MATERIAL SAFETY DATA SHEET
Share Corporation
P.O. Box 245013
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: 414-355-4000
EMERGENCY TELEPHONE NUMBER: (800) 776-7192 REVISION DATE: August 24, 2005
CHEMTREC: (800) 424-9300 DATE OF ISSUE: September 8, 2005
I - Product Identification
Adhesive - General Adhesive
PRODUCT CODE: A61038103
CHEMICAL FORMULATION: Cyanoacrylate adhesive.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 2 FLAMMABILITY: 2 REACTIVITY: 1
HAZARD RATING: 4 - Extreme; 3 - High; 2 - Moderate; 1 - Slight; 0 - Insignificant
II - Hazardous Ingredients
Values reported as TWA unless noted.
APPROX OSHA ACGIH EPA 40 CFR:
SUBSTANCE % PEL TLV 302 355 372 CAS #
Ethyl cyanoacrylate 90.0-100.0 None 0.2 ppm N N N 7085-85-0
Poly (methyl methacrylate) 1.00-10.0 N/E N/E N N N 9011-14-7
3
2 mg/m3
Hydroquinone 0.10-0.50 2 mg/m N N N 12-31-9
Key: PEL: Permissible Exposure Limit TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit
N/A: Not Applicable N/D: Not Determined N/E: Not Established Y: Yes N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
SPECIFIC GRAVITY (WATER = 1): 1.05
BOILING POINT (掳F): >300
VAPOR PRESSURE (mm Hg): <0.2 mm Hg @ 75潞F VOC CONTENT (% by weight): 87.1
VAPOR DENSITY (AIR = 1): 3 EVAPORATION RATE (WATER = 1): N/D
SOLUBILITY IN WATER: Polymerized pH: N/D
APPEARANCE AND ODOR: Clear liquid; sharp irritating odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (掳F): 160-200 (TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %) UPPER: N/A LOWER: N/A
EXTINGUISHING MEDIA: Foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: None
PRODUCT NAME: Adhesive - General Adhesive PRODUCT CODE: A61038103
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Polymerized by contact with water, alcohol, amines, alkalis.
CONDITIONS TO AVOID: Not available
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION: X EYE CONTACT: X SKIN CONTACT: X INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None
EFFECTS OF OVEREXPOSURE
IF IN EYES: Irritant.
IF ON SKIN: Irritant. May cause burns. Bonds rapidly to skin.
IF SWALLOWED: Ingestion is not likely.
IF INHALED: Irritation to mucous membranes. Prolonged and repeated over exposure to vapors may produce allergic reactions with
asthma-like symptoms in sensitive individuals.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical
attention.
IF ON SKIN: Wash with soap and water. Remove contaminated clothing and launder separately before reuse. If irritation persists,
obtain medical attention.
IF SWALLOWED: Contact physician or poison control center immediately.
IF INHALED: Remove person to fresh air.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and remove all sources of ignition. Contain
spill. Flood area with water to polymerize the material. Soak up with inert absorbent material and place in a properly marked closed
container for proper disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. If recommended Exposure Limits are exceeded wear a NIOSH
approved respirator, following manufacturer鈥檚 recommendations.
VENTILATION: LOCAL: Recommended MECHANICAL: Recommended
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses or goggles.
OTHER PROTECTIVE EQUIPMENT: Polyethylene aprons.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from heat or open flame. Keep
container tightly closed when not in use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: N/A
DOT CLASS: N/A DOT ID NUMBER: N/A DOT PACKING GROUP: N/A
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further
intended, different shipping names and labeling may apply.
REVISION DATE: August 24, 2005 Prepared by: Technical Dept DATE OF ISSUE: September 8, 2005
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the
results to be obtained from the use thereof. Share Corporation assumes no responsibility for personal injury or property damage to the vendee, users or third
parties caused by the material such vendees or users assume all risks associated with the use of this material.
|