MATERIAL SAFETY DATA SHEET
Share Corporation
P.O. Box 245013
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 355-4000
EMERGENCY TELEPHONE NUMBER: (800) 776-7192 REVISION DATE: January 2, 2003
CHEMTREC: (800) 424-9300 DATE OF ISSUE: January 15, 2003
I - Product Identification
Paint Stripper
PRODUCT CODE: 8580
CHEMICAL FORMULATION: Pressurized solvent based cleaner.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 3 FLAMMABILITY: 4 REACTIVITY: 1
HAZARD RATING: 4 - Extreme; 3 - High; 2 - Moderate; 1 - Slight; 0 - Insignificant
II - Hazardous Ingredients
Values reported as TWA unless noted.
APPROX OSHA ACGIH EPA 40 CFR:
SUBSTANCE % PEL TLV 302 355 372 CAS #
Methylene Chloride 40.0-60.0 25 ppm 25 ppm Y N Y 75-09-2
Toluene 10.0-20.0 100 ppm 100 ppm Y N Y 108-88-3
Methanol 1.00-5.00 200 ppm 200 ppm Y N Y 67-56-1
Liquid Petroleum Gas 5.00-10.0 1000 ppm 1000 ppm N N N 68476-85-7
Key: PEL: Permissible Exposure Limit TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit
N/A: Not Applicable N/D: Not Determined N/E: Not Established Y: Yes N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
SPECIFIC GRAVITY (WATER = 1): 1.13
BOILING POINT (掳 F): 96
VAPOR PRESSURE (mm Hg): 50 VOC CONTENT (% by weight): ~ 45
VAPOR DENSITY (AIR = 1): > 1.0 EVAPORATION RATE (WATER = 1): N/D
SOLUBILITY IN WATER: Slight pH: N/A
APPEARANCE AND ODOR: Clear to opaque liquid, mild sweet solvent odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (掳 F): -70 (concentrate) (TEST METHOD): T.O.C. FLAME EXTENSION: N/D
FLAMMABLE LIMITS IN AIR (VOLUME %) UPPER: N/D LOWER: N/D NFPA 30B Rating: 1
EXTINGUISHING MEDIA: Foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: Extreme temperature above 120 掳 F may cause bursting.
PRODUCT NAME: Paint Stripper PRODUCT CODE: 8580
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizers, acids and bases & selected amines.
CONDITIONS TO AVOID: Excess heat and open flame.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon; hydrogen chloride and
phosgene.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION: X EYE CONTACT: X SKIN CONTACT: X INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS:
Methylene Chloride (CAS# 75-09-2)
EFFECTS OF OVEREXPOSURE
IF IN EYES: Moderate irritation, pain, slight corneal injury.
IF ON SKIN: Irritation, with prolonged or repeated exposure.
IF SWALLOWED: Gastrointestinal irritation, nausea, vomiting, and diarrhea. Aspiration of material into the lungs can cause
chemical pneumonitis.
IF INHALED: Irritation of nasal and upper respiratory tract. Abusive or excessive inhalation may cause dizziness, nausea and other
central nervous system effects.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical
attention.
IF ON SKIN: Wash with soap and water. If irritation persists, obtain medical attention.
IF SWALLOWED: Contact physician or poison control center immediately. Do not induce vomiting.
IF INHALED: Remove person to fresh air. If breathing has stopped, administer artificial respiration.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and remove all sources of ignition. Contain
spill. Soak up spilled material with inert absorbent material and place in a properly marked closed container for proper disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities. Dispose of cans in non-incinerated trash only.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. Do not breathe vapors or mists. If recommended Exposure Limits
are exceeded wear a NIOSH approved respirator, following manufacturer鈥檚 recommendations.
VENTILATION LOCAL: Recommended MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses or chemical resistant gloves.
OTHER PROTECTIVE EQUIPMENT: Protective clothing.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from heat or open flame. Do
not expose to direct sunlight or store at temperatures above 120 掳 F.
OTHER PRECAUTIONS: Keep out of reach of children. Do not puncture or incinerate container.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: Consumer Commodity
DOT CLASS: ORM-D DOT ID NUMBER: None DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further
intended, different shipping names and labeling may apply.
REVISION DATE: January 2, 2003 Prepared by: PMR DATE OF ISSUE: January 15, 2003
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or
the results to be obtained from the use thereof. Share Corporation assumes no responsibility for personal injury or property damage to the vendee, users or third
parties caused by the material such vendees or users assume all risks associated with the use of this material.
|