MATERIAL SAFETY DATA SHEET
FL109 Page: 1
PRODUCT NAME: MIGHTY VS7 THROTTLE PLATE CLEANER HMIS CODES: H F R P
PRODUCT CODE: FL109 2*2 0
================== SECTION I - DISTRIBUTOR IDENTIFICATION ==================
DISTRIBUTOR'S NAME : MIGHTY DISTRIBUTING SYSTEM OF AMERICA
ADDRESS : 650 ENGINEERING DRIVE
NORCROSS, GA 30092
EMERGENCY PHONE : 770-448-3900 DATE PRINTED : 6/13/2003
INFORMATION PHONE : 770-448-3900 NAME OF PREPARER : ESP
========== SECTION II -HAZARDOUS INGREDIENTS/SARA III INFORMATION =========
VAPOR PRESSURE WEIGHT
REPORTABLE COMPONENTS CAS NUMBER mm Hg @ TEMP PERCENT
--------------------------------------------------------------------------------
ACETONE 67-64-1 181 68 49
OSHA PEL: 750 PPM, ACGIH TLV: 750 PPM
* TOLUENE 108-88-3 10 81 45
OSHA PEL: 200PPM TWA, ACGIH TLV: 100 PPM, : 200PPM ACC
CARBON DIOXIDE 124-38-9 38650 60 6
OSHA PEL: 10000 PPM, ACGIH TLV: 5000 PPM
* Indicates toxic chemical(s) subject to the reporting requirements of
section 313 of Title III and of 40 CFR 372.
=============== SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS ============
BOILING RANGE: 133 deg F - 231 deg F SPECIFIC GRAVITY (H2O=1): 0.83
VAPOR DENSITY: HEAVIER THAN AIR EVAPORATION RATE: SLOWER THAN ETHER
SOLUBILITY IN WATER: SLIGHT TO MODERATE
APPEARANCE AND ODOR: AEROSOL PRODUCT
================= SECTION IV - FIRE AND EXPLOSION HAZARD DATA ==============
FLASH POINT: 1 deg F METHOD USED: TCC
FLAMMABLE LIMITS IN AIR BY VOLUME- LOWER: 1.2 UPPER: 13
EXTINGUISHING MEDIA: FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
SPECIAL FIREFIGHTING PROCEDURES
WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CONTAINERS TO PREVENT
PRESSURE BUILD-UP AND EXPLOSION WHEN EXPOSED TO EXTREME HEAT. IF WATER IS USED,
FOG NOZZLES PREFERRED. WEAR GOGGLES AND SELF-CONTAINED BREATHING APPARATUS.
UNUSUAL FIRE AND EXPLOSION HAZARDS
CLOSED CONTAINERS MAY EXPLODE FROM INTERNAL PRESSURE BUILD-UP WHEN EXPOSED TO
EXTREME HEAT AND DISCHARGE CONTENTS. VAPOR ACCUMULATION CAN FLASH OR EXPLODE IF
IGNITED. OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD.
SYMPTOMS MAY NOT BE READILY APPARENT. OBTAIN MEDICAL ATTENTION.
======================== SECTION V - REACTIVITY DATA =======================
STABILITY: STABLE
CONDITIONS TO AVOID
APPLICATION TO HOT SURFACES. STORAGE ABOVE 120 DEG F. EXPOSURE TO OPEN FLAME.
INCOMPATIBILITY (MATERIALS TO AVOID)
STRONG OXIDIZING AGENTS.
MATERIAL SAFETY DATA SHEET
FL109 Page: 2
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
MAY PRODUCE FUMES WHEN HEATED TO DECOMPOSITION. FUMES MAY CONTAIN CARBON
MONOXIDE AND OTHER TOXIC FUMES.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
==================== SECTION VI - HEALTH HAZARD DATA =======================
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
RESPIRATORY IRRITATION, HEADACHE, NAUSEA, FATIGUE, DROWSINESS, IMPAIRED CO-
ORDINATION, POSSIBLE UNCONSCIOUSNESS.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
SKIN: CONTACT MAY DRY THE SKIN; PROLONGED CONTACT MAY CAUSE IRRITATON. EYES:
LIQUID OR VAPOR CAN CAUSE SEVERE IRRITATION, REDNESS, TEARING, AND BLURRED
VISION; PROLONGED CONTACT MAY LEAD TO CORNEAL DAMAGE.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
MAY BE ABSORBED. SOLVENT ACTION CAN DRY AND DEFAT THE SKIN CAUSING THE SKIN TO
CRACK, LEADING TO DERMATITIS.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
NOT A LIKELY ROUTE OF EXPOSURE. CAN CAUSE GASTRO-INTESTINAL IRRITATION,
VOMITING, DIARRHEA, BLINDNESS AND DEATH. IF SWALLOWED, DO NOT INDUCE VOMITING.
SEEK IMMEDIATE MEDICAL ADVICE AND/OR ATTENTION.
HEALTH HAZARDS (ACUTE AND CHRONIC)
ACUTE: EYE IRRITANT. SKIN IRRITANT. NARCOTIC IN HIGH CONCENTRATIONS. CHRONIC:
UNKNOWN FOR PRODUCT AS A WHOLE.
CARCINOGENICITY: NTP CARCINOGEN: No IARC MONOGRAPHS: No OSHA REGULATED: No
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
ACUTE AND CHRONIC LIVER AND KIDNEY DISEASE, ANEMIA.
EMERGENCY AND FIRST AID PROCEDURES
INHALATION: REMOVE TO FRESH AIR. ADMINISTER OXYGEN IF NEEDED. APPLY ARTIFICIAL
RESPIRATION IF BREATHING HAS STOPPED. GET MEDICAL ATTENTION. SKIN: WIPE OFF WITH
TOWEL. WASH WITH SOAP AND WATER. GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
EYES: WASH IMMEDIATELY WITH LARGE VOLUMES OF FRESH WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION.
=========== SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE ============
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
AVOID BREATHING VAPORS. VENTILATE AREA. REMOVE ALL SOURCES OF IGNITION. CLEAN UP
AREA WITH ABSORBENT MATERIAL AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
WASTE DISPOSAL METHOD
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. BEFORE
ATTEMPTING CLEAN UP, REFER TO OTHER SECTIONS OF THIS MSDS FOR HAZARD CAUTION
INFORMATION.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
STORE AND USE IN COOL, DRY, WELL-VENTILATED AREAS. DO NOT STORE ABOVE 120 DEG F.
DO NOT PUNCTURE OR INCINERATE (BURN) CANS. DO NOT STICK PIN, NAIL OR ANY OTHER
SHARP OBJECT INTO OPENING ON TOP OF CAN. DO NOT SPRAY IN EYES. DO NOT TAKE
INTERNALLY. SEE PRODUCT LABEL FOR ADDITIONAL INFORMATION.
MATERIAL SAFETY DATA SHEET
FL109 Page: 3
OTHER PRECAUTIONS
SMALL PRESSURIZED CONTAINERS OF FLAMMABLE PRODUCTS MAY BE STORED IN AREAS
SUITABLE FOR ORDINARY COMBUSTIBLES WITH RESPECT TO CONSTRUCTION, DRAINAGE,
CONTROL OF IGNITION SOURCES, AND VENTILATION EXCEPT THAT THEY SHOULD NOT BE
STORED IN BASEMENTS. STORAGE SHOULD BE IN AREAS SUITABLE FOR LEVEL 2 AEROSOLS.
===================== SECTION VIII - CONTROL MEASURES ======================
RESPIRATORY PROTECTION
NONE UNDER NORMAL USE. AVOID BREATHING VAPORS. IN RESTRICTED AREAS, USE APPROVED
CHEMICAL/MECHANICAL FILTERS DESIGNED TO REMOVE A COMBINATION OF PARTICLES AND
VAPOR. IN CONFINED AREAS, USE APPROVED AIR LINE TYPE RESPIRATOR OR HOOD. SELF-
CONTAINED BREATHING APPARATUS IS REQUIRED FOR VAPOR CONCENTRATIONS ABOVE PEL/TLV
LIMITS.
VENTILATION
SUFFICIENT TO PREVENT INHALATION OF SOLVENT VAPORS. GENERAL DILUTION AND/OR
LOCAL EXHAUST VENTILATION IN VOLUME OR PATTERN TO KEEP PEL/TLV OF MOST HAZARDOUS
INGREDIENT BELOW ACCEPTABLE LIMIT AND LEL BELOW STATED LIMIT.
PROTECTIVE GLOVES
NONE UNDER NORMAL USE. SOLVENT RESISTANT REQUIRED FOR PROLONGED OR REPEATED
CONTACT.
EYE PROTECTION
NONE UNDER NORMAL USE; HOWEVER, USE OF SAFETY GLASSES WITH SPLASH GUARDS OR FULL
FACE SHIELD IS RECOMMENDED.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
NONE UNDER NORMAL USE; HOWEVER, USE OF SOLVENT RESISTANT APRONS OR OTHER
CLOTHING IS RECOMMENDED.
WORK/HYGIENIC PRACTICES
EYE WASHES AND SAFETY SHOWERS IN THE WORKPLACE ARE RECOMMENDED.
========================= SECTION IX - DISCLAIMER ==========================
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE. HOWEVER,
NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THE DATA OR THE
RESULTS TO BE OBTAINED FROM THE USE THEREOF. BECAUSE THE INFORMATION CONTAINED
HEREIN MAY BE APPLIED UNDER CONDITIONS BEYOND OUR CONTROL, WE ASSUME NO
RESPONSIBILITY FOR ITS USE.
|