MATERIAL SAFETY DATA SHEET
RESPIRATO RY/INHALATION:
This material does not present an inhalation hazard.
INGESTION:
6103 Orthoway
If swallowed, this substance is considered practically non-toxic
Fort Madison, Iowa 52627
to internal organs. Ingestion may cause irritation of the digestive
Emergency Number 800-346-7237 tract which may result in nausea, vomiting and diarrhea.
C ryo t e ch E36庐 LRD (LRD = Liquid Runway Deicer)
4. PROTECTIVE EQUIPMENT
This Material Safety Data Sheet contains environmental, health
and toxicology information for your employees. Please make EYE PROTECTION:
sure this information is given to them. It also contains informa- Do not get this material in your eyes. Eye contact can be avoided
tion to help you meet community right-to-know/emergency by wearing chemical goggles.
response reporting requirements under SARA Title III and many
SKIN PROTECTION:
other laws. If you resell this product, this MSDS must be given
No special skin protection is usually necessary. Avoid prolonged
to the buyer or the information incorporated in your MSDS.
or frequently repeated skin contact with this material. Skin con-
Discard any previous edition of this MSDS.
tact can be minimized by wearing protective clothing.
R evision Date: August 2001
RESPIRATORY PROTECTION:
1. PRODUCT IDENTIFICATION No special respiratory protection is normally required.
Cryotech E36庐 LRD VENTILATION:
No special ventilation is necessary.
CAUTION! 鈥? MAY CAUSE EYE IRRITATION
PRODUCT INFORMATION: (800)346-7237
5. FIRE FIGHTING MEASURES
2. FIRST AID MEASURES
FLASH POINT: NA
EMERGENCY NUMBER (24 hr): 1-800-346-7237
AUTOIGNITION: NA
EYE CONTACT:
FLAMMABILITY LIMITS (% by volume in air):
Flush eyes immediately with fresh water for at least 15 minutes
Lower: NA Upper: NA Non-flammable
while holding the eyelids open. Remove contact lenses if worn.
No additional first aid should be necessary. However, if irritation EXTINGUISHING MEDIA:
persists, see a doctor. NA 鈥? Material is not flammable
SKIN CONTACT:
FIRE FIGHTING PROCEDURES:
No first aid procedures are required. As a precaution, wash skin
This material normally will not burn.
thoroughly with soap and water. Remove and wash contami-
nated clothing. COMBUSTION PRODUCTS:
INHALATION: Normal combustion forms carbon dioxide and water vapor.
Since this material is not expected to be an immediate inhalation NFPA RATINGS:
problem, no first aid procedures are required.
Health 1; Flammability 0; Reactivity 0; Special NDA :
INGESTION: (Least - 0, Slight -1, Moderate - 2, High - 3, Extreme - 4).
If swallowed, give water or milk to drink and telephone for med- These values are obtained using the guidelines or published
ical advice. DO NOT make person vomit unless directed to do so
evaluations prepared by the National Fire Protection Association
by medical personnel. If medical advice cannot be obtained,
(NFPA) or the National Paint Coating Association.
then take the person and product container to the nearest med-
ical emergency treatment center or hospital.
6 . STO R AGE, HANDLING, AND REACTIVITY
3 . IMMEDIATE HEALTH EFFECTS
(also see Sections 11 and 12) HAZARDOUS DECOMPOSITION PRODUCTS:
None known.
EYE CONTAC T:
This substance is slightly irritating to the eyes and could cause STABILITY:
prolonged (days) impairment of your vision. The degree of the Stable.
injury will depend on the amount of material that gets into the
HAZARDOUS POLYMERIZATION:
eye and the speed and thoroughness of the first aid treatment.
Polymerization will not occur.
Signs and symptoms may include pain, tears, swelling, redness,
and blurred vision. I N CO M PATIBILITY:
SKIN IRRITATION: May react with strong acids or strong oxidizing agents, such as
This substance is not expected to cause prolonged or significant chlorates, nitrates, peroxides, etc. Avoid prolonged contact with
skin irritation. reactive metals such as magnesium and zinc, especially in
closed systems where hydrogen gas may accumulate over time.
DERMAL TOXICITY:
The systematic toxicity of this substance has not been deter- SPECIAL PRECAUTIONS:
mined. However, it should be practically non-toxic to internal READ AND OBSERVE ALL PRECAUTIONS ON PRODUCT LABEL.
organs if it gets on the skin.
Store away from strong oxidizing materials.
N DA 鈥? No Data Available NA 鈥? Not Applicable MSDS Number: 118
Prepared According to the OSHA Hazard Communication Standard (29 CFR 1910.1200) by Cryotech Deicing Technology, A Division of
General Atomics International Services Division, 6103 Orthoway, Fort Madison, IA 52627
MATERIAL SAFETY DATA SHEET
7. P H YS I CA L AND CHEMICAL PROPERTIES D OT HAZARD CLASS:
NOT APPLICABLE
SOLUBILITY: Completely miscible in water.
D OT IDENTIFICATION NUMBER:
APPEARANCE: Clear, colorless to light straw colored liquid.
NOT APPLICABLE
(May be dyed blue at customer request)
SA R A 3 11 CATEGORIES:
BOILING POINT: 100掳C (approximately)
1. Immediate (Acute) Health Effects: Yes
MELTING POINT: 鈥?40掳C
2. Delayed (Chronic) Health Effects: No
E VA P O R ATION: NDA
3. Fire Hazard: No
SPECIFIC GRAV I T Y: 1.28 @ 20掳C
4. Sudden Release of Pressure Hazard: No
VAPOR PRESSURE: NDA
5. Reactivity Hazard: No
PERCENT VO L ATILE (VOLUME %): NDA
REGULATO RY LISTS SEARCHED:
VAPOR DENSITY (AIR = 1): NDA
01 = SARA 313 02 = MASS RTK
V I S COSITY: 6.5 cP @ 20掳C
03 = NTP Carcinogen 04 = CA Prop. 65
05 = MI 406 06 = IARC Group 1
8 . ENVIRONMENTA L CONCERNS, SPILL
07 = IARC Group 2A 08 = IARC Group 2B
RESPONSE AND DISPOSA L 09 = SARA 302/304 10 = PA RTK
11 = NJ RTK 12 = CERCLA 302.4
EMERGENCY NUMBER (24 hr): 1- 8 00-346-7237
13 = MN RTK 14 = ACGIH TLV
SPILL/LEAK PRECAUTIONS:
15 = ACGIH STEL 16 = ACGIH Calculated TLV
This material is not expected to be toxic to aquatic organisms.
17 = OSHA TWA 18 = OSHA STEL
This material is not expected to present any environmental
20 = EPA Carcinogen 21 = TSCA Sect 4(e)
problem.
22 = TSCA Sect 5(a)(e)(f) 23 = TSCA Sect 6
DISPOSAL METHODS: 24 = TSCA Sect 12(b) 25 = TSCA Sect 8(a)
Based on information available to Cryotech Deicing Technology, 26 = TSCA Sect 8(d) 28 = Canadian WHMIS
this product is neither listed as a hazardous waste nor does it 29 = OSHA CEILING
exhibit any of the characteristics that would cause it to be classi-
None of the components of this material are found on the
fied or disposed of as a RCRA hazardous waste.
regulatory lists indicated.
If product should spill or be otherwise unsuitable for normal
11. TOX I CO LOGICAL INFORMATION
antifreeze applications, it may be disposed of in sanitary landfill
unless state or local regulations prohibit such disposal. EYE IRRITATION:
No product toxicology data available. The hazard evaluation
9 . E X P O S U R E STA N DA R D S , R E G U L AT O RY was based on data from similar products.
LIMITS A N D COMPOSITION SKIN IRRITATION:
No product toxicology data available. The hazard evaluation
The percent compositions are given to allow for the various
was based on data from similar materials.
ranges of the components present in the whole product and
DERMAL TOXICITY:
may not equal 100%.
No product toxicology data available. The hazard evaluation
PERCENT/CAS # COMPONENT/REGULATO RY LIMITS
was based on data from similar materials.
Cryotech E36庐 LRD
100%
RESPIRATO RY/INHALATION:
CONTAINING
No product toxicology data available. The hazard evaluation
50% POTASSIUM ACETATE
was based on data from similar materials.
CAS127082
INGESTION:
AND
The oral LD50 in rats is greater than 5.0 g/kg.
< 1.0% CORROSION INHIBITORS IN
50% WATER 12 . ADDITIONAL HEALTH DATA
CAS7732185
ADDITIONAL HEALTH DATA COMMENT:
TLV 鈥? Threshold Limit Value TWA 鈥? Time Weighted
This product contains potassium salts. Ingestion of large
STEL - Short-term Exposure Limit Average amounts (25 or more grams) of potassium salts usually causes
RQ - Reportable Quantity TPQ - Threshold Planning
a person to vomit. If the person is not suffering from a preexist-
CAS - Chemical Abstract Quantity ing kidney condition the absorbed potassium is rapidly excreted
Service Number CPS - CUSA Product Code
in the urine. However, very young children or individuals with
compromised kidney and/or cardiac function could experience
10. REGULATO RY INFORMATION the following effects after ingesting excessively large doses of
potassium salts: irritation and inflammation of the stomach lin-
D OT SHIPPING NAME:
ing, muscular weakness, burning, tingling and numbness sen-
NOT DESIGNATED AS A HAZARDOUS MATERIAL BY THE FED-
sations of hands and feet, slower heart beat, reduced blood
ERAL DOT
pressure, irregular heart beat and cardiac arrest.
N DA 鈥? No Data Available NA 鈥? Not Applicable MSDS Number: 118
The above information is accurate to the best of our knowledge. However, since data, safety standards, and government regulations
are subject to change and the conditions of handling and use or misuse are beyond our control, C ryotech Deicing Te chnology, a
Division of General Atomics International Services Corporation makes no warranty, either express or implied, with
respect to the completeness or continuing accuracy of the information contained herein and disclaims all liability for
reliance thereon. Cryotech Deicing Technology, a Division of General Atomics International Services Corporation assumes no
responsibility for any injury or loss resulting from the use of the product described herein. User should satisfy himself that he has all
current data relevant to his particular use.
|