MATERIAL SAFETY DATA SHEET 01825 Pg. 1
Issued: 11/19/07
1. Chemical Product and Contact Information
Cell Cleaning Solution
Product Name: Part Number:
502-341
LECO Corporation
3000 Lakeview
St. Joseph, Michigan 49085
Information: 269-983-5531
Chemtrec: 800-424-9300
(Chemtrec Int'l: 703-527-3887)
2. Composition/Information on Ingredients
OSHA ACGIH Typical %
Component CAS No. PEL (mg/m 3) TLV (mg/m3) by Weight
Anionic surfactant None Listed Not estab. Not estab. <5
Non-ionic surfactant None Listed Not estab. Not estab. <5
Polycarboxylates None Listed Not estab. Not estab. < 15
Water 7732-18-5 Not estab. Not estab. < 80
An emulsion of anionic and non-ionic surface active agents, stabilizing agents, alkalies, non-
phosphate detergent builders, and sequestering agents in an aqueous base.
3. Hazard Identification
EMERGENCY OVERVIEW
No unusual fire or spill hazard; moderate health risk. Milky liquid.
Potential Health Effects
EYES: May cause irritation.
SKIN: May cause irritation. May be harmful if absorbed through the skin.
INHALATION: May be harmful.
INGESTION: Harmful.
MEDICAL CONDITIONS AGGRAVATED: Not available.
CHRONIC OVEREXPOSURE: Not available.
ACUTE OVEREXPOSURE: Not available.
CARCINOGENICITY: None.
P/N: 502-341
MATERIAL SAFETY DATA SHEET 01825 Pg. 2
4. First Aid Measures
EYES: Immediately flush with copious amounts of water for at least 15 minutes.
SKIN: Immediately wash with soap and copious amounts of water. Wash contaminated clothing
before reuse.
INHALATION: Remove to fresh air. If not breathing, give artificial respiration. If breathing is
difficult, give oxygen.
INGESTION: Wash out mouth with water provided person is conscious. Call a physician.
5. Fire Fighting Measures
FLAMMABLE PROPERTIES: Non-flammable.
Flash Point: None. Method Used: Not applicable.
Flammable Limits (% by Volume in Air):
Lower: None. Upper: None.
AUTO-IGNITION TEMPERATURE: Not applicable.
HAZARDOUS COMBUSTION PRODUCTS: Emits toxic fumes under fire conditions.
EXTINGUISHING MEDIA: Water spray, carbon dioxide, dry chemical powder or appropriate
foam. Foam and water spray are effective but may cause frothing.
FIREFIGHTING INSTRUCTIONS: Wear self-contained breathing apparatus and protective
clothing to prevent contact with skin and eyes.
6. Accidental Release Measures
SMALL/LARGE SPILL: Evacuate the spill area. Floor may be slippery; use care to avoid falling.
Contain spills immediately with inert materials (e.g. sand, earth). Transfer liquids and solid
diking material to separate suitable containers for recovery or disposal. Keep dust to a
minimum. CAUTION: Keep spills and cleaning runoffs out of municipal sewers and open
bodies of water.
7. Handling and Storage
HANDLING: Refer to Section 8's guidelines. Avoid contact and inhalation, do not get in eyes, on
skin or on clothing. Wash thoroughly after handling.
STORAGE: Keep container closed. Store in a cool dry place.
8. Exposure Controls/Personal Protection
ENGINEERING CONTROLS: None required.
RESPIRATORY PROTECTION: NIOSH/MSHA-approved respirator.
SKIN AND HAND PROTECTION: Rubber gloves.
EYE AND FACE PROTECTION: Chemical safety goggles.
OTHER PROTECTIVE EQUIPMENT: Safety shower and eye bath.
P/N: 502-341
MATERIAL SAFETY DATA SHEET 01825 Pg. 3
9. Physical and Chemical Properties
APPEARANCE: Milky liquid.
BOILING POINT: 214掳 F.(101掳 C.)
MELT ING POINT: 25掳 F.(-4掳 C.)
VAPOR PRESSURE (mm): < 17 mm 68掳 F. (20掳 C.)
VAPOR DENSITY (air = 1): > Not available.
SOLUBILITY IN WATER: Miscible in all proportions.
SPECIFIC GRAVITY: 1.08
pH: Not available.
ODOR: None.
PERCENT VOLATILES: Not available.
EVAPORATION RATE (Butyl Acetate = 1): Not available.
10. Stability and Reactivity
CHEMICAL STABILITY: Stable.
INCOMPATIBILITY: Strong oxidizing or reducing agents.
HAZARDOUS DECOMPOSITION PRODUCTS: Toxic fumes of carbon monoxide, carbon
dioxide.
HAZARDOUS POLYMERIZATION: None.
11. Toxicological Information
None reported.
12. Ecological Information
No environmental hazard is anticipated.
13. Disposal Consideration
Observe all federal, state & local environmental regulations.
14. Transportation Information
U.S.A. DOT: Not regulated.
P/N: 502-341
MATERIAL SAFETY DATA SHEET 01825 Pg. 4
15. Regulatory Information
U.S. FEDERAL REGULATIONS:
TSCA STATUS: On Toxic Substance Control Inventory.
CERCLA REPORTABLE QUANTITY: None.
SARA TITLE III:
Section 302 Extremely Hazardous Substances: None.
Section 313 Toxic Chemicals: None.
RCRA STATUS: Not regulated.
CANADIAN REGULATIONS:
WHMIS: No information available.
16. Other Information
Prepared By:
Jason Whitt
Information herein is given in good faith as authoritative and valid; however, no warranty, expressed
or implied can be made.
P/N: 502-341
|