MATERIAL SAFETY DATA SHEET 01570 Pg. 1
Issued: 11/19/07
1. Chemical Product and Contact Information
Product Name: Leak Detection Solution Part Number:
502-213
LECO Corporation
3000 Lakeview
St. Joseph, Michigan 49085
Information: 269-983-5531
Chemtrec: 800-424-9300
(Chemtrec Int'l: 703-527-3887)
2. Composition/Information on Ingredients
OSHA ACGIH Typical %
Component CAS No. PEL (mg/m3) TLV (mg/m3) by Weight
Demineralized Water 7732-18-5 None None > 90
This product does not contain any chemicals that meet the definition of Hazardous Chemical as defined in 29 CFR
1910.1200 or chemicals listed on the SARA Title III 313 list. This product does not contain any "controlled products" as
defined by Canada's Workplace Hazardous Materials Information System (WHMIS).
3. Hazard Identification
EMERGENCY OVERVIEW
No significant spill or fire hazard; possible irritant. Clear liquid.
Potential Health Effects
EYES: May be slightly irritating.
SKIN: May be slightly irritating.
INHALATION: None.
INGESTION: May be slightly irritating.
MEDICAL CONDITIONS AGGRAVATED: None.
CHRONIC OVEREXPOSURE: None.
ACUTE OVEREXPOSURE: None.
CARCINOGENICITY: None.
P/N: 502-213
MATERIAL SAFETY DATA SHEET 01570 Pg. 2
4. First Aid Measures
EYES: Rinse with water for 15 minutes, seek medical attention if irritation develops.
SKIN: Rinse with water. If irritation develops, seek medical attention.
INHALATION: Unlikely to be inhaled. However, if person is affected by vapors, remove to fresh
air, seek medical attention.
INGESTION: Unlikely to cause ill effects. If distress develops, seek medical attention.
5. Fire Fighting Measures
FLAMMABLE PROPERTIES: Non-combustible.
Flash Point: None. Method Used: Not applicable.
Flammable Limits (% by Volume in Air):
Lower: None. Upper: None.
AUTO-IGNITION TEMPERATURE: Not applicable.
HAZARDOUS COMBUSTION PRODUCTS: None.
EXTINGUISHING MEDIA: None.
FIREFIGHTING INSTRUCTIONS: None.
6. Accidental Release Measures
SMALL/LARGE SPILL: Treat as a water spill; soak up liquid with absorbent material or rinse
down drain.
7. Handling and Storage
HANDLING: No special requirements.
STORAGE: Store between 45掳 F and 85掳 F. (7掳 and 29掳 C.) Keep container closed.
8. Exposure Controls/Personal Protection
ENGINEERING CONTROLS: General ventilation acceptable.
RESPIRATORY PROTECTION: None required.
SKIN AND HAND PROTECTION: Suggest rubber or impervious gloves.
EYE AND FACE PROTECTION: Suggest safety glasses with side shields or goggles.
OTHER PROTECTIVE EQUIPMENT: None required.
P/N: 502-213
MATERIAL SAFETY DATA SHEET 01570 Pg. 3
9. Physical and Chemical Properties
APPEARANCE: Clear liquid.
BOILING POINT: 212掳 F. (100掳 C.)
FREEZE-MELT POINT: < 32掳 F. (< 0掳 C.)
VAPOR PRESSURE (mm): Not applicable.
VAPOR DENSITY (air = 1): Not applicable.
SOLUBILITY IN WATER: Completely soluble.
SPECIFIC GRAVITY: 1.00
pH: 7.0
ODOR: None.
PERCENT VOLATILES: Not available.
EVAPORATION RATE (Butyl Acetate = 1): Not applicable.
10. Stability and Reactivity
CHEMICAL STABILITY: Stable.
INCOMPATIBILITY: Oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS: None.
HAZARDOUS POLYMERIZATION: None.
11. Toxicological Information
None reported.
12. Ecological Information
Not available.
13. Disposal Consideration
Discarded product is not hazardous waste as defined in 40 CFR 261. Can be rinsed down the drain.
14. Transportation Information
U.S.A. DOT: Not regulated.
P/N: 502-213
MATERIAL SAFETY DATA SHEET 01570 Pg. 4
15. Regulatory Information
U.S. FEDERAL REGULATIONS:
TSCA STATUS: On Toxic Substance Control Inventory.
CERCLA REPORTABLE QUANTITY: None.
SARA TITLE III:
Section 302 Extremely Hazardous Substances: None.
Section 313 Toxic Chemicals: None.
RCRA STATUS: Not regulated
CANADIAN REGULATIONS:
WHMIS: Not Regulated.
RISK/SAFETY PHRASES:
None
16. Other Information
Hazard Index: (0 - 4, 4 = Extreme)
Health: 1 Fire: 0 Reactivity: 0
Prepared By:
Jason Whitt
Information herein is given in good faith as authoritative and valid; however, no warranty, expressed
or implied can be made.
P/N: 502-213
|