MATERIAL SAFETY DATA SHEET MSDS #61-360-047
Page 1 of 9
SYNKO庐 Lite Joint
SYNKO Lite Joint 61360047v4
SECTION 1
CHEMICAL PRODUCT AND IDENTIFICATION
CGC Inc.
Product Safety: 1 (800) 507-8899
350 Burnhamthorpe Rd. W., 5th Floor
www.cgcinc.com
Mississauga, Ontario L5B 3J1
Version Date: January 1, 2008
(905) 803-5600 Fax (905) 803-5688
Version: 4
A Subsidiary of USG Corporation
PRODUCT(S) SYNKO庐 Lite Joint
CHEMICAL FAMILY /
Joint Treatment
GENERAL CATEGORY
SYNONYMS Joint Compound (Ready Mixed), Taping Compound, Mud
SECTION 2
HAZARD IDENTIFICATION
EMERGENCY OVERVIEW:
螖CAUTION!
This product is not expected to produce any unusual hazards during normal use. Exposure to high dust levels may
irritate the skin, eyes, nose, throat, or upper respiratory tract.
POTENTIAL HEALTH EFFECTS (See Section 11 for more information)
ACUTE :
Exposure to dust generated during the sanding of the product may irritate eyes, skin, nose, throat, and
upper respiratory tract. Persons subjected to large amounts of this dust will be forced to leave area
Inhalation because of nuisance conditions such as coughing, sneezing and nasal irritation. Labored breathing
may occur after excessive inhalation. If respiratory symptoms persist, consult physician.
Dust can cause mechanical irritation of eyes. If burning, redness, itching, pain or other symptoms
Eyes
persist or develop, consult physician.
Skin None known.
Ingestion None known.
CHRONIC:
Prolonged and repeated exposure to airborne free respirable crystalline silica can result in lung disease
Inhalation (i.e., silicosis) and/or lung cancer. The development of silicosis may increase the risks of additional
health effects. The risk of developing silicosis is dependent upon the exposure intensity and duration.
Eyes None known.
Skin None known.
Ingestion None known.
TARGET ORGANS: Eyes, skin and respiratory system.
PRIMARY ROUTES OF ENTRY: Inhalation, eyes and skin contact.
CARCINOGENICITY CLASSIFICATION OF INGREDIENT(S) All substances listed are associated with the nature of
the raw materials used in the manufacture of this product and are not independent components of the product
MATERIAL SAFETY DATA SHEET MSDS #61-360-047
Page 2 of 9
SYNKO庐 Lite Joint
formulation. All substances, if present, are at levels well below regulatory limits. See Section 11: Toxicology
Information for detailed information.
MATERIAL IARC NTP ACGIH CAL- 65
Vinyl Acetate Monomer 2B Not Listed A3 Not Listed
Acetaldehyde 2B 2 A3 Listed
Formaldehyde 1 2 A2 Listed
Crystalline silica 1 1 A2 Listed
IARC - International Agency for Research on Cancer: 1- Carcinogenic to humans; 2A 鈥? Probably carcinogenic to
humans; 2B 鈥? Possibly carcinogenic to humans; 3 - Not classifiable as a carcinogen; 4 鈥? Probably not a carcinogen
NTP 鈥? National Toxicology Program (Health and Human Services Dept., Public Health Service, NIH/NIEHS): 1-
Known to be carcinogen; 2- Anticipated to be carcinogens
ACGIH 鈥? American Conference of Governmental Industrial Hygienists: A1 鈥? Confirmed human carcinogen; A2 鈥?
Suspected human carcinogen; A3 鈥? Animal carcinogen; A4 - Not classifiable as a carcinogen; A5 鈥? Not suspected as
a human carcinogen
CAL-65 鈥? California Proposition 65 鈥淐hemicals known to the State of California to Cause Cancer鈥?
Respirable crystalline silica: IARC: Group 1 carcinogen, NTP: Known human carcinogen. The weight percent of
crystalline silica given represents total quartz and not the respirable fraction. The weight percent of respirable silica
has not been measured in this product.
Food and Drug Administration [CFR Title 21, v.3, sec 184.1409] 鈥? Ground limestone is Generally Recognized as Safe
(GRAS).
POTENTIAL ENVIRONMENTAL EFFECTS: This product has no known adverse effect on ecology. (See Section 12
for more information.)
SECTION 3
COMPOSITION, INFORMATION ON INGREDIENTS
MATERIAL WT% CAS #
Water >40 7732-18-5
Limestone <40 1317-65-3
Expanded Perlite <10 93763-70-3
Sepiolite <5 63800-47-3
Vinyl Acetate Polymer <5 9003-20-7
24937-78-8
Or Ethylene Vinyl Acetate Polymer
14808-60-7
Crystalline Silica <5
All ingredients of this product are included in the U.S. Environmental Protection Agency鈥檚 Toxic Substances Control
Act Chemical Substance Inventory and the Canadian Domestic Substances List (DSL).
The weight percent for silica represents total quartz and not the respirable fraction.
SECTION 4
FIRST AID MEASURES
FIRST AID PROCEDURES
Remove to fresh air. Leave the area of exposure and remain away until coughing and other symptoms
Inhalation
subside. Other measures are usually not necessary, however if conditions warrant, contact physician.
In case of contact, do not rub or scratch your eyes. To prevent mechanical irritation, flush thoroughly
Eyes
with water for 15 minutes. If irritation persists, consult physician.
MATERIAL SAFETY DATA SHEET MSDS #61-360-047
Page 3 of 9
SYNKO庐 Lite Joint
Skin Wash with mild soap and water. If irritation persists, consult physician.
Ingestion This product is not intended to be ingested or eaten. If gastric disturbance occurs, call physician.
MEDICAL CONDITIONS WHICH MAY BE AGGRAVATED: Pre-existing upper respiratory and lung diseases such
as, but not limited to, bronchitis, emphysema and asthma. Pre-existing skin diseases such as, but not limited to,
rashes and dermatitis.
NOTES TO PHYSICIAN: Treatment should be directed at the control of symptoms and the clinical condition.
SECTION 5
FIRE FIGHTING MEASURES
General Fire Hazards None known
Extinguishing Media Water or use extinguishing media appropriate for surrounding fire.
Special Fire Fighting Procedures Wear appropriate personal protective equipment. See section 8.
Unusual Fire and Explosion
None known
Hazards
Above 800潞 C 鈥? limestone may decompose to calcium oxide (CaO) and
Hazardous Combustion Products carbon dioxide (CO2). Above 175潞 C 鈥? polyvinyl acetate may decompose to
H2O, CO2, CO, and acetic acid, could produce vinyl acetate monomers.
Flash Point Auto Ignition
Not Determined Not Applicable
Method Used Not Applicable Flammability
Not Applicable
Classification
Upper Flammable Limit (UFL) Not Determined
Lower Flammable Limit (LFL) Rate of Burning
Not Determined Not Applicable
SECTION 6
ACCIDENTAL RELEASE MEASURES
CONTAINMENT: No special precautions. Wear appropriate personal protective equipment. See section 8.
CLEAN-UP: Use normal clean up procedures. No special precautions.
DISPOSAL: Follow all local, state, provincial and federal regulations. Never discharge large releases directly into
sewers or surface waters.
SECTION 7
HANDLING AND STORAGE
HANDLING: Avoid dust contact with eyes. Wear the appropriate eye protection against dust (See Section 8).
Minimize dust generation and accumulation. Avoid breathing dust. Wear the appropriate respiratory protection
against dust in poorly ventilated areas and if TLV is exceeded (see Sections 2 and 8). Use good safety and industrial
hygiene practices.
MATERIAL SAFETY DATA SHEET MSDS #61-360-047
Page 4 of 9
SYNKO庐 Lite Joint
STORAGE: Store in a cool, dry, ventilated area away from sources of heat, moisture and incompatibilities (see
Section 10). Do not use if material has spoiled, i.e., there is a moldy appearance or an unpleasant odor. Close
container and discard properly. Keep tightly sealed following use.
SECTION 8
EXPOSURE CONTROLS/PERSONAL PROTECTION
TLV (mg/m3) PEL( mg/m3)
MATERIAL WT%
Water >40 (NE) (NE)
Limestone <40 10 15(T)/5(R)
Expanded Perlite <10 10 15(T)/5(R)
Sepiolite <5 10 15(T)/5(R)
(NE) (NE)
Vinyl Acetate Polymer <5
(NE) (NE)
Or Ethylene Vinyl Acetate Polymer
0.025(R) 0.1(R)
Crystalline Silica <5
(T)鈥揟otal; (R)鈥揜espirable; (NE)-Not Established; (C)-Ceiling; (STEL)-Short-term exposure limit
(F)-Fume; (Du)-Dust; (M)-Mist
ppm-part per million; f/cc-fiber per cubic centimeter; mppcf- million particles per cubic foot
ENGINEERING CONTROLS: Provide ventilation sufficient to control airborne dust levels. If user operations generate
airborne dust, use ventilation to keep dust concentrations below permissible exposure limits. Where general
ventilation is inadequate, use process enclosures, local exhaust ventilation, or other engineering controls to control
dust levels below permissible exposure limits.
RESPIRATORY PROTECTION: Wear a NIOSH/MSHA-approved respirator equipped with particulate cartridges when
dusty in poorly ventilated areas, and if TLV is exceeded. A respiratory program that meets OSHA's 29 CFR 1910.134
and ANSI Z88.2 requirements must be followed whenever workplace conditions warrant a respirator's use. If
engineering controls are not possible, wear a properly fitted NIOSH/MSHA-approved particulate respirator.
OTHER PERSONAL PROTECTIVE EQUIPMENT:
Eye/Face Wear eye protection, safety glasses or goggles, to avoid possible eye contact.
Skin Wear gloves and protective clothing to prevent repeated or prolonged skin contact.
Selection of Personal Protective Equipment will depend on environmental working conditions and
General
operations.
SECTION 9
PHYSICAL AND CHEMICAL PROPERTIES
Appearance Vapor Density (Air = 1)
Off white to gray < 1(same as water)
Odor Specific Gravity (H2O = 1)
Low to no odor 1.3-1.7
Odor Threshold Solubility in water (g/100g)
Not Determined Unlimited dispersibility
Physical State Partition Coefficient
Paste Not Applicable
pH @ 25 潞 C Auto-ignition Temp
~ 7-8.5 Not Determined
Melting Point Decomposition Temp
Not Applicable Not Determined
MATERIAL SAFETY DATA SHEET MSDS #61-360-047
Page 5 of 9
SYNKO庐 Lite Joint
450-700 Brabender Units
Freezing Point Viscosity
32潞F/ 0潞C
at 20 潞C
99% Finer than 250
Boiling Point Particle Size
212潞F/ 100潞C
microns
Flash Point Bulk Density
Not Determined 1.3-1.7 kg/L
Evaporation Rate (BuAc = 1) Molecular Weight
Not Applicable Mixture
Upper Flammable Limit (UFL) VOC Content
Not Determined <2 g/l
Lower Flammable Limit (LFL) Percent Volatile
Not Determined 20-45
Vapor Pressure (mm Hg) ~24 mmHg@ 25潞C
SECTION 10
CHEMICAL STABILITY AND REACTIVITY
STABILITY Stable.
CONDITIONS TO AVOID Contact with incompatibles (see below).
INCOMPATIBILITY None known.
HAZARDOUS POLYMERIZATION None known.
Above 800潞 C 鈥? limestone may decompose to calcium oxide (CaO)
and carbon dioxide (CO2). Above 175潞 C 鈥? polyvinyl acetate may
HAZARDOUS DECOMPOSITION
decompose to H2O, CO2, CO, and acetic acid, could produce vinyl
acetate monomers.
SECTION 11
TOXICOLOGICAL INFORMATION
ACUTE EFFECTS: None known.
CHRONIC EFFECTS / CARCINOGENICITY:
Vinyl acetate/acetaldehyde/formaldehyde: Ethylene vinyl acetate polymer is a common emulsion polymer most
familiar as the component of ordinary white glue which exhibits the 鈥渟ticky鈥? characteristic. Ethylene vinyl acetate
polymer is not classified as a carcinogen by IARC, NTP or ACGIH. Trace amounts of residual vinyl acetate
monomers, acetaldehyde and formaldehyde may be associated with the production of ethylene vinyl acetate polymer.
Any exposure to vinyl acetate monomer, acetaldehyde, or formaldehyde is expected to remain well below OSHA
regulatory and ACGIH recommended limits during normal handling and use of this product.
Crystalline Silica: Exposures to respirable crystalline silica are not expected during the normal use of this product;
however, actual levels must be determined by workplace hygiene testing. The weight percent of respirable crystalline
silica may not have been measured in this product. Prolonged and repeated exposure to airborne free respirable
crystalline silica can result in lung disease (i.e., silicosis) and/or lung cancer. The development of silicosis may
increase the risks of additional health effects. The risk of developing silicosis is dependent upon the exposure
intensity and duration.
In June, 1997, IARC classified crystalline silica (quartz and cristobalite) as a human carcinogen. In making the overall
evaluation, the IARC Working Group noted that carcinogenicity in humans was not detected in all industrial
circumstances studied. Carcinogenicity may be dependent on inherent characteristics of the crystalline silica or on
external factors affecting its biological activity or distribution of its polymorphs.
IARC states that crystalline silica inhaled in the form of quartz or cristobalite from occupational sources is carcinogenic
MATERIAL SAFETY DATA SHEET MSDS #61-360-047
Page 6 of 9
SYNKO庐 Lite Joint
to humans (Group 1).
SECTION 12
ECOLOGICAL INFORMATION
ENVIRONMENTAL TOXICITY: This product has no known adverse effect on ecology.
Ecotoxicity value Not determined.
SECTION 13
DISPOSAL CONSIDERATIONS
WASTE DISPOSAL METHOD: Dispose of material in accordance with federal, state, and local regulations. Never
discharge directly into sewers or surface waters. Consult with environmental regulatory agencies for guidance on
acceptable disposal practices.
SECTION 14
TRANSPORT INFORMATION
U.S. DOT INFORMATION: Not a hazardous material per DOT shipping requirements. Not classified or regulated.
Shipping Name Same as product name.
Hazard Class Not classified.
UN/NA # None. Not classified.
Packing Group None.
Label (s) Required Not applicable.
GGVSec/MDG-Code Not classified.
ICAO/IATA-DGR Not applicable.
RID/ADR None.
ADNR None.
SECTION 15
REGULATORY INFORMATION
UNITED STATES REGULATIONS
All ingredients of this product are included in the U.S. Environmental Protection Agency鈥檚 Toxic Substances Control
Act Chemical Substance Inventory.
MATERIAL SAFETY DATA SHEET MSDS #61-360-047
Page 7 of 9
SYNKO庐 Lite Joint
CERCLA
Sec. 112
3 3 3
RCRA
MATERIAL WT% 0 0 1
Code
CAA
2 4 3
Water >40 NL NL NL NL NL NL
Limestone <40 NL NL NL NL NL NL
Expanded Perlite <10 NL NL NL NL NL NL
Sepiolite <5 NL NL NL NL NL NL
Vinyl Acetate Polymer <5 NL NL NL NL NL NL
NL NL NL NL NL NL
Or Ethylene Vinyl Acetate Polymer
NL NL NL NL NL NL
Crystalline Silica <5
Key : NL = Not Listed
SARA Title III Section 302 (EPCRA) Extremely Hazardous Substances: Threshold Planning Quantity (TPQ)
SARA Title III Section 304 (EPCRA) Extremely Hazardous Substances: Reportable Quantity (RQ)
SARA Title III Section 313 (EPCRA) Toxic Chemicals: X= Subject to reporting under section 313
CERCLA Hazardous Substances: Reportable Quantity (RQ)
CAA Section 112 (r) Regulated Chemicals for Accidental Release Prevention: Threshold Quantities(TQ)
RCRA Hazardous Waste: RCRA hazardous waste code
CANADIAN REGULATIONS
This product has been classified in accordance with the hazard criteria of Controlled Product regulations and the
MSDS contains all the information required by the Controlled Products Regulations. All ingredients of this product are
included in the Canadian Domestic Substances List (DSL).
WHMIS
MATERIAL WT% IDL Item #
Classification
Water >40 Not Listed Not Listed
Limestone <40 Not Listed D2A
Expanded Perlite <10 Not Listed D2A
Sepiolite <5 Not Listed Not Listed
Not Listed Not Listed
Vinyl Acetate Polymer <5
Not Listed Not Listed
Or Ethylene Vinyl Acetate Polymer
1406 D2A
Crystalline Silica <5
IDL Item#: Canadian Hazardous Products Act 鈥? Ingredient Disclosure List Item #
WHMIS Classification: Workplace Hazardous Material Information System
Risk and Safety Phrases defined by European Union Directive 67/548/EEC (Annex III and IV)
R-Phrase(s): R36/37/38
S-Phrase(s): S51 S38 S39 S2
SECTION 16
OTHER INFORMATION
MATERIAL SAFETY DATA SHEET MSDS #61-360-047
Page 8 of 9
SYNKO庐 Lite Joint
Label Information
螖 CAUTION!
Dust generated from sanding product may cause irritation to eyes, skin, nose, throat and upper respiratory tract.
Avoid irritation by reducing exposure to dust. Use wet-sanding to reduce dust created. Use in a well-ventilated area
or provide sufficient local ventilation. If dusty, wear a NIOSH/MSHA-approved respirator. Wear eye protection. If eye
contact occurs, flush thoroughly with water for 15 minutes. If irritation persists, call physician. Wash with soap and
water after use. Do not ingest. If ingested, call physician. Do not use if material has spoiled, i.e., there is a moldy
appearance or an unpleasant odor. Close container and discard properly. Product safety information: (800) 507-
8899 or www.cgcinc.com.
KEEP OUT OF REACH OF CHILDREN.
INFORMATION FOR HANDLING AND IDENTIFICATION OF CHEMICAL HAZARDS
0 = Minimal Hazard
*
HEALTH 1
0
NFPA Ratings: HIMS Ratings: 1 = Slight Hazard
0
FLAMMABILITY
1 0
Health: 1 Health: 1 2 = Moderate Hazard
0
PHYSICAL HAZARD
Fire: 0 Fire: 0 3 = Serious Hazard
E
PERSONAL PROTECTION
Reactivity: 0 Reactivity: 0 4 = Severe Hazard
E 鈥? Safety glasses, gloves and dust respirator
Key/Legend
TLV Threshold Limit Value
PEL Permissible Exposure Limit
CAS Chemical Abstracts Service (Registry Number)
NIOSH National Institute for Occupational Safety and Health
MSHA Mine Safety and Health Administration
OSHA Occupational Health and Safety Administration
ACGIH American Conference of Governmental Industrial Hygienists
IARC International Agency for Research on Cancer
DOT United States Department of Transportation
EPA United States Environmental Protection Agency
NFPA National Fire Protection Association
HMIS Hazardous Materials Identification System
PPE Personal Protection Equipment
TSCA Toxic Substances Control Act
DSL Canadian Domestic Substances List
NDSL Canadian Non-Domestic Substances List
SARA Superfund Amendments and Reauthorization Act of 1986
CAA Clean Air Act
Emergency Planning & Community Right-to-know Act
EPCRA
RCRA Resource Conservation and Recovery Act
CERCLA Comprehensive Environmental Response, Compensation and Liability Act of 1980
UN/NA# United Nations/North America number
MATERIAL SAFETY DATA SHEET MSDS #61-360-047
Page 9 of 9
SYNKO庐 Lite Joint
CFR Code of Federal Regulations
WHMIS Workplace Hazardous Material Information System
Prepared by:
Product Safety
USG Corporation
550 West Adams Street
Chicago, IL 60661-3637
The information contained in this document applies to this specific material as supplied. It may not be valid for this
material if it is used in combination with any other materials. It is the user鈥檚 responsibility to satisfy oneself as to the
suitability and completeness of this information for his/her own particular use.
END
|