PIRS Page 1 of 3
MATERIAL SAFETY DATA SHEET: TRUST-X II DEP CENTER WHL
DATE OF ISSUE: 04/20/2000 SUPERCEDES: 09/12/1997
SECTION I - GENERAL INFORMATION
Chemical Name & Synonyms: Trade Name & Synonyms:
ALUMINA/ZIRCONIA RESIN GRINDING WHEEL TRUST-X II DEP CENTER WHL
Chemical Family: Formula Mixture: X
ABRASIVES
Manufacturer's Name:
DYNA SYSTEMS A PARTSMASTER CO DIV OF NCH
Address:
P.O. BOX 655326
DALLAS, TEXAS 75265-5326
Prepared By: Product Code Number Emergency Phone Number
A SANTIAGO/CHEMIST 97717000 972-438-1381
SECTION II - HAZARDOUS INGREDIENTS
THE HAZARDS PRESENTED BELOW ARE THOSE OF THE INDIVIDUAL COMPONENTS
Chemical Name (Ingredients) Hazard TLV PEL STEL CAS #
ZIRCONIUM DIOXIDE NOT DETERM 5 MG/M3 5 MG/M3 N/A 1314-23-4
CURED PHENOL FORMALDEHYDE RESIN NOT DETERM NO DATA NO DATA N/A 903-35-4
ALUMINUM OXIDE, NON FIBROUS IRRITANT 10 MG/M3 15 GM/M3 NA 1344-28-1
FIBERGLASS IRRITANT 5 MG/M3 5 MG/M3 N/A 65997-17-3
CALCIUM OXIDE IRRITANT 2 MG/M3 5 MG/M3 N/A 1305-78-8
IRON DISULFIDE POISON-INH 10 MG/M3 10 MG/M3 N/A 12068-85-8
SECTION III - PHYSICAL DATA
N/A 2-4
Boiling Point (f): Specific Gravity (H20=1):
N/A GREY
Vapor Pressure (MM HG): Color:
N/A NONE
Vapor Density (Air=1): Odor:
N/A OPAQUE
PH @ 100% : Clarity
0% N/A
% Volatile by Volume: Evaporation Rate (BU A/C=1):
SLIGHT SOLID
H20 Solubility: Viscosity:
SECTION IV - FIRE AND EXPLOSION HAZARD
Flash Point: Flammable Limits: LEL: UEL:
N/A / N/A
Extinguishing Media:
Foam: Alcohol Foam: CO2: Dry Chemical: Water Spray: X Other:
Special Fire Fighting Procedures:
NOT APPLICABLE
Unusual Fire and Explosion Hazards:
NONE
NFPA Hazard Rating: (0=Insignificant 1=Slight 2=Moderate 3=High 4=Extreme)
Health: 1 Flamability: 0 Reactivity: 0 Special: 0
SECTION V - HEALTH HAZARD DATA
Threshold Limit Value:
NOT ESTABLISHED FOR MIXTURE. SEE SECTION II.
Effects of Overexposure:
-Acute(Short Term Exposure)
http://pirs.nch.com/MSDSPrintPage.asp 2/15/2001
PIRS Page 2 of 3
COUGHING AND SHORTNESS OF BREATH MAY OCCUR DUE TO INHALATION OF DUST. SOME MAY
EXPERIENCE SKIN IRRITATION DUE TO DUST. DUST MAY IRRITATE EYES AND RESPIRATORY TRACT AT HIGH
CONCENTRATIONS.
-Chronic (Long Term Exposure)
INHALATION OF DUST MAY AFFECT BREATHING CAPACITY. GRINDING MAY CREATE ELEVATED SOUND
LEVELS WHICH MAY AFFECT HEARING. DUST GENERATED FROM INTEN- DED USE MAY CONTAIN TRACE
AMOUNTS OF PHENOL AND FORMALDEHYDE WHICH UNDER EXCESSIVE EXPOSURE MAY CAUSE SKIN
SENSITIZATION AND AIRWAY OBSTRUCTION.
Inhalation: X Ingestion: Absorption:
Primary Routes of Entry:
Emergency and First Aid Procedures:
-Inhalation:
REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION AS NEEDED. OBTAIN MEDICAL ASSISTANCE.
-Eye Contact:
WASH WITH LARGE AMOUNTS OF WATER. OBTAIN FIRST AID AND MEDICAL ASSISTANCE IF NEEDED.
-Skin Contact:
WASH AFFECTED AREA WITH SOAP AND WATER. OBTAIN MEDICAL ASSISTANCE, IF NEDEED.
-Ingestion:
CALL POISON CONTROL CENTER, HOSPITAL EMERGENCY ROOM OR PHYSICIAN IMMEDIATELY.
-Notes to Physician:
NONE
SECTION VI - TOXICITY INFORMATION
Product Contains Chemicals Listed as Carcinogen or Potential Carcinogen By:
IARC: No NTP: No OSHA: No ACGIH: No OTHER: No
CARCINOGENICITY:
FOR WHEELS CONTAINING FIBERGLASS, THE DIAMETER OF THE FIBERS ARE GREATER
THAN 10UM, THEREFORE CONSIDERED NON-RESPIRABLE. FIBERGLASS- IARC-3,NOT A
HUMAN CARCINOGEN.
ALL CHEMICALS IN THIS PRODUCT ARE LISTED, OR ARE EXEMT FROM LISTING, ON THE
TSCA INVENTORY.
SECTION VII - REACTIVITY DATA
Stable: X Unstable:
Stability:
Contitions to Avoid: N/A
Incompatibility (Materials to Avoid):
AVOID ACIDS OF ALL TYPES WITH PH < 4.0
Hazardous Decomposition Products:
THERMAL DECOMPOSITION MAY PRODUCE TRACE AMOUNTS OF PHENOL AND FORMALDEHYDE.
May Occur: Will Not Occur: X
Hazardous Polymerization:
Contitions to Avoid:
SECTION VIII - SPILL OR LEAK PROCEDURES
Steps to be Taken if Material is Released or Spilled:
USE NORMAL CLEANUP PROCEDURES.
Waste Disposal Method(s):
SANITARY LANDFILL METHODS CONSISTENT WITH FEDERAL, STATE AND LOCAL REGULA- TIONS.
Neutralizing Agent:
N/A
SECTION IX - SPECIAL PROTECTION INFORMATION
http://pirs.nch.com/MSDSPrintPage.asp 2/15/2001
PIRS Page 3 of 3
Required Ventilation:
LOCAL AND MECHANICAL VENTILATION ARE RECOMMENDED.
Respiratory Protection:
USE NIOSH-APPROVED RESPIRATOR IF DUST EXPOSURE EXCEEDS TLV.
Glove Protection:
AS DESIRED
Eye Protection:
SAFETY GLASSES OR GOGGLES
Other Protection:
HEARING PROTECTION IS RECOMMENDED. SEE OSHA 29 CFR 1910.134 AND OTHER APPLICABLE
REGULATIONS.
SECTION X - STORAGE AND HANDLING INFORMATION
Indoors: Outdoors: Heated: Refrigerated:
Storage Temperature:
Minimum Temperature: N/A Maximum Temperature: N/A
Precautions to be taken in Handling and Storing:
SEE ANSI STANDARD B7.1
Other Precautions:
HANDLE ONLY WITH ADEQUATE VENTILATION
SECTION XI - REGULATORY INFORMATION
Chemical Name CAS Number Upper % Limit
Those Ingredients listed above are subject to the reporting requirements of 313 of Title III & of the Superfund
Amendments and Reauthorization Act of 1986 and 40 CFR part 372.
CALIFORNIA PROPOSITION 65
WARNING: This product contains the following chemical(s) know to the State of California to cause (1)Cancer or (2)Birth
Defects or other reproductive harm. THIS PRODUCT CONTAINS NONE
SECTION XII - REFERENCES
1. SAX'S DANGEROUS PROPERTIES OF INDUSTRIAL MATERIALS, TENTH EDITION,,
RICHARD J. LEWIS, SR.
2. TITLE III SECTION 313 OF THE SUPERFUND AMEMENDMENT AND REAUTHORIZATION
ACT, SARA, APRIL, 2000.
3. REGISTRY OF TOXIC EFFECTS OF CHEMICAL SUBSTANCES, CCINFO DISC, 2000.
4. TOXIC SUBSTANCE CONTROL ACT, TSCA, APRIL, 2000.
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE IN LIGHT OF CURRENT
FORMULATION. HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF
THESE DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF.
DYNA SYSTEMS A PARTSMASTER CO DIV OF NCH assumes no responsibility for personal injury or property damage
caused by the use, storage, or disposal of the product in a manner not recommended on the product label. Users
assume all risks associated with such unrecommended use,storage or disposal of the product."
http://pirs.nch.com/MSDSPrintPage.asp 2/15/2001
|