#816
MATERIAL SAFETY DATA SHEET
EPA Reg. No. 47371-131-1658 EPA Est. No. 1658-MO-1
NFPA RATING: Health = 2 Flammability = 0 Reactivity = 0
HMIS RATING: Health = 2 Flammability = 1 Reactivity = 0
SECTION I -- IDENTITY AND MANUFACTURER'S INFORMATION (1090A)
Manufacturer's Name: HILLYARD INDUSTRIES Product Name: ARSENAL RE-JUV-NAL
Address: 302 North Fourth Street Date Prepared: September 21, 2006
St. Joseph, MO 64501 Prepared by: Regulatory Affairs Department
Emergency Telephone No.: (800) 424-9300 (Only in the event of chemical emergency involving a spill, leak, fire, exposure or
accident involving chemicals.) Other information calls: (816) 233-1321 (Ext. 8285)
http://www.hillyard.com
SECTION II -- INGREDIENTS/IDENTITY INFORMATION
Components
(Specific Chemical Identity: ACGIH OTHER LIMITS
Common Name(s) CAS# OSHA PEL TLV RECOMMENDED %
Didecyl dimethyl ammonium chloride 7173-51-5 not established N/A N/A 2.54
n-Alkyl (C14 50%, C12 40%, C16 10%) dimethyl 8001-54-5 not established N/A N/A 1.69
benzyl ammonium chloride
Octyl dimethyl amine oxide 2605-78-9 not established N/A N/A ---
Edtate Disodium 139-33-3 not established N/A N/A ---
Deionized water 7732-18-5 none N/A N/A ---
SECTION III -- PHYSICAL / CHEMICAL CHARACTERISTICS
210掳F Specific Gravity (H2O = 1): 25掳C = 1.00 & 39掳C = 1.00
Boiling Point:
Vapor Pressure (mm Hg.): 17.6 94.7
Percent Volatile by Volume (%):
0.6 Evaporation Rate (ethyl ether = 1): slower than 1
Vapor Density (AIR = 1):
complete clear, reddish-orange liquid; floral odor
Solubility in Water: Appearance and Odor:
pH of concentrate: 7.2 - 8.2
SECTION IV -- FIRE AND EXPLOSION HAZARD DATA
>200潞F (Tag Closed Cup) Flammable Limits: LEL = Not applicable UEL = Not applicable
Flash point:
Foam, alcohol foam, carbon dioxide, dry chemical, water
Extinguishing Media:
Special Fire Fighting Procedures: Must wear NIOSH/MSHA approved self-contained breathing apparatus and
protective clothing. Cool fire-exposed containers with water spray.
Unusual Fire and Explosion Hazards: Products of combustion are toxic.
SECTION V -- PHYSICAL HAZARDS
Stability: Stable Conditions to Avoid: N/A
Incompatibility (Materials to Avoid): Strong oxidizing and reducing agents.
Hazardous Decomposition Products or Byproducts: Thermal decomposition may produce toxic vapors/fumes of
Hydrogen chloride, amines, and other organic materials, and oxides of carbon and nitrogen.
Hazardous Polymerization: Will not occur Conditions to Avoid: None known to Hillyard
SECTION VI -- HEALTH HAZARD DATA
Routes of entry: Inhalation? yes Skin? yes Eye? Yes Ingestion? yes
HEALTH HAZARDS (1. Acute and 2. Chronic)
1. From previous experience with a 2 oz. per gallon alkaline quat, the oral LD50 (rat): 1850 mg/kg; Dermal LD50
(Rabbit): 4430 mg/kg.; Eye: Diluted product 1:64 (rabbit) essentially non-irritating; Skin irritation: Diluted product 1:64
(rabbit) non-irritating. Inhalation of fine fog mist can cause irritation of mucous membranes. Fine fog mist application is
not recommended. 2. None known to Hillyard.
Chemical listed as Carcinogen or Potential Carcinogen:
National Toxicology Program = No I.A.R.C. Monographs = No OSHA = No
Signs and Symptoms of Exposure: Causes irreversible eye damage. Do not get in eyes or clothing. Wear protective
eyewear (goggles, face shield, or safety glasses). Avoid contact with skin. Harmful if inhaled. Avoid breathing spray
mist. Wash thoroughly with soap and water after handling. Remove contaminated clothing and wash clothing before
reuse.
page 2 of #816 鈥? Arsenal Re-Juv-Nal
SECTION VI -- HEALTH HAZARD DATA continued:
Medical Conditions Generally Aggravated by Exposure: None known to manufacturer.
Emergency and First Aid Procedures: If in eyes: Hold eye open and rinse slowly and gently with water for at least 15-20
minutes. If on skin or clothing: Take off contaminated clothing. Rinse skin immediately with plenty of water for 15-20 minutes.
If inhaled: Move person to fresh air. If person is not breathing, call 911 or an ambulance, then give artificial respiration,
preferably by mouth-to-mouth, if possible. Call a poison control center or doctor for treatment advice. Have the product container
or label with you when calling a poison control center or doctor or going for treatment. NOTE TO PHYSICIAN: Probable
mucosal damage may contraindicate the use of gastric lavage.
SECTION VII -- PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken In Case Material Is Released Or Spilled: Caution. Floors may become slippery. Wear appropriate
protective gear and respiratory protection where mist or vapors of unknown concentrations may be generated (self-contained
breathing apparatus preferred). Dike and contain spill with inert material (sand, earth, etc.) and transfer the liquid and solid
separately to containers of recovery or disposal. Keep spill out of sewers and open bodies of water.
Waste Disposal Method: Dispose of in compliance with all federal, state and local laws and regulations. Incineration is the
preferred method.
Precautions To Be Taken In Handling And Storing: Keep away from children.
Other Precautions: Store in original container in areas inaccessible to children. Open dumping is prohibited Do not reuse empty
container. This product contains no reportable quantities of toxic chemicals subject to reporting requirements of Section 313 of
SARA Title III Emergency Planning & Community Right to Know Act of 1986 and 40 CFR Part 372.
SECTION VIII -- CONTROL MEASURES
Ventilation: In processes where mists or vapors must be generated, proper ventilation must be provided in accordance with good
ventilation practices. Respiratory Protection (Specify Type): In processes where mists or vapors may be generated, a
NIOSH/MSHA jointly approved respirator is advised in the absence of proper environmental controls. Protective Gloves:
Rubber or neoprene, when needed, to prevent skin contact with concentrate. Eye Protection: Wear chemical splash goggles
where there is a potential for eye contact. Use safety glasses with side shields under normal use conditions. Other Protective
Clothing or Equipment: Eye wash; safety shower, protective clothing (long sleeves, coveralls or other, as appropriate), when
needed to prevent skin contact with concentrate. Work / Hygienic Practices: Wash hands thoroughly after handling.
SECTION IX -- TRANSPORTATION INFORMATION
Applicable regulations: 49 CFR = No; IMCO = No; IATA = No
Proper shipping name: Cleaning Compound; UN No.: Not applicable; Limited Qty.: Not applicable;
Hazard Class: Not applicable
Labels required: Not required Exception: Not applicable
EPA Hazardous waste number/code: Not listed
Hazardous waste characteristics: Ignitability = Not applicable; Corrosivity = Not applicable; Reactivity = Not applicable
DISCLAIMER OF WARRANTIES
NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY,
FITNESS FOR A PARTICULAR PURPOSE, OR OF ANY NATURE ARE MADE WITH RESPECT TO THE
PRODUCT(S) OR INFORMATION CONTAINED IN THIS MATERIAL SAFETY DATA SHEET. The information and
recommendations contained in this Material Safety Data Sheet are supplied pursuant to 29 CFR 1910.1200 of the
Occupational Safety and Health Standards Hazard Communication Rule. All information contained herein is presented in
good faith and is believed to be appropriate and accurate. THE BUYER OR USER ASSUMES ALL RISKS
ASSOCIATED WITH THE USE, MISUSE OR DISPOSAL OF THIS PRODUCT. THE BUYER OR USER IS
RESPONSIBLE TO COMPLY WITH ALL FEDERAL, STATE OR LOCAL REGULATIONS CONCERNING THE
USE, MISUSE OR DISPOSAL OF THESE PRODUCTS.
|