#821
MATERIAL SAFETY DATA SHEET
NFPA RATING: Health = 2 Flammability = 0 Reactivity = 0
HMIS RATING: Health = /2 Flammability = 0 Reactivity = 0
SECTION I -- IDENTITY AND MANUFACTURER'S INFORMATION (502N-42G)
Manufacturer's Name: HILLYARD INDUSTRIES Product Name: TYPHOON
Address: 302 North Fourth Street Date Prepared: September 18, 2001
St. Joseph, MO 64501 Prepared by: Regulatory Affairs Department
Emergency Telephone No.: (800) 424-9300 (Only in the event of chemical emergency involving a spill, leak, fire, exposure or
accident involving chemicals.) Other information calls: (816) 233-1321 (Ext. 8285)
SECTION II -- INGREDIENTS/IDENTITY INFORMATION
Components
(Specific Chemical Identity: OTHER LIMITS
Common Name(s) CAS# OSHA PEL ACGIH TLV RECOMMENDED %
Dipropylene glycol methyl ether 34590-94-8 100ppm 100 ppm STEL-150 ppm 8-13%
Water 7732-18-5 not established not established N/A ---
Linear primary alcohol ethoxylate 68439-46-3 not established not established N/A ---
Propylene glycol butyl ether 5131-66-8 not established not established N/A ---
Propylene Glycol N-Propyl Ether 1569-01-3 not established not established N/A ---
Didecyl dimethyl ammonium chloride 7173-51-5 not established not established N/A ---
n-Alkyl (C14 50%, C12 40%, C16 10%) 8001-54-5 not established not established N/A ---
dimethyl benzyl ammonium chloride
Lauramine oxide 1643-20-5 not established not established N/A ---
Tetrasodium Salt of EDTA 64-02-8 not established not established N/A ---
VOS (Concentrate) = 20% or 1.7 lbs./gallon; VOS (Diluted 1:12) = 1.54%
SECTION III -- PHYSICAL / CHEMICAL CHARACTERISTICS
corrected 206掳F 0.99 & 39掳C = 0.99
Boiling Point: Specific Gravity (H2O = 1): 25掳C =
16.9 86.54%
Vapor Pressure (mm Hg.): Percent Volatile by Volume (%):
1.6 slower than 1
Vapor Density (AIR = 1): Evaporation Rate (ethyl ether = 1):
Complete clear orange liquid; fresh & clean mint
Solubility in Water: Appearance and Odor:
odor
10.74 鈥? 11.74
pH (concentrate) =
SECTION IV -- FIRE AND EXPLOSION HAZARD DATA
None (Tag Closed Cup) Flammable Limits: LEL = N/A UEL = N/A
Flash point:
Extinguishing Media: Foam, carbon dioxide, dry chemical, water spray.
Special Fire Fighting Procedures: Self-contained breathing apparatus and protective clothing should be worn in
fighting fires involving chemicals.
Unusual Fire and Explosion Hazards: None known to manufacturer.
SECTION V -- PHYSICAL HAZARDS
Stable N/A
Stability: Conditions to Avoid:
Incompatibility (Materials to Avoid): Do not mix with strong acids.
Hazardous Decomposition Products or Byproducts: As with any organic material, combustion will
produce carbon dioxide and carbon monoxide.
Will not occur N/A
Hazardous Polymerization: Conditions to Avoid:
SECTION VI -- HEALTH HAZARD DATA
Routes of entry: Inhalation? Yes Skin? Yes Ingestion? Yes
HEALTH HAZARDS (1. Acute and 2. Chronic)
1. When tested per the Federal Hazardous Substance Act, the concentrate was found to be a Primary Skin Irritant (concentrate
induced crust formation in all six test subjects by day 7) and per this method concentrate was also found to be a primary eye
irritant. (neovascularization was observed in all 6 test subjects by day 7). Concentrate induced mortality in one test subject;
concentrate was estimated to have an acute oral LD50 of greater than 5 g./kg. When diluted 1:6 product was not acutely toxic to
10 test subjects following a one hour exposure at a nominal concentration of 52.7026 mg./L (actual concentration = 37.7248
mg./L.) This concentration was the maximum that could be generated with this test system. 2. None known to Hillyard.
page 2 of #821 Typhoon
SECTION VI -- HEALTH HAZARD DATA continued
Chemical listed as Carcinogen or Potential Carcinogen:
No No No
National Toxicology Program = I.A.R.C. Monographs = OSHA =
This product has no carcinogens listed by IARC, NTP, NIOSH, or ACGIH as of this date, greater than or equal to 0.1%.
Signs and Symptoms of Exposure: May cause redness of eyes; prolonged contact may cause skin and eye burns with
concentrate. Prolonged breathing of fine fog mist may cause nose, throat, and lung irritation.
Medical Conditions Generally Aggravated by Exposure: Repeated overexposure may cause defatting of skin and dermatitis.
Emergency and First Aid Procedures: In case of contact, immediately flush eyes or skin with plenty of water for at least 15
minutes while removing contaminated clothing and shoes. Remove contact lenses then flush eyes with water again. Get
medical attention. Wash clothing before reuse and thoroughly clean contaminated shoes before reuse. If swallowed, do not
induce vomiting; immediately give large amounts of water and CALL A PHYSICIAN, hospital emergency room or poison
control center. Inhalation -remove victim to fresh air; if respiratory tract remains irritated call a physician.
SECTION VII -- PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken In Case Material Is Released Or Spilled: Absorb large spills with floor dry material (see disposal
below). Small spills: Flush with water and pick up with mop or wet vacuum.
Waste Disposal Method: Dispose of in accordance with state or local regulations. Do not dispose of in storm drains or
streams.
Precautions To Be Taken In Handling And Storing: Keep container closed when not in use. Since empty packages retain
product residue, follow label warning even after package is empty. Spray mist may produce respiratory irritation or damage and
increase susceptibility to respiratory illness.
Other Precautions: Do not get in eyes, on skin, or on clothing. USE ONLY WITH ADEQUATE VENTILATION. Avoid
breathing vapors or spray mist. Open windows and doors, use exhaust fans or other means to insure fresh air entry during
application and drying. Refer to OSHA STANDARD 29 CFR 1910.94 for technical guidelines on keeping air contaminates
below acceptable exposure limits. Wash thoroughly after handling. Do not take internally. Keep container closed when not in
use. In case of spillage, absorb with inert material and dispose of in accordance with applicable regulations.
SECTION VIII -- CONTROL MEASURES
Respiratory Protection (Specify Type): Ventilate to keep air below TLV. A NIOSH approved respirator for organic vapor
should be worn if needed to keep level below TLV.
Ventilation:
Recommended Recommended N/A
Local Exhaust = Mechanical (General) = Special =
N/A Chemical safety goggles
Other = Eye Protection:
Other Protective Clothing or Equipment: Impervious boots and aprons where splashing of concentrate is a problem;
otherwise, use uniforms or coveralls.
Work / Hygienic Practices: Wash thoroughly after handling.
SECTION IX - TRANSPORTATION INFORMATION
Applicable regulations: 49 CFR = no; IMCO = no; IATA = no
Proper shipping name: Cleaning compound
UN NO.: not applicable Limited Qty.: not applicable Hazard Class = not applicable
Labels required: not required DOT Exception: not applicable
EPA Hazardous waste number / code: not listed
Hazardous waste characteristics:
Ignitability = not applicable; Corrosivity = not applicable; Reactivity = not applicable
DISCLAIMER OF WARRANTIES
NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS FOR A
PARTICULAR PURPOSE, OR OF ANY NATURE ARE MADE WITH RESPECT TO THE PRODUCT(S) OR INFORMATION
CONTAINED IN THIS MATERIAL SAFETY DATA SHEET.
The information and recommendations contained in this Material Safety Data Sheet are supplied pursuant to 29 CFR 1910.1200 of the
Occupational Safety and Health Standards Hazard Communication Rule. All information contained herein is presented in good faith and is
believed to be appropriate and accurate.
THE BUYER OR USER ASSUMES ALL RISKS ASSOCIATED WITH THE USE, MISUSE OR DISPOSAL OF THIS PRODUCT. THE
BUYER OR USER IS RESPONSIBLE TO COMPLY WITH ALL FEDERAL, STATE OR LOCAL REGULATIONS CONCERNING THE
USE, MISUSE OR DISPOSAL OF THESE PRODUCTS.
|