MATERIAL SAFETY DATA SHEET 02185 Pg. 1
Revised: 1/2/96
1. Chemical Product and Contact Information
Product Name: Lubricant, Air Cylinder P/N:773-276
LECO Corporation
3000 Lakeview
St. Joseph, MI, 49085
Information: 269-983-5531
Chemtrec: 800-424-9300
(Chemtrec Int'l: 202-483-7616)
2. Composition/Information on Ingredients
OSHA ACGIH Other Typical %
Component CAS No. PEL (mg/m3) TLV (mg/m3) Limits by Weight
Siloxanes & Silicone 63148-58-3 Not avail. Not avail. 100
3. Hazard Identification
EMERGENCY OVERVIEW
Minor spill hazard, no unusual fire hazard; eye/inhalation irritant. Liquid with some color and little
odor.
Potential Health Effects
EYES: Direct contact may cause temporary discomfort with mild redness and dryness similar to
wind burn.
SKIN: Single, prolonged exposure (24 to 48 hours) causes no known adverse effect.
INHALATION: No irritation to eyes or respiratory passages. No injury is likely from relatively short
exposures of less than 8 hours.
INGESTION: Amounts transferred to the mouth by fingers, etc., during normal operations should
not cause injury.
MEDICAL CONDITIONS AGGRAVATED: None known.
CHRONIC OVEREXPOSURE: Several repeated, prolonged exposures may cause slight skin
irritation. No known chronic hazard, but unnecessary exposure to any chemical should be
avoided.
ACUTE OVEREXPOSURE: See above.
CARCINOGENICITY: None.
4. First Aid Measures
EYES: Flush with water.
SKIN: Wipe off and flush with water.
INHALATION: Remove to fresh air.
INGESTION: No first aid should be needed.
P/N: 773-276
MATERIAL SAFETY DATA SHEET 02185 Pg. 2
Revised: 1/2/96
5. Fire Fighting Measures
FLAMMABLE PROPERTIES: Non-flammable.
Flash Point: > 214掳 F. (101掳 C.) Method Used: Open Cup
Flammable Limits (% by Volume in Air):
Lower: None. Upper: None.
AUTO-IGNITION TEMPERATURE: Not applicable.
HAZARDOUS COMBUSTION PRODUCTS: Silicon dioxide, carbon dioxide, and traces of
incompletely burned carbon products.
EXTINGUISHING MEDIA: Water fog, carbon dioxide, dry chemical, foam and other agents.
FIREFIGHTING INSTRUCTIONS: Self-contained breathing apparatus and protective clothing
should be worn in fighting fires involving chemicals.
6. Accidental Release Measures
SMALL/LARGE SPILL: Use absorbent material to collect and contain for salvage or disposal.
7. Handling and Storage
HANDLING: Section 8 precautions are for room temperature handling; use at elevated temperatures
may require additional precautions.
STORAGE: Keep container closed.
8. Exposure Controls/Personal Protection
ENGINEERING CONTROLS: General ventilation recommended.
RESPIRATORY PROTECTION: None required.
SKIN AND HAND PROTECTION: Remove contaminated clothing and shoes at the end of the
work period and clean thoroughly before reuse.
EYE AND FACE PROTECTION: Safety glasses with side shields as a minimum.
OTHER PROTECTIVE EQUIPMENT: None required.
9. Physical and Chemical Properties
APPEARANCE: Colorless liquid .
BOILING POINT: > 300掳 F. (149掳 C.) @ 760 mm Hg
FREEZE-MELT POINT: Not applicable.
VAPOR PRESSURE (mm): < 5 @ 77掳 F. (25掳 C.).
VAPOR DENSITY (air = 1): Not applicable.
SOLUBILITY IN WATER: Negligible (< 0.1%)
SPECIFIC GRAVITY: 1.1 @ 77掳 F. (25掳 C.)
pH: Not applicable.
ODOR: Very little.
PERCENT VOLATILES: < 5%
EVAPORATION RATE (Butyl Acetate = 1): < 1.0
P/N: 773-276
MATERIAL SAFETY DATA SHEET 02185 Pg. 3
Revised: 1/2/96
10. Stability and Reactivity
CHEMICAL STABILITY: Stable.
INCOMPATIBILITY: Oxidizing material can cause a reaction.
HAZARDOUS DECOMPOSITION PRODUCTS: Silicon dioxide, carbon dioxide, and traces of
incompletely burned carbon products.
HAZARDOUS POLYMERIZATION: None.
11. Toxicological Information
None reported.
12. Ecological Information
Product is an oil in the context of the U.S. Clean Water Act. Spills to U.S. surface waters, or to
watercourses or sewers leading to U.S. surface waters that cause a visible sheen must be reported
to the National Response Center.
13. Disposal Consideration
All local, state and federal regulations concerning health and pollution should be reviewed to
determine approved disposal procedures.
14. Transportation Information
U.S.A. DOT: Not regulated.
15. Regulatory Information
U.S. FEDERAL REGULATIONS:
TSCA STATUS: On Toxic Substance Control Inventory.
CERCLA REPORTABLE QUANTITY: None.
SARA TITLE III:
Section 302 Extremely Hazardous Substances: None.
Section 313 Toxic Chemicals: None.
RCRA STATUS: Not regulated
16. Other Information
Hazard Index: (0 - 4, 4 = Extreme)
Health: 0 Fire: 1 Reactivity: 0
Prepared By:
Duane Ostenson
Information herein is given in good faith as authoritative and valid; however, no warranty, expressed
or implied can be made.
P/N: 773-276
|