MATERIAL SAFETY DATA SHEET 01889 Pg. 1
Revised: 1/11/99
1. Chemical Product and Contact Information (obsolete)
Refractory Alumina
Product Name: Part Numbers:
Crucible 529-036
LECO Corporation 529-042
529-043
3000 Lakeview
529-047
St. Joseph, Michigan 49085
529-048
Information: 269-983-5531
Chemtrec: 800-424-9300
LPC-909A1
(Chemtrec Int'l: 703-527-3887)
2. Composition/Information on Ingredients
OSHA ACGIH Typical %
Component CAS No. PEL (mg/m3) TLV (mg/m3) by Weight
Alumina 1344-28-1 5 10 62 - 64
Mullite 1302-93-8 Not avail. Not avail. 36 - 38
3. Hazard Identification
EMERGENCY OVERVIEW
No unusual fire or spill hazard; minor inhalation health risk. White shape.
Potential Health Effects
EYES: Irritation.
SKIN: Possible abrasion.
INHALATION: Tight chest, cough, wheeze, dypsnea.
INGESTION: Not established.
MEDICAL CONDITIONS AGGRAVATED: Persons with chronic respiratory or dermatological
disorders may be at increased risk from exposure.
CHRONIC OVEREXPOSURE: Prolonged exposure may affect lung function.
ACUTE OVEREXPOSURE: Not available.
CARCINOGENICITY: None.
P/N 529-036
MATERIAL SAFETY DATA SHEET 01889 Pg. 2
4. First Aid Measures
EYES: Flush with water.
SKIN: Wash with soap and water.
INHALATION: Relocate to fresh air environment.
INGESTION: Contact a physician.
5. Fire Fighting Measures
FLAMMABLE PROPERTIES: Non-flammable.
Flash Point: None. Method Used: Not applicable.
Flammable Limits (% by Volume in Air):
Lower: None. Upper: None.
AUTO-IGNITION TEMPERATURE: Not applicable.
HAZARDOUS COMBUSTION PRODUCTS: None.
EXTINGUISHING MEDIA: Not available.
FIREFIGHTING INSTRUCTIONS: Not available.
6. Accidental Release Measures
SMALL/LARGE SPILL: Not available.
7. Handling and Storage
HANDLING: If wet product is put into service, explosive spalling can occur.
STORAGE: Keep container closed. Do not allow product to become wet. If product becomes wet,
it must be dried thoroughly before being put into service.
8. Exposure Controls/Personal Protection
ENGINEERING CONTROLS: Provide sufficient mechanical (general and/or local exhaust)
ventilation to maintain exposure below exposure limits.
RESPIRATORY PROTECTION: NIOSH/MSHA Dust respiratory protection required if exposure
limits are exceeded.
SKIN AND HAND PROTECTION: Protective gloves recommended.
EYE AND FACE PROTECTION: Safety glasses with side shields.
OTHER PROTECTIVE EQUIPMENT: None required.
P/N: 529-036
MATERIAL SAFETY DATA SHEET 01889 Pg. 3
9. Physical and Chemical Properties
APPEARANCE: White shape.
BOILING POINT: Not available.
FREEZE-MELT POINT: 3272掳 F. (1800掳 C.)
VAPOR PRESSURE (mm): None.
VAPOR DENSITY (air = 1): Not available.
SOLUBILITY IN WATER: None.
SPECIFIC GRAVITY: 3.6 (apparent)
pH: Not applicable.
ODOR: None.
PERCENT VOLATILES: None.
EVAPORATION RATE (Butyl Acetate = 1): Not available.
10. Stability and Reactivity
CHEMICAL STABILITY: Stable.
INCOMPATIBILITY: Not available.
HAZARDOUS DECOMPOSITION PRODUCTS: None.
HAZARDOUS POLYMERIZATION: None.
11. Toxicological Information
None reported.
12. Ecological Information
Not available.
13. Disposal Consideration
Approved landfill in accordance with all federal, state and local regulations.
14. Transportation Information
U.S.A. DOT: Not regulated.
P/N: 529-036
MATERIAL SAFETY DATA SHEET 01889 Pg. 4
15. Regulatory Information
U.S. FEDERAL REGULATIONS:
TSCA STATUS: On Toxic Substance Control Inventory.
CERCLA REPORTABLE QUANTITY: None.
SARA TITLE III:
Section 302 Extremely Hazardous Substances: None.
Section 311/312 Hazardous Categories: Chronic.
Section 313 Toxic Chemicals: Aluminum Oxide
(Fibrous Forms only)
RCRA STATUS: Not regulated.
CANADIAN REGULATIONS:
WHMIS: Not regulated.
16. Other Information
Prepared By:
Duane Ostenson
Information herein is given in good faith as authoritative and valid; however, no warranty, expressed
or implied can be made.
P/N: 529-036
|