#138
MATERIAL SAFETY DATA SHEET
1 Flammability = 2 Reactivity = 0
NFPA RATING: Health =
1 Flammability = 2 Reactivity = 0
HMIS RATING: Health =
SECTION I -- IDENTITY AND MANUFACTURER'S INFORMATION (464N-08E)
+
Manufacturer's Name: HILLYARD INDUSTRIES Product Name: WINDO-CLEAN+
Address: 302 North Fourth Street Date Prepared: February 6, 1996
St. Joseph, MO 64501 Prepared by: Regulatory Affairs Department
Emergency Telephone No.: (800)-424-9300 (Only in the event of chemical emergency involving a spill, leak, fire, exposure or
accident involving chemicals.) Other information calls: (816) 233-1321 (Ext. 2303)
http://www.hillyard.com
SECTION II -- INGREDIENTS/IDENTITY INFORMATION
Components
(Specific Chemical Identity: CAS# OSHA PEL ACGIH TLV OTHER LIMITS %
Common Name(s) RECOMMENDED
Butyl cellosolve (2-Butoxyethanol) * (1) 111-76-2 25 ppm 25 ppm N/A 12-17
Isopropyl alcohol (2) 67-63-0 400 ppm 400 ppm N/A 4-9
Propylene Glycol Monomethyl Ether(3) 107-98-2 100 ppm 100 ppm STEL=150 ppm 4-9
Water 7732-18-5 none none N/A ---
Sulfated Ethoxylated Alcohol 27731-61-9 none none N/A ---
*This product contains the following chemical subject to the reporting requirements of SARA Title III, Sec. 313, and 40 CFR Part
372: 2-Butoxyethanol.
(1), (2)and (3) Regulated by OSHA and the following states: CA, FL, IL, OH, TX.
VOS = 2.48 lbs./gal. for concentrate; Diluted VOS = 1.5%
SECTION III -- PHYSICAL / CHEMICAL CHARACTERISTICS
0.98 & 39潞C = 0.98
Boiling Point: Specific Gravity (H20 = 1): 25潞C =
195掳F
17.4 97.3
Vapor Pressure (mm Hg.): Percent Volatile by Volume (%):
1.5 slower than 1
Vapor Density (AIR = 1): Evaporation Rate (ethyl ether = 1):
complete clear, lavender liquid; solvent odor
Solubility in Water: Appearance and Odor:
6.4
pH (concentrate) =
SECTION IV -- FIRE AND EXPLOSION HAZARD DATA
1.1% UEL = N/A (mixture)
Flash point: Flammable Limits: LEL =
105掳F (T.C.C.) minimum
Extinguishing Media: Alcohol foam, dry chemical, carbon dioxide
Special Fire Fighting Procedures: Water spray may be ineffective, but may be used to cool closed containers.
Unusual Fire and Explosion Hazards: None known to manufacturer
SECTION V -- PHYSICAL HAZARDS
Stable Heat, sparks and open flame
Stability: Conditions to Avoid:
Incompatibility (Materials to Avoid): Strong oxidizing materials
Hazardous Decomposition Products or Byproducts: As with any organic material, combustion will produce carbon
dioxide and probably carbon monoxide.
Will not occur None known
Hazardous Polymerization: Conditions to Avoid:
SECTION VI -- HEALTH HAZARD DATA
Yes Skin? Yes Ingestion? Yes
Routes of entry: Inhalation?
HEALTH HAZARDS (1. Acute and 2. Chronic)
1. When tested according to Federal Hazardous Substance Act product was not a primary skin irritant but concentrate
produced slight skin irritation on prolonged exposure. When tested the concentrate was found to be an eye irritant. Also test
on the concentrate showed that acute oral LD50 was not acutely toxic at 8.0 g./kg. Inhalation testing showed that the LC50
nominal concentration to be 15.5 mg./l. (actual concentration 12.5 mg./l.). Prolonged breathing of high concentrations of
butyl cellosolve vapor may result in respiratory and eye irritation, narcosis, hematuria and damage to liver and kidneys. 2.
None known to Hillyard Industries.
+
page 2 of #138 - Windo-Clean+
SECTION VI -- HEALTH HAZARD DATA cont.
Chemical listed as Carcinogen or Potential Carcinogen:
No No No
National Toxicology Program = I.A.R.C. Monographs = OSHA =
This product has no carcinogens listed by IARC, NTP, NIOSH, or ACGIH as of this date, greater than or equal to 0.1%.
Signs and Symptoms of Exposure: Overexposure may cause drowsiness, headache and uncoordination.
Medical Conditions Generally Aggravated by Exposure: None known by manufacturer.
Emergency and First Aid Procedures: If swallowed, get medical attention immediately. In case of contact, immediately flush eyes
or skin with plenty of water for 15 minutes. If irritation persists, get medical attention. Inhalation - If you experience difficulty in
breathing, leave the area to obtain fresh air. If continued difficulty is experienced, get medical assistance immediately.
SECTION VII -- PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken In Case Material Is Released Or Spilled: Absorb large spills with floor dry material. Small spills: Flush with
water and pick up with mop.
Waste Disposal Method: Dispose of contaminated absorbent, container, and unused contents in accordance. with state and local
regulations. Do not dispose of in storm drains or streams.
Precautions To Be Taken In Handling And Storing: Keep away from heat, sparks and flames. Since empty packages retain
product residue, follow label warnings even after packages is empty.
Other Precautions: Keep away from heat and flame. Prevent build-up of vapors by opening all windows and doors to achieve
cross-ventilation. USE ONLY WITH ADEQUATE VENTILATION. Do not breathe vapors or spray mist. Ensure fresh air entry
during application and drying. If you experience eye watering, headache or dizziness or if air monitoring demonstrates vapor / mist
levels are above applicable limits, wear an appropriate, properly fitted respirator (NIOSH/MSHA approved) during and after
application. Follow respirator manufacturer鈥檚 directions for respirator use. Close container after each use. Avoid contact with eyes,
skin and clothing. Wash thoroughly after handling. Do not take internally. Contains Butyl Cellosolve which may cause blood
damage based on animal data.
SECTION VIII -- CONTROL MEASURES
Respiratory Protection (Specify Type): Ventilate to keep air below TLV. A NIOSH approved respirator for organic vapor should
be worn if needed to keep level below TLV.
Ventilation: Recommend at least 5 CFM
N/A Recommended N/A N/A
Local Exhaust = Mechanical (General) = Special = Other =
none required with normal use Splash goggles where splashing is a concern.
Protective Gloves: Eye Protection:
Other Protective Clothing or Equipment: Use uniforms or coveralls.
Work / Hygienic Practices: Wash thoroughly after handling
SECTION IX - TRANSPORTATION INFORMATION
Applicable regulations: no 49 CFR; yes, IMCO; yes, IATA.
Proper shipping name for air and foreign water: Flammable Liquid, N.O.S. (Isopropyl alcohol), 3.3, UN 1993, III. Proper
shipping name for U.S. highway: Cleaning Compound
UN No.: not applicable for highway Limited Qty.: not applicable Hazard Class = not applicable
Labels required: not required for highway DOT Exception: not applicable
EPA Hazardous waste characteristics:
Ignitability = yes; Corrosivity = not applicable; Reactivity = not applicable.
DISCLAIMER OF WARRANTIES
NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS
FOR A PARTICULAR PURPOSE, OR OF ANY NATURE ARE MADE WITH RESPECT TO THE PRODUCT(S) OR
INFORMATION CONTAINED IN THIS MATERIAL SAFETY DATA SHEET.
The information and recommendations contained in this Material Safety Data Sheet are supplied pursuant to 29 CFR
1910.1200 of the Occupational Safety and Health Standards Hazard Communication Rule. All information contained herein
is presented in good faith and is believed to be appropriate and accurate.
THE BUYER OR USER ASSUMES ALL RISKS ASSOCIATED WITH THE USE, MISUSE OR DISPOSAL OF THIS
PRODUCT. THE BUYER OR USER IS RESPONSIBLE TO COMPLY WITH ALL FEDERAL, STATE OR LOCAL
REGULATIONS CONCERNING THE USE, MISUSE OR DISPOSAL OF THESE PRODUCTS.
|