Product Name: Permatex(R) Anti-Seize Lubricant 133MA Page 1 of 6
LOCTITE CORPORATION 12/10/98
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 01 of 06
Permatex(R) Anti-Seize Lubricant 133MA
81464
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Item No.: 81464
Part No.: 133MA
Product Type: Aerosol lubricant
2. COMPOSITION, INFORMATION ON INGREDIENTS
Ingredients CAS No. %
n-HEPTANE 142-82-5 35-40
BUTANE 106-97-8 10-15
PROPANE 74-98-6 10-15
Mineral oil 64742-54-7 10-15
Trade Secret,
NJ REG. 08-0100362-5008P Proprietary 10-15
Graphite 7782-42-5 3-5
ALUMINUM 7429-90-5 0.1-3
COPPER* 7440-50-8 0.1-3
Trade Secret,
NJ REG. 08-0100362-5004P Proprietary 0.1-3
* This component is listed as a SARA Section 313 Toxic Chemical.
Ingredients which have exposure limits
Exposure Limits (TWA) ACGIH OSHA OTHER
Ingredients (TLV) (PEL)
n-HEPTANE 400 ppm TWA 500 ppm TWA None
1640 mg/M3 1600 mg/M3
BUTANE 800 ppm TWA 800 ppm TWA None
1900mg/M3 1900mg/M3
PROPANE 2500 ppm 1000 ppm None
1800 mg/m3
Mineral oil 5mg/m3 TWA mist 5mg/m3 TWA mist None
Graphite 2 mg/m3 resp 15 mppcf None
5 mg/m3 resp
ALUMINUM 10 mg/m3 dust 15 mg/m3 dust None
5 mg/m3 respir.
COPPER 1 mg/m3 dust 1 mg/m3 dust None
Exposure Limits (STEL) ACGIH OSHA
Ingredients (TLV) (PEL)
n-HEPTANE 500 ppm 500 ppm
2050 mg/M3 2000 mg/M3
LOCTITE CORPORATION 12/10/98
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 02 of 06
http://www.loctite.com/datasheets/msds/81464.html 1/1/99
Product Name: Permatex(R) Anti-Seize Lubricant 133MA Page 2 of 6
Item No.: 81464
2. COMPOSITION, INFORMATION ON INGREDIENTS (continued)
PROPANE Asphyxiant Asphyxiant
Mineral oil 10 mg/m3 mist None
3. HAZARDS IDENTIFICATION
Toxicity: Irritation of eyes, skin and respiratory system.
May cause nervous system depression. Extreme
overexposure may result in unconsciousness and
possibly death.
Reports have associated repeated and prolonged
overexposure to solvents with permanent brain and
nervous system damage.
Prolonged overexposure to solvent ingredients in
Section 2 may cause adverse effects to the liver,
urinary, cardiovascular and reproductive systems.
Primary Routes of Entry: Exposure may be by inhalation and/or skin or eye
contact, depending on conditions of use. To
minimize exposure, follow recommendations for
proper use, ventilation, and personal protective
equipment.
Signs and Symptoms
of Exposure: Headache, dizziness, nausea, and loss of
coordination are indications of excessive exposure
to vapors or spray mists. Redness and itching or
burning sensation may indicate eye or excessive
skin exposure.
Existing Conditions
Aggravated by Exposure: None known
Literature Referenced Carcinogen
Ingredients Target Organ and Other Health Effects NTP IARC OSHA
n-HEPTANE CNS IRR NO NO NO
BUTANE CAR CNS IRR NO NO NO
PROPANE CAR CNS IRR NO NO NO
Mineral oil No Data NO NO NO
Trade Secret,
NJ REG. 08-0100362-5008P No Data NO NO NO
Graphite LUN NO NO NO
ALUMINUM IRR LUN NO NO NO
COPPER BLO CNS GAS IMM IRR KID LIV MUT NO NO NO
SEN SKI
Trade Secret,
NJ REG. 08-0100362-5004P No Data NO NO NO
-------------------------------------------------------------------------------
LOCTITE CORPORATION 12/10/98
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 03 of 06
Item No.: 81464
3. HAZARDS IDENTIFICATION (continued)
Abbreviations
http://www.loctite.com/datasheets/msds/81464.html 1/1/99
Product Name: Permatex(R) Anti-Seize Lubricant 133MA Page 3 of 6
BLO Blood CAR Cardiac
CNS Central nervous system GAS Gastrointestinal
IMM Immune system IRR Irritant
KID Kidney LIV Liver
LUN Lung MUT Mutagen
SEN Sensory SKI Skin
4. FIRST AID MEASURES
Ingestion: Never give anything by mouth to an unconscious
person. Do not induce vomiting. Seek medical
attention.
Inhalation: If affected, remove from exposure. Restore
breathing. Keep warm and quiet.
Skin Contact: Wash affected area thoroughly with soap and water.
Remove contaminated clothing and launder before
reuse.
Eye Contact: Flush eyes with large amounts of water for 15
minutes. Get medical attention.
5. FIRE FIGHTING MEASURES
Flash Point: Less than 0掳F (Propellant) Method: Tag closed cup
Recommended
Extinguishing Agents: Carbon dioxide, foam, dry chemical
Special Firefighting
Procedures: Full protective equipment including self-contained
breathing apparatus should be used. Water spray
may be ineffective. If water is used, fog nozzles
are preferable. Water may be used to cool
containers to prevent pressure build-up and
possible autoignition or exposion when exposed
to extreme heat.
Hazardous Products formed
by Fire or Thermal Decomp Irritating organic vapors; oxides of carbon.
Unusual Fire or
Explosion Hazards: Isolate from heat, electrical equipment, sparks,
and open flame. Closed containers may explode when
exposed to extreme heat. Application to hot
surfaces requires special precautions. During
emergency conditions overexposure to decomposition
products may cause a helath hazard. Symptoms may
not be immediately apparent. Obtain medical
attention.
LOCTITE CORPORATION 12/10/98
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 04 of 06
Item No.: 81464
5. FIRE FIGHTING MEASURES (continued)
Explosive Limits:
(% by volume in air)Lower 1.0%
(% by volume in air)Upper 10.0%
6. ACCIDENTAL RELEASE MEASURES
Steps to be taken in case
of spill or leak: Remove all sources of ignition. Maintain good
http://www.loctite.com/datasheets/msds/81464.html 1/1/99
Product Name: Permatex(R) Anti-Seize Lubricant 133MA Page 4 of 6
ventilation. Soak up with an inert absorbent.
Store in a closed container until disposal.
7. HANDLING AND STORAGE
Safe Storage: Keep away from heat, sparks, and open flame.
(Contact Loctite Customer Service 1-800-243-4874 for shelf life information)
Handling: Keep away from heat, sparks or open flame. Vapors
will accumulate readily and may ignite explosively
Keep away from eyes. Avoid breathing of vapor and
mists.Avoid skin contact. During use and until all
vapors are gone: Keep area ventilated. Do not
smoke, Extinguish all flames, pilot lights, and
heaters. Turn off stoves, electric tools and
appliances, and other sources of ignition. Consult
NFPA Code. Use approved bonding and grounding
procedures. Do not puncture, incinerate, or expose
to temperature above 120掳F. Heat from sunlight
radiators, stoves, hot water, and other heat
sources could cause continere to burst. Do not
take internally. Keep out ot the reach of children
Intentional misuse by deliberately concentrating
and inhaling the contents can be harmful or fatal.
Wash hands after using.
8. EXPOSURE CONTROLS, PERSONAL PROTECTION
Eyes: Wear safety spectacles with unperforated
sideshields.
Skin: Chemical resistant gloves.
Ventilation: Local exhaust preferable. General exhaust
acceptable if the exposure to materials in Section
II is maintained below applicable exposure limits.
Refer to OSHA Standards 1910.94, 1910.107,
1910.108.
Respiratory If personal exposure cannot be controlled below
applicable exposure limits by ventilation, wear a
properly fitted organic/particulate respirator
approved by NIOSH/MSHA for protection against
materials in Section 2.
LOCTITE CORPORATION 12/10/98
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 05 of 06
Item No.: 81464
8. EXPOSURE CONTROLS, PERSONAL PROTECTION (continued)
See Section 2 for Exposure Limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Grey liquid
Odor: Solvent
Boiling Point: Range: Less than 0掳F to 238掳F.
pH: Does not apply
Solubility in Water: Not available
Specific Gravity 0.73 (Base only)
Volatile Organic Compound
(EPA Method 24) 64%; 461 grams per liter of material
http://www.loctite.com/datasheets/msds/81464.html 1/1/99
Product Name: Permatex(R) Anti-Seize Lubricant 133MA Page 5 of 6
Vapor Pressure: Not available
Vapor Density: More than 1 (base only)
Evaporation Rate
(Ether = 1) Faster
10. STABILITY AND REACTIVITY
Stability: Stable
Hazardous Polymerization: Will not occur
Incompatibility: Strong oxidizing agents
Conditions to Avoid: Not available
Hazardous Decomposition
Products (non-thermal): None
11. TOXICOLOGICAL INFORMATION
See Section 3.
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended methods of
disposal: Incinerate liquid obtained by spray-emptying cans
following EPA and local regulations. Do not
puncture or incinerate pressurized cans.
EPA Hazardous Waste
Number D001 - Hazardous waste per 40CFR 261.21
14. TRANSPORTATION INFORMATION
DOT (49 CFR 172)
Domestic Ground Transport
Proper Shipping Name: Consumer Commodity
LOCTITE CORPORATION 12/10/98
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 06 of 06
Item No.: 81464
14. TRANSPORTATION INFORMATION (continued)
Hazard Class or
Division: ORM-D
Identification Number: UN 1950
Marine Pollutant: None
IATA
Proper Shipping Name: Aerosols, flammable, n.o.s.
Class or Division: Division 2.1
UN or ID Number: UN 1950
15. REGULATORY INFORMATION
CA Proposition 65: WARNING: This product contains a chemical known to
the State of California to cause cancer
and birth defects or other reproductive
harm.
http://www.loctite.com/datasheets/msds/81464.html 1/1/99
Product Name: Permatex(R) Anti-Seize Lubricant 133MA Page 6 of 6
16. OTHER INFORMATION
Estimated NFPA(R) Code:
Health Hazard: 1
Fire Hazard: 4
Reactivity Hazard: 0
Specific Hazard: Does not apply
Estimated HMIS(R) Code:
Health Hazard: 2*
Flammability Hazard: 4
Reactivity Hazards: 0
Personal Protection: See Section 8.
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Prepared By: Stephen Repetto
Title: Research Chemist- Safety,Health&Regulatory Affairs
Company: Loctite Corp., 1001 Tr Br Cr, Rocky Hill CT 06067
(24hr.) Phone: (860) 571-5100
Revision Date: August 20, 1998 Revision: 0005
application assistance . browse catalog . distributor locator . datasheets . what's new
about loctite . contact loctite . literature . loctite world wide . search . home
copyright 漏 1997-1998 Loctite
http://www.loctite.com/datasheets/msds/81464.html 1/1/99
|