Friday, January 19, 2007
Page 1 of 4
MSDS - Material Safety Data Sheet
I. Basic Information:
Contact: Not Available
Manufacturer: LIFE AUTOMOTIVE PRODUCTS INC.
Not Available
Address: 1210 MIDAS COVE, SUITE 101 Information Telephone Number:
City, ST Zip: CORDOVA, TN 38018 Emergency Contact: CHEMTREC
Country: Emergency Telephone Number: 800-424-9300
Emergency Restrictions:
Product Name: MIGHTY AUTO PARTS VS7 SYNTRAMAX COMPLETE FUEL SYSTEM CLEANER
MSDS No.: SB304
Issue Date: 01/17/2007
Supersedes Date: Not Available
II. Hazards Identification:
EMERGENCY OVERVIEW
Danger: Harmful or fatal if swallowed. Eye and skin irritant. Combustible.
OSHA Regulatory Status
This material is considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200).
Potential Health Effects
Route(s) of Entry:
Absorption, Inhalation, and Ingestion.
Health Hazards (Acute and Chronic):
See signs and symptoms below
Signs and Symptoms:
Eye Contact: Irritant. Prolonged contact may cause conjunctivitis.
Skin Contact: Irritant. Defatting of tissue, dermatitis may occur.
Inhalation: Irritant to mucous membranes. Repeated exposure may cause narcosis..
Ingestion: HARMFUL OR FATAL IF SWALLOWED. May cause burns to mouth, throat & stomach.
Medical Conditions Generally Aggravated by Exposure:
Non Known
Other Health Warnings:
Vomiting and subsequent aspiration into the lungs may lead to chemical pneumonia and pulmonary edema which is a potentially fatal condition.
Potential Environmental Effects
Not Available
III. Composition/Information on Ingredients:
Chemical Name CAS No. % Range Trade Secret
1,2,4-Trimethylbenzene 1.0 - 5.0
95-63-6
Aliphatic Hydrocarbon Solvent 60.0 - 100.0
8052-41-3
Hydrocarbon Solvent 7.0 - 13.0
Proprietary
Mesitylene 3.0 - 7.0
108-67-8
Petroleum naphtha 1.0 - 5.0
64742-94-5
Polyether amine 7.0 - 13.0
Proprietary
Xylene (mixed isomers) 1.0 - 5.0
1330-20-7
IV. First Aid Measures:
Emergency and First Aid Procedures:
Friday, January 19, 2007
Page 2 of 4
MSDS - Material Safety Data Sheet
Eye Contact: Flush eyes with clean water for 20 minutes while lifting eyelids. Get prompt medical attention.
Skin Contact: Wash skin with soap and water thoroughly. If adverse effects persist, get prompt medical attention. Remove and isolate contaminated
clothing. Launder contaminated clothing before reuse.
Inhalation: Move victim to fresh air. If breathing becomes difficult, administer oxygen and get prompt medical attention. If breathing stops, give artificial
respiration and get prompt medical attention.
Ingestion: DO NOT INDUCE VOMITING! Call Poison Control Center, physician, or hospital emergency room immediately. Aspiration of vomit into the lungs
can cause pneumonitis, which can be fatal.
Note to Physicians:
N/E
V. Fire Fighting Measures:
Suitable Extinguishing Media:
Water Fog, Foam, Carbon Dioxide, Dry Chemical
Unsuitable Extinguishing Media:
Do not use forced water stream as this could cause the fire to spread.
Products of Combustion:
Carbon dioxide, carbon monoxide, and various hydrocarbons
Protection of Firefighters:
Wear self-contained positive pressure breathing apparatus and protective clothes. Use shield to protect from rupturing and venting containers. At elevated
temperatures containers may vent, rupture or burst, even violently
VI. Accidental Release Measures:
Personal Precautions:
Eliminate all ignition sources. Persons not wearing protective equipment should be excluded from area of spill until clean-up has been completed.
Environmental Precautions:
Prevent run-off to sewers, streams, or other bodies of water. If run-off occurs, notify proper authorities as required that a spill has occurred. Run off to sewer
may create fire or explosion hazard.
Methods for Containment:
Dike or contain spill and absorb with inert materials (sand, sawdust, absorbent sweeping compounds, rags, etc).
Methods for Cleanup:
Using a non-metallic scoop, place contaminated material into an approved chemical waste container. Where possible, vacuum spilled liquid using an
explosion proof vacuum to recover material.
Other Information:
All equipment used with handling the concentrate must be grounded. If run-off occurs, notify proper authorities as required that a spill has occurred.
VII. Handling and Storage:
Handling Precautions:
Handling: Use with adequate ventilation and proper protective equipment.
Storage Precautions:
Keep container closed tightly when not in use. Combustible. Store in a cool place below 120 F away from acids, ignition sources and oxidizing agents.
VIII. Exposure Controls/Personal Protection:
Friday, January 19, 2007
Page 3 of 4
MSDS - Material Safety Data Sheet
Chemical Name OSHA PEL ACGIH TLV Other Limits
Polyether amine N/E Not Available
N/E
Hydrocarbon Solvent Not Available Not Available Not Available
Xylene (mixed isomers) 100 ppm (TWA) PA & NJ RTK
100 ppm (TWA)
Petroleum naphtha N/E 100 ppm
N/E
Aliphatic Hydrocarbon Solvent 100 ppm NJ RTK
100 ppm
Mesitylene N/A Not Available
N/A
1,2,4-Trimethylbenzene N/E Not Available
25 ppm
Engineering Controls:
See Section 2 for applicable exposure limits. Maintain adequate ventilation.
Avoid breathing vapors. In restricted areas, use approved chemical filters designed to remove vapor. In confined areas, use approved air line type respirator
or hood. A self-contained breathing apparatus is required for vapor concentrations above TLV limit
Personal Protective Equipment:
See Section 2 for applicable exposure limits. For prolonged exposure wear protective safety glasses, gloves, and apron.
IX. Physical and Chemical Properties:
Boiling Point: >300 F Melting Point: N/D
N/D Freezing Point: N/D
Boiling Range:
Solubility In Water: Insoluble Evaporation Rate (Butyl Acetate = 1): N/D
Flash Point: 140F Flash Point Method: TCC
N/D Light yellow--amber liquid with petroleum
Odor Threshold: Appearance and Odor:
odor.
Vapor Density (AIR = 1): N/D Vapor Pressure (mm Hg.): N/D
N/A N/D
pH Range: Partition Coefficient:
N/D
Decomposition Temp: Auto-Ignition Temp: N/D
Lower Explosive Limit: N/D Upper Explosive Limit: N/D
Specific Gravity (H20 = 1): 0.81
Other Information: N/D
X. Stability and Reactivity:
Stability:
Stable
Conditions to Avoid:
Avoid heat, sparks, and flames. Avoid incompatible materials.
Incompatible Materials:
Oxidizing agents. Open flame, or spark, and acids
Hazardous Decomposition Products:
Fire: Normal products of combustion: carbon monoxide, carbon dioxide, and acrid smoke.
Nitrogen and sulfur oxides
Possibility of Hazardous Reactions:
Will not occur
XI. Toxicological Information:
N/D
Friday, January 19, 2007
Page 4 of 4
MSDS - Material Safety Data Sheet
XII. Ecological Information:
N/D
XIII. Disposal Considerations:
DISPOSAL: This container may be recycled in a recycling centers when empty. Before offering for recycling, empty the can or bottle by using the product
according to the label. If recycling is not available, wrap the container and discard in the trash. Dispose of unused product in accordance with all local, state
government and federal laws and regulations
XIV. Transport Information:
Not Available
Shipping Name:
Not Available Not Available
DOT Hazard Class: DOT Subsidiary Hazard Class:
UN/NA#: Not Available Not Available
MSDSPackGroup:
Transportation Information:
DOT Shipping Name: Not DOT regulated.
DOT Hazard Class: None
The DOT description is provided to assist in the proper shipping classification of this product and may not be suitable for all shipping purposes
XV. Regulatory Information:
See Section 2 for SARA Reportable Chemicals.
USA TSCA: All components of this material are listed on the US TSCA Inventory.
This fuel additive is registered in the United States
XVI. Other Information:
Liquid Gas Solid
Chemical State: X
Pure Mixture
Chemical Type: 2
X
Hazard Category:
2 0
Acute Chronic Fire
X X
Pressure Reactive
Additional Manufacturer Warnings:
Do not used in confined area without proper ventilation. Contact lenses may
2
cause further damage in case of splash into eye. KEEP AWAY FROM
CHILDREN AND ANIMALS! 2
0
N/E: Not Established
N/D: Not Determined H
N/A: Not Applicable
Additional Product Information:
While Life Automotive Products, Inc... believes this data is accurate as of the revision date, we make no warranty with respect to the data
and we expressly disclaim all liability for reliance thereon. The data is offered solely for information, investigation, and verification. Various
government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which
may not be covered by this MSDS. The user is responsible for full compliance.
|