilation.
Avoid contact with skin and eyes. Avoid breathing vapor and spray mist.
Wash hands after using.
VENTILATION
Local exhaust preferable. General exhaust acceptable if the exposure to materials in Section 2 is
maintained below applicable exposure limits.
Refer to OSHA Standards 1910.94, 1919.107, 1910.108.
RESPIRATORY PROTECTION
If personal exposure cannot be controlled below applicable limits by ventilation, wear a properly fitted
organic vapor/particulate respirator approved by NIOSH/MSHA for protection against materials in
section 2.
PROTECTIVE GLOVES
None required for normal application of aerosol products where minimal skin contact is expected. For
long or repeated contact, wear chemical resistant gloves.
EYE PROTECTION
Wear safety spectacles with unperforated sideshields.
OTHER PRECAUTIONS
Intentional misuse be deliberately concentrating and inhaling the contents can be harmful or fatal.
Material Safety Data Sheet Product Number 83013
SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES
PRODUCT WEIGHT 6.22 1b/gal 744 g/l
SPECIFIC GRAVITY 0.75
BOILING POINT <0 鈥? 550掳 F <-18-287掳 C
MELTING POINT Not Available
VOLATILE VOLUME 90%
EVAPORATION RATE Faster than ether
VAPOR DENSITY Heavier than air
SOLUBILITY IN WATER N/A.
VOLATILE ORGANIC COMPOUNDS (VOL Theoretical )
Volatile Weight 88.00% Less Federally Exempt Solvents
SECTION 10 STABILITY AND REACTIVITY
STABILITY 鈥? Stable
CONDITIONS TO AVOID
None known.
INCOMPATIBILITY
None know
HAZARDOUS DECOMPOSITION PRODUCTS
By fire: Carbon Dioxide, Carbon Monoxide
HAZARDOUS POLYMERIZATION
Will not occur
SECTION 11 TOXICOLOGICAL INFORMATION
CRONIC HEALTH HAZARDS
No ingredient in this product is an IRAC, NTP or OSHA listed carcinogen. Reports have associated
repeated and prolonged overexposure to solvents with permanent brain and nervous system damage.
TOXICOLOGY DATA
CAS No. Ingredient Name
74-98-6 Propane LC50 RAT 4HR Not Available
LD RAT Not Available
106-97-8 Butane LC50 RAT 4 HR Not Available
LD50 RAT Not Available
68551-20-2 Heavy Aliphatic Naphtha
LC50 RAT 4 HR Not Available
LD RAT Not Available
64741-73-7 Distillates, petroleum, alkylate
LC50 RAT 4 HR Not Available
LD50 RAT Not Available
SECTION 12 ECOLOGICAL INFORMATION
ECOTOXICOLOGICAL INFORMATION
No data available
SECTION 13 DISPOSAL CONSIDERATIONS
WASTE DISPOSAL METHOD
Waste from the product may be hazardous as defined under the Resource Conservation and Recovery Act (RCRA) 40 CFR 261.
Waste must be tested for ignitability to determine the applicable EPA hazardous waste numbers.
Do not incinerate. Depressurize container. Dispose of in accordance with Federal, State and Local regulations regarding pollution.
Material Safety Data Sheet Product Number 83013
SECTION 14 TRANSPORT INFORMATION
Call for information
SECTION 15 REGULATORY INFORMATION
SARA 313 (40 CFR 372.62C) Supplier Notification
CAS NO. CHEMICAL/COMPOUND % by WT. % Element
No ingredients in this product are subject to SARA 313 (40 CFR 372.65C)
Supplier Notification.
TSCA CERTIFICATION
All chemicals in this product are listed, or are exempt from listing, on the TSCA Inventory.
SECTION 16 OTHER INFORMATION
This product has been classified in accordance with hazard criteria of the CPR and MSDS contains all of the information
required by the CFR.
The above information pertains to this product as currently formulated, and is based on the information available at this time.
Addition of reducers or other additives to this product may substantially alter the composition and hazards of the product. Since
conditions of use are outside our control, we make no warranties, express or implied, and assume no liability in connection with any of
this information.
|