804
Spartan Chemical Company, Inc.
Material Safety Data Sheet
SECTION I: PRODUCT INFORMATION
Product Name or Number (as it appears on label): Product Division:
Janitorial
TNT FOAMING DISINFECTANT CLEANER
Product Number: 6343
Product/Technical1-(800)-537-8990
Spartan Chemical Company, Inc.
Information:
Medical Emergency:1-(888)-314-6171 (24 hours)
1110 Spartan Drive
Chemical Leak/SpilCHEMTREC 1-(800) 424-9300 (24 hours)
Maumee OH 43537
Emergency:
Shipping Description: ORM-D, Consumer commodity, cleaning compounds, aerosol, n.o.s.
NFPA Ratings: HMIS Ratings:
Health: 1- Slight Health: *1 - Slight; Chronic Hazard
Fire: 2 - Moderate Fire: 2 - Moderate
Reactivity: 0 - Minimal Reactivity: 0 - Minimal
Pers. Prot. Equip.: See Section VIII
SECTION II: HAZARDOUS INGREDIENTS
(Listed when present at 1% or greater, carcinogens at 0.1% or greater) All component chemicals are listed or
exempted from listing on the "TSCA Inventory" of chemical substances maintained by the U.S. Environmental
Protection Agency.
Table Z- 1 - A
CAS Registry CELING
Chemical Name(s) %W Carcinogen
No. TWA mg/m3 STEL mg/m 3 mg/m3
Not Not
Isobutane 01-05 75-28-5 1900 (NIOSH) No
Established Established
Not Not
*2-Butoxyethanol 4.5 111-76-2 120 [skin] No
Established Established
Tetrapotassium Not Not Not
01-05 7320-34-5 No
pyrophosphate Established Established Established
Alkyl dimethyl benzyl Not Not Not
< 1.0 68391-01-5 No
ammonium chloride Established Established Established
Alkyl dimethyl ethyl Not Not Not
< 1.0 68956-79-6 No
benzyl ammonium chloride Established Established Established
Comment: *This substance is subject to the reporting requirements of Section 313 of the Emergency Planning and
Community Right-To-Know Act of 1986 (SARA) and of 40 CFR 372.
Page 1 of 3
804
SECTION III: PHYSICAL DATA
Boiling Point: (Concentrate) 210 掳F Vapor Pressure: Unknown
Vapor Density (AIR = 1): Unknown Solubility in Water: Complete
pH: 10.5-11.0 Specific Gravity 1.01
(H2O=1):
Evaporation Rate <1 Percent Solid by 1-2
(but.ace.=1): Weight:
Physical State: Pressurized liquid (Aerosol
can)
Appearance & Odor: Foam spray, mint fragrance
SECTION IV: FIRE & EXPLOSIVE HAZARD DATA
Flash Point: Propellant: < 0掳F Method Used: Estimate
Flammable Limits: Not Established Flame Extension: 0 Inches
NFPA 30B Level 1 Aerosol
Extinguishing Media: Carbon dioxide, dry chemical, water fog, foam.
Special Fire Fighting Water may be used to cool closed containers to prevent pressure build-up and
Procedures: possible rupture when exposed to heat. Wear a full face positive pressure self
contained breathing apparatus when fighting fires.
Unusual Fire & Explosive Product vapor may travel along the ground or pool in low areas and be ignited by
Hazards: pilot lights, other flames, sparks, heaters, smoking, electrical motors, static
electricity or other ignition sources.
SECTION V: HEALTH HAZARD DATA
Threshold Limit Value: Not Established Primary Routes of Inhalation, Skin Contact,
Entry: Eyes and Ingestion
Effects of Overexposure- Causes moderate eye irritation. Harmful if absorbed through the skin. May be
Conditions to Avoid: harmful if swallowed. Inhalation may cause respiratory irritation.
Contains 2-butoxyethanol which may cause central nervous system depression with
symptoms such as headache; dizziness; nausea and drowsiness. Exposure to 2-
butoxyethanol may cause blood cell; liver and kidney damage based on animal data.
Avoid contact with eyes, skin or clothing. Do not swallow. Avoid breathing
product mist. Wash thoroughly with soap and water after handling.
Conditions Aggravated by Preexisting skin; eye and respiratory disorders.
Use:
Emergency & First Aid Procedures:
Eyes: Hold eye open and rinse slowly and gently with water for 15-20 minutes. Remove
contact lenses; If present after the first 5 minutes; then continue rinsing eye. Call a
poison control center or doctor for treatment advice.
Skin: Take off contaminated clothing. Rinse skin immediately with plenty of water for 15-
20 minutes. Get medical attention if irritation persists.
Ingestion: Do not induce vomiting. Drink one or two glasses of water to dilute product. Get
medical attention. Do not give anything by mouth to an unconscious person.
Inhalation: In case of respiratory irritation; move person to fresh air. Get medical attention if
irritation persists.
Page 2 of 3
804
SECTION VI: REACTIVITY DATA
Stability: Stable Incompatible Materials: Strong oxidizers
Hazardous Decomposition None Hazardous Will Not Occur
Products: Polymerization:
SECTION VII: SPILL OR LEAK PROCEDURES
Steps to be Taken in Case Flush with water to sanitary sewer. Prevent product from contaminating streams,
Material is Released or ponds, lakes or other bodies of water.
Spilled:
Waste Disposal Method: Do not puncture or incinerate aerosol containers. Dispose of in accordance with
federal, state and local regulations.
SECTION VIII: SPECIAL PROTECTION INFORMATION
Respiratory Protection: Not usually required when good ventilation is provided. However, if exposure limits
are exceeded (See Section II) or if respiratory irritation occurs, a NIOSH approved
respirator suitable for the use conditions and the chemicals listed in Section II
should be worn.
Ventilation: Provide good general ventilation. Local exhaust ventilation may be necessary for
some operations.
Protective Gloves(Specify Rubber gloves are recommended.
Type):
Eye Protection(Specify Type): Splash goggles or safety glasses are recommended.
Other Protective Equipment: See 29 CFR 1910.132-138
SECTION IX: SPECIAL PRECAUTIONS
Precautions; Handling & Contents under pressure. Do not use near fire, sparks or flame. Do not store where
Storing: temperatures could exceed 120 F. Do not puncture or incinerate container.
Other Precautions: Keep out of reach of children.
漏 SCC 03/29/2002 Name: Ronald T. Cook Title: Manager, Regulatory Affairs
TNT FOAMING DISINFECTANT Effective 03/29/2002 Supercedes: 09/24/99
CLEANER
Date:
Ref: 29 CFR 1910.1200 Changes: Update Sections I, II, III, IV, V, VII, VIII & IX
(OSHA)
This document has been prepared using data from sources considered technically reliable. It does not constitute a
warranty, express or implied, as to the accuracy of the information contained herein. Actual conditions of use and
handling are beyond sellers control. User is responsible to evaluate all available information when using product for
any particular use and to comply with all Federal, State and Local laws and regulations.
Page 3 of 3
|