MATERIAL SAFETY DATA SHEET 02515 Pg. 1
Revised: 6/1/94
1. Chemical Product and Contact Information
Product Name: Microid Diamond Spray P/N:810-502
810-504
LECO Corporation
810-506
3000 Lakeview
810-508
St. Joseph, MI, 49085
Information: 269-983-5531
Chemtrec: 800-424-9300
(Chemtrec Int'l: 202-483-2616)
2. Composition/Information on Ingredients
OSHA ACGIH Other Typical %
Component CAS No. PEL (mg/m3) TLV (mg/m3) Limits by Weight
Dichlorodifluoro- 75-45-6 1000 ppm 1000 ppm 40 - 50
methane
Isopropanol 67-63-0 400 ppm 400 ppm 30 - 40
Ingredients not identified are non-hazardous.
3. Hazard Identification
EMERGENCY OVERVIEW
No spill hazard; moderate fire hazard; moderate inhalation health risk. Liquid with mild odor.
Potential Health Effects
EYES: Can be irritating.
SKIN: Can be irritating.
INHALATION: Lightheadedness, giddiness, shortness of breath, possible narcosis, possible cardiac
arrhythmias at high concentrations.
INGESTION: May induce mild narcosis.
MEDICAL CONDITIONS AGGRAVATED: Not available.
CHRONIC OVEREXPOSURE: Not available.
ACUTE OVEREXPOSURE: Eye overexposure can cause corneal burns and eye damage.
CARCINOGENICITY: None.
P/N: 810-502
MATERIAL SAFETY DATA SHEET 02515 Pg. 2
4. First Aid Measures
EYES: Flush eyes until irritation subsides. If irritation persists, call a physician.
SKIN: Flush with water.
INHALATION: Remove to fresh air and call a physician.
INGESTION: Induce vomiting and call a physician.
5. Fire Fighting Measures
FLAMMABLE PROPERTIES: Non-flammable.
Flash Point: None Method Used: Not applicable.
Flammable Limits (% by Volume in Air):
Lower: None. Upper: None.
AUTO-IGNITION TEMPERATURE: Not applicable.
HAZARDOUS COMBUSTION PRODUCTS: Hydrochloric and hydrofluoric acid, carbonyl
fluoride, carbon dioxide and/or carbon monoxide.
EXTINGUISHING MEDIA: Carbon dioxide, dry chemicals for small fires; alcohol type foam for
larger fires.
FIREFIGHTING INSTRUCTIONS: Use water to keep containers cool. Explosion potential:
Elevated at temperatures above 120掳 F. (248掳 C.).
6. Accidental Release Measures
SMALL/LARGE SPILL: Remove all sources of ignition. Ventilate area, especially areas where
vapor might collect.
7. Handling and Storage
HANDLING: Spray away from face. Use in well-ventilated area.
STORAGE: Keep container closed. Keep container in cool area
8. Exposure Controls/Personal Protection
ENGINEERING CONTROLS: Local preferred, mechanical (general) acceptable.
RESPIRATORY PROTECTION: Air masks in confined and highly concentrated areas.
SKIN AND HAND PROTECTION: Rubber gloves.
EYE AND FACE PROTECTION: Safety glasses with side shields.
OTHER PROTECTIVE EQUIPMENT: Eye bath and safety shower.
P/N: 810-502
MATERIAL SAFETY DATA SHEET 02515 Pg. 3
9. Physical and Chemical Properties
APPEARANCE: Liquid.
BOILING POINT: Not available.
FREEZE-MELT POINT: Not available.
VAPOR PRESSURE (mm): Not available.
VAPOR DENSITY (air = 1): Not available.
SOLUBILITY IN WATER: Soluble.
SPECIFIC GRAVITY: Not available.
pH: Not available.
ODOR: Mild.
PERCENT VOLATILES: Not available.
EVAPORATION RATE (Butyl Acetate = 1): Not available.
10. Stability and Reactivity
CHEMICAL STABILITY: Stable.
INCOMPATIBILITY: Anhydride, isocyanate, monomer and organometallic contamination. Avoid
open flames or high temperatures.
HAZARDOUS DECOMPOSITION PRODUCTS: Hydrochloric and hydrofluoric acid, carbonyl
fluoride, carbon dioxide and/or carbon monoxide.
HAZARDOUS POLYMERIZATION: None.
11. Toxicological Information
None reported.
12. Ecological Information
Not available.
13. Disposal Consideration
Do not incinerate. Dispose of aerosol product according to federal, state and local regulations.
14. Transportation Information
U.S.A. DOT: Not regulated.
P/N: 810-502
MATERIAL SAFETY DATA SHEET 02515 Pg. 4
15. Regulatory Information
U.S. FEDERAL REGULATIONS:
TSCA STATUS: On Toxic Substance Control Inventory.
CERCLA REPORTABLE QUANTITY: None.
SARA TITLE III:
Section 302 Extremely Hazardous Substances: None.
Section 311/312 Hazardous Categories: Acute, Pressure.
Section 313 Toxic Chemicals: None.
RCRA STATUS: Not regulated
16. Other Information
Prepared By:
Duane Ostenson
Information herein is given in good faith as authoritative and valid; however, no warranty, expressed
or implied can be made.
P/N: 810-502
|