MATERIAL SAFETY DATA SHEET 02320 Pg. 1
Issued: 11/19/07
1. Chemical Product and Contact Information
Lubricant
Product Name: Part Number:
502-165
LECO Corporation
3000 Lakeview
St. Joseph, Michigan 49085
Information: 269-983-5531
Chemtrec: 800-424-9300
(Chemtrec Int'l: 703-527-3887)
2. Composition/Information on Ingredients
OSHA ACGIH Other
Component CAS No. PEL (mg/m3) TLV (mg/m3) Limits
Proprietary combination not 5 10 5 mg/m3 (NIOSH)
tested as a whole. Largely
petroleum hydrocarbons.
3. Hazard Identification
EMERGENCY OVERVIEW
Moderate fire hazard, minor spill hazard and moderate ingestion health hazard. Blue grease with slight
odor of petroleum distillate.
Potential Health Effects
EYES: Could be irritating.
SKIN: Could be irritating.
INHALATION: Can cause mild to severe pulmonary injury.
INGESTION: May be mildly toxic.
MEDICAL CONDITIONS AGGRAVATED: Under normal use medical conditions are not
generally aggravated by exposure.
CHRONIC OVEREXPOSURE: Expected to cause mild skin and eye irritation. May cause
dermatitis.
ACUTE OVEREXPOSURE: There will probably be no evidence of acute exposure. The exception
could be eye irritation.
CARCINOGENICITY: None.
P/N: 502-165
MATERIAL SAFETY DATA SHEET 02320 Pg. 2
4. First Aid Measures
EYES: Flush with water until removed.
SKIN: Wipe away excess then wash with soap and water.
INHALATION: Impossible in normal use.
INGESTION: Seek medical help to remove, rather than by vomiting, where lung entry could be
harmful.
5. Fire Fighting Measures
FLAMMABLE PROPERTIES: Non-flammable.
Flash Point: 460掳 F. (238掳 C.) Method Used: COC
Flammable Limits (% in Volume by Air):
Lower: Not available. Upper: Not available.
AUTO-IGNITION TEMPERATURE: Not available.
HAZARDOUS COMBUSTION PRODUCTS: Carbon monoxide, carbon dioxide, compounds of
nitrogen, zinc and calcium.
EXTINGUISHING MEDIA: Carbon dioxide, dry chemical, water.
FIREFIGHTING INSTRUCTIONS: Use air supplied breathing apparatus for enclosed areas.
6. Accidental Release Measures
SMALL/LARGE SPILL: Pick up with shovel or trowel. Us applicable solvents and absorbents to
effect complete clean up.
7. Handling and Storage
HANDLING: 'Empty' containers may contain residue. Do not cut, weld or expose or open flames
as they may explode.
STORAGE: Store away from heat and open flames. Do not store with oxidizing agents. Keep
container closed.
8. Exposure Controls/Personal Protection
ENGINEERING CONTROLS: If mist created, do not exceed TLV for oil.
RESPIRATORY PROTECTION: Normally none required. If high vapor or mist concentrations
expected, use respirator approved for organic vapors and gases.
SKIN AND HAND PROTECTION: Oil impervious, if needed.
EYE AND FACE PROTECTION: Safety glasses with side shields, if needed.
OTHER PROTECTIVE EQUIPMENT: Use good industrial hygienic practices.
P/N: 502-165
MATERIAL SAFETY DATA SHEET 02320 Pg. 3
9. Physical and Chemical Properties
APPEARANCE: Blue grease.
BOILING POINT: Broad range; IBP > 600掳 F. (> 316掳 C.)
FREEZE-MELT POINT: Not available.
VAPOR PRESSURE (mm): < 0.1 mm Hg @ 36掳 F. (2掳 C.)
VAPOR DENSITY (air = 1): < 10x that of Air
SOLUBILITY IN WATER: Negligible.
SPECIFIC GRAVITY: 0.91
pH: Not available.
ODOR: Slight isoproponal odor.
PERCENT VOLATILES: Trace.
EVAPORATION RATE (Butyl Acetate = 1): Not established.
10. Stability and Reactivity
CHEMICAL STABILITY (CONDITIONS TO AVOID): Stable.
INCOMPATIBILITY: Strong oxidants; concentrated oxygen and chlorine.
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon monoxide, carbon dioxide, compounds
of nitrogen, zinc and calcium.
HAZARDOUS POLYMERIZATION: None.
11. Toxicological Information
Not available.
12. Ecological Information
Not available.
13. Disposal Consideration
Dispose of in a manner to comply with the mandates of all applicable governmental agencies.
P/N: 502-165
MATERIAL SAFETY DATA SHEET 02320 Pg. 4
14. Transportation Information
U.S.A. DOT: Not regulated.
15. Regulatory Information
U.S. FEDERAL REGULATIONS:
TSCA STATUS: On Toxic Substance Control Inventory.
CERCLA REPORTABLE QUANTITY: None.
SARA TITLE III:
Section 302 Extremely Hazardous Substances: None.
Section 311/312 Hazardous Categories: Chronic, Fire.
Section 313 Toxic Chemicals: None.
RCRA STATUS: Not available.
CANADIAN REGULATIONS:
WHMIS: Not regulated
16. Other Information
Hazard Index: (0 - 4, 4 = Extreme)
Health: 1 Fire: 1 Reactivity: 0
Prepared By:
Jason Whitt
Information herein is given in good faith as authoritative and valid; however, no warranty, expressed
or implied can be made.
P/N: 502-165
|