DATE OF ISSUE: 11/07/1997 SUPERCEDES: 04/18/1991
SECTION I - GENERAL INFORMATION
Chemical Name & Synonyms: Trade Name & Synonyms:
BONDED ABRASIVE BENCH GRINDING WHEEL
Chemical Family: Formula Mixture: X
ALUMINUM OXIDE
Manufacturer's Name:
DYNA SYSTEMS A PARTSMASTER CO DIV OF NCH
Address:
P.O. BOX 655326
DALLAS, TEXAS 75265-5326
Prepared By: Product Code Number Emergency Phone Number
B ABBOTT/CHEMIST 87563336 972-438-1381
SECTION II - HAZARDOUS INGREDIENTS
THE HAZARDS PRESENTED BELOW ARE THOSE OF THE INDIVIDUAL COMPONENTS
Chemical Name (Ingredients) Hazard TLV PEL STEL CAS #
ALUMINUM OXIDE IRRITANT 10MG/M3 1. 15MG/M3 2. 1344-38-1
SECTION III - PHYSICAL DATA")%>
Boiling Point (f): N/A Specific Gravity (H20=1): 2-4
Vapor Pressure (MM HG): N/A Color: GREY
Vapor Density (Air=1): N/A Odor: NONE
PH @ 100% : N/A Clarity OPAQUE
% Volatile by Volume: 0% Evaporation Rate (BU A/C=1): N/A
H20 Solubility: SLIGHT Viscosity: SOLID
SECTION IV - FIRE AND EXPLOSION HAZARD
Flash Point: Flammable Limits: LEL: UEL:
N/A / N/A
Extinguishing Media:
Foam: Alcohol Foam: CO2: Dry Chemical: Water Spray:X Other:
Special Fire Fighting Procedures:
NONE
Unusual Fire and Explosion Hazards:
NONE
NFPA Hazard Rating: (0=Insignificant 1=Slight 2=Moderate 3=High 4=Extreme)
Health:1 Flammability:0 Instability:0 Special:0
SECTION V - HEALTH HAZARD DATA
Threshold Limit Value:
NOT ESTABLISHED FOR MIXTURE
Effects of Overexposure:
http://pirs.nch.com/MSDSPrintPage.asp 11/13/2001
PIRS Page 2 of 3
-Acute(Short Term Exposure)
COUGHING AND SHORTNESS OF BREATH MAY OCCUR DUE TO INHALATION OF DUST. SOME MAY EXPERIENCE
SKIN IRRITATION DUE TO DUST. DUST MAY IRRITATE EYES.
-Chronic (Long Term Exposure)
INHALATION OF DUST MAY AFFEST BREATHING CAPACITY. GRINDING MAY CREATE ELEVATED SOUND
LEVELSWHICH MAY AFFECT HEARING, AND MAY AGGRAVATE PRE- EXISTING RESPIRATORY CONDITIONS.
Primary Routes of Entry: Inhalation:X Ingestion: Absorption:
Emergency and First Aid Procedures:
-Inhalation:
REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION AS NEEDED. OBTAIN MEDICAL ASSISTANCE.
-Eye Contact:
WASH WITH LARGE AMOUNTS OF WATER. OBTAIN FIRST AID AND MEDICAL ASSISTANCE IF NEEDED.
-Skin Contact:
WASH AFFECTED AREA WITH SOAP AND WATER. OBTAIN MEDICAL ASSISTANCE.
-Ingestion:
OBTAIN MEDICAL ASSISTANCE.
-Notes to Physician:
SECTION VI - TOXICITY INFORMATION
Product Contains Chemicals Listed as Carcinogen or Potential Carcinogen By:
IARC: No NTP: No OSHA: No ACGIH: No OTHER: No
SECTION VII - REACTIVITY DATA
Stability: Stable:X Unstable:
Conditions to Avoid: N/A
Incompatibility (Materials to Avoid):
AVOID CONTACT WITH ACIDS WITH PH UNDER 4.0
Hazardous Decomposition Products:
Hazardous Polymerization: May Occur: Will Not Occur:X
Conditions to Avoid:
SECTION VIII - SPILL OR LEAK PROCEDURES
Steps to be Taken if Material is Released or Spilled:
USE NORMAL CLEANUP PROCEDURES.
Waste Disposal Method(s):
SANITARY LANDFILL METHODS CONSISTENT WITH FEDERAL, STATE AND LOCAL REGULA- TIONS.
Neutralizing Agent:
N/A
SECTION IX - SPECIAL PROTECTION INFORMATION
http://pirs.nch.com/MSDSPrintPage.asp 11/13/2001
PIRS Page 3 of 3
Required Ventilation:
LOCAL AND MECHANICAL VENTILATION ARE RECOMMENDED.
Respiratory Protection:
USE NIOSH-APPROVED RESPIRATOR IF DUST EXPOSURE EXCEEDS TLV.
Glove Protection:
AS DESIRED
Eye Protection:
SAFETY GLASSES OR GOGGLES
Other Protection:
HEARING PROTECTION IS RECOMMENDED.
SECTION X - STORAGE AND HANDLING INFORMATION
Storage Temperature: Indoors: Outdoors: Heated: Refrigerated:
Minimum Temperature:N/A Maximum Temperature:N/A
Precautions to be taken in Handling and Storing:
SEE ANSI STANDARD B7.1
Other Precautions:
HANDLE ONLY WITH ADEQUATE VENTILATION
SECTION XI - REGULATORY INFORMATION
Chemical Name CAS Number Upper % Limit
ALUMINUM OXIDE 1344-28-1 96
Those Ingredients listed above are subject to the reporting requirements of 313 of Title III& of the Superfund
Amendments and Reauthorization Act of 1986 and 40 CFR part 372.
CALIFORNIA PROPOSITION 65
WARNING: This product contains the following chemical(s) know to the State of Californiato cause (1)Cancer or (2)
Birth Defects or other reproductive harm. THIS PRODUCTCONTAINS NONE.
SECTION XII - REFERENCES
1. "THRESHOLD LIMIT VALUES AND BIOLOGICAL EXPOSURE LIMITS FOR 1989-1990",
- AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS.
2. "AIR CONTAMINANTS - PERMISSIBLE LIMITS" CFR 29 (1910.1000), U.S.DEPART-
MENT OF LABOR, OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION.
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE IN LIGHT OF CURRENT
FORMULATION.HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THESE
DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF.
DYNA SYSTEMS A PARTSMASTER CO DIV OF NCHassumes no responsibility for personal injury or property damage
caused by the use, storage, or disposal of the product in a manner not recommended on the product label. Users
assume all risks associated with such unrecommended use,storage or disposal of the product."
http://pirs.nch.com/MSDSPrintPage.asp 11/13/2001
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP