Page 1 of 4
Alkaline Batteries
August 2008
As a courtesy to our customers, Energizer has prepared copyrighted Product Safety Datasheets to provide information on the different
Eveready/Energizer battery systems. As defined in OSHA Hazard Communication Standard, Section 1910.1200 (c), Eveready/Energizer batteries are
manufactured 鈥渁rticles鈥?, which do not result in exposure to a hazardous chemical under normal conditions of use. For this reason, Material Safety
Datasheets are not required. The information and recommendations set forth herein are made in good faith, for information only, and are believed to be
accurate as of the date of preparation. However, ENERGIZER BATTERY MANUFACTURING, INC., MAKES NO WARRANTY, EITHER EXPRESS OR
IMPLIED, WITH RESPECT TO THIS INFORMATION AND DISCLAIMS ALL LIABILITY FROM REFERENCE ON IT.
PRODUCT SAFETY DATA SHEET
PRODUCT NAME: Eveready / Energizer Battery Type No.: Volts:
TRADE NAMES: ENERGIZER, ENERGIZER e虏, INDUSTRIAL ZMA, HERCULES,
Approximate Weight:
EVEREADY, WONDER
CHEMICAL SYSTEM: Alkaline Manganese Dioxide-Zinc Designed for Recharge: No
SECTION 1 - MANUFACTURER INFORMATION
Energizer Battery Manufacturing, Inc. Telephone Number for Information:
25225 Detroit Rd.
800-383-7323 (USA / CANADA)
Westlake, OH 44145
Date Prepared: August 2008
SECTION 2 鈥? HAZARDS IDENTIFICATION
Under normal conditions of use, the battery is hermetically sealed.
Ingestion: Swallowing a battery can be harmful. Contents of an open battery can cause serious chemical burns of mouth, esophagus, and
gastrointestinal tract.
Inhalation: Contents of an open battery can cause respiratory irritation.
Skin Contact: Contents of an open battery can cause skin irritation and/or chemical burns.
Eye Contact: Contents of an open battery can cause severe irritation and chemical burns.
SECTION 3 - INGREDIENTS
IMPORTANT NOTE: The battery should not be opened or burned. Exposure to the ingredients contained within or their combustion products could be
harmful.
MATERIAL OR INGREDIENT PEL (OSHA) TLV (ACGIH) %/wt.
15 mg/m3 TWA (total dust) 2 mg/m3 TWA (respirable
Graphite 2-6
5 mg/m3 TWA (respirable
(CAS# 7782-42-5) fraction)
fraction)
5 mg/m3 Ceiling (as Mn) 0.2 mg/m3 TWA (as Mn)
Manganese Dioxide 30-45
(CAS# 1313-13-9)
2 mg/m3 Ceiling
Potassium Hydroxide None established 4-8
(CAS# 1310-58-3)
15 mg/m3 TWA PNOR* 10 mg/m3 TWA PNOC**
Zinc 12-25
(CAS# 7440-66-6) (total dust) (inhalable particulate)
5 mg/m3 TWA PNOR* 3 mg/m3 TWA PNOC**
(respirable fraction) (respirable particulate)
Non-Hazardous Components
Steel None established None established 18-22
(iron CAS# 7439-89-6)
Water, Paper, Plastic and Other None established None established Balance
* PNOR: Particulates not otherwise regulated
**PNOC: Particulates not otherwise classified
漏2008 Energizer
Page 2 of 4
Alkaline Batteries
August 2008
SECTION 4 鈥? FIRST AID MEASURES
Ingestion: Do not induce vomiting or give food or drink. Seek medical attention immediately. CALL NATIONAL BATTERY INGESTION
HOTLINE for advice and follow-up (202-625-3333) collect day or night.
Inhalation: Provide fresh air and seek medical attention.
Skin Contact: Remove contaminated clothing and wash skin with soap and water. If a chemical burn occurs or if irritation persists, seek
medical attention.
Eye Contact: Immediately flush eyes thoroughly with water for at least 15 minutes, lifting upper and lower lids, until no evidence of the
chemical remains. Seek medical attention.
SECTION 5 - FIRE FIGHTING MEASURES
In case of fire, it is permissible to use any class of extinguishing medium on these batteries or their packing material. Cool exterior of batteries if
exposed to fire to prevent rupture.
Fire fighters should wear self-contained breathing apparatus.
SECTION 6 - ACCIDENTAL RELEASE MEASURES
To cleanup leaking batteries:
Ventilation Requirements: Room ventilation may be required in areas where there are open or leaking batteries.
Eye Protection: Wear safety glasses with side shields if handling an open or leaking battery.
Gloves: Use neoprene or natural rubber gloves if handling an open or leaking battery.
Battery materials should be collected in a leak-proof container.
SECTION 7 - HANDLING AND STORAGE
Storage: Store in a cool, well ventilated area. Elevated temperatures can result in shortened battery life.
Mechanical Containment: If potting or sealing the battery in an airtight or watertight container is required, consult your Energizer Battery
Manufacturing, Inc. representative for precautionary suggestions. Batteries normally evolve hydrogen which, when combined with oxygen
from the air, can produce a combustible or explosive mixture unless vented. If such a mixture is present, short circuits, high temperature, or
static sparks can cause an ignition.
Do not obstruct safety release vents on batteries. Encapsulation (potting) of batteries will not allow cell venting and can cause high pressure
rupture.
Handling: Accidental short circuit for a few seconds will not seriously affect the battery. Prolonged short circuit will cause the battery to lose
energy, and can cause the safety release vent to open. Sources of short circuits include jumbled batteries in bulk containers, metal jewelry,
metal covered tables or metal belts used for assembly of batteries into devices.
If soldering or welding to the battery is required, consult your Energizer Battery Manufacturing, Inc. representative for proper precautions to
prevent seal damage or short circuit.
Charging: This battery is manufactured in a charged state. It is not designed for recharging. Recharging can cause battery leakage or, in
some cases, high pressure rupture. Inadvertent charging can occur if a battery is installed backwards.
Labeling: If the Eveready / Energizer Battery label or package warnings are not visible, it is important to provide a package and/or device
label stating:
WARNING: do not install backwards, charge, put in fire, or mix with other battery types. May explode or leak causing injury.
Replace all batteries at the same time.
Where accidental ingestion of small batteries is possible, the label should include:
漏2008 Energizer
Page 3 of 4
Alkaline Batteries
August 2008
Keep away from small children. If swallowed, promptly see doctor; have doctor phone (202) 625-3333 collect.
SECTION 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION
Ventilation Requirements: Not necessary under normal conditions.
Respiratory Protection: Not necessary under normal conditions.
Eye Protection: Not necessary under normal conditions.
Gloves: Not necessary under normal conditions.
SECTION 9 鈥? PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point @ 760 mm Hg (掳C) Not applicable for an Article
Vapor Pressure (mm Hg @ 25掳C) Not applicable for an Article
Vapor Density (Air = 1) Not applicable for an Article
Density (g/cm3) 2.0 鈥? 3.0
Percent Volatile by Volume (%) Not applicable for an Article
Evaporation Rate (Butyl Acetate = 1) Not applicable for an Article
Physical State Solid
Solubility in Water (% by weight) Not applicable for an Article
pH Not applicable for an Article
Appearance and Odor Solid object / no odor
SECTION 10 鈥? STABILITY AND REACTIVITY
Alkaline batteries do not meet any of the criteria established in 40 CFR 261.2 for reactivity.
SECTION 11 鈥? TOXICOLOGICAL INFORMATION
Alkaline batteries are not hazardous waste. Under normal conditions of use, alkaline batteries are non-toxic.
SECTION 12 鈥? ECOLOGICAL INFORMATION
Issues such as ecotoxicity, persistence and bioaccumulation are not applicable for articles.
SECTION 13 鈥? DISPOSAL CONSIDERATIONS
Dispose of in accordance with all applicable federal, state and local regulations. Appropriate disposal technologies include incineration and
land filling.
漏2008 Energizer
Page 4 of 4
Alkaline Batteries
August 2008
SECTION 14 鈥? TRANSPORT INFORMATION
In general, all batteries in all forms of transportation (ground, air, or ocean) must be packaged in a safe and responsible manner. Regulatory concerns
from all agencies for safe packaging require that batteries be packaged in a manner that prevents short circuits and be contained in 鈥渟trong outer
packaging鈥? that prevents spillage of contents. All original packaging for Energizer alkaline batteries has been designed to be compliant with these
regulatory concerns.
SECTION 15 - REGULATORY INFORMATION
Batteries marketed by Energizer Battery Manufacturing, Inc. are not classified as dangerous goods by the US Department of Transportation or the major
international regulatory bodies and are therefore not regulated.
SARA/TITLE III - As an article, this battery and its contents are not subject to the requirements of the Emergency Planning and Community Right-To-
Know Act.
SECTION 16 - OTHER INFORMATION
None.
漏2008 Energizer
|