Supplier:
Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106
Telephone: 1-87-Permatex
(877) 376-2839
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 77BR ULTRA BLUE RTV 3.35OZ TB CG
Item No: 81724
Product Type: Elastomeric rubber
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredients Percent ACGIH 8 Hr. TWA: OSHA 8 Hr. TWA:
CALCIUM CARBONATE 40-50 10 mg/m3 dust 15 mg/m3 dust; 5 mg/m3 respir
471-34-1
POLY (DIMETHYLSILOXANE), 30-40
HYDROXY TERMINATED
70131-67-8
POLYBUTYLENE RESIN 10-20
9003-29-6
VINYL OXIMINOSILANE 1-10
2224-33-1
METHYL OXIMINOSILANE 1-10
22984-54-9
2-BUTANONE OXIME ****
96-29-7
3. HAZARDS IDENTIFICATION
May cause eye and skin irritation. ****When this product if exposed to moisture, up to 5% butanone
Toxicity:
oxime may be formed. When heated to temperatures above 300 degrees F. in the presence of air,
this product can form formaldehyde vapors. Formaldehyde is a potential cancer hazard and a known
skin and respiratory sensitizer. Safe handling conditions may be maintained by keeping vapor
concentrations below the OSHA permissible limit for formaldehyde. May be harmful if swallowed.
May irritate lips, gums, tongue, mouth, nose and throat.
Eye and skin contact, ingestion, inhalation.
Primary Routes of Entry:
Butanone oxime produced during curing is toxic and irritates eyes, nose and throat. Overexposure to
Signs and Symptoms of Exposure:
the silane may cause coma and respiratory failure.
Medical Conditions Recognized as Being None known
Aggravated by Exposure:
4. FIRST AID MEASURES
Rinse mouth with water several times. If swallowed, DO NOT induce vomiting. Keep individual calm.
Ingestion:
Obtain medical attention.
If inhaled, remove from area to fresh air. Get medical attention if respiratory irritation develops or if
Inhalation:
breathing becomes difficult.
Wipe off paste with paper towel or cloth. Wash exposed area with soap and water. Seek medical
Skin Contact:
attention if irritation persists.
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get
Eye Contact:
medical attention if irritation persists.
5. FIRE FIGHTING MEASURES
More than 200 degrees F. Method: Tag Closed Cup
Flash Point (掳F/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Water spray may be ineffective on flames but should be used to keep fire-exposed containers cool.
Special Fire-Fighting Procedures:
Oxides of nitrogen, Methyl ethyl ketone, possibly methyl ethyl ketoxime. Silica fume, Oxides of
Hazardous Products Formed by Fire or
carbon. Formaldehyde,
Thermal Decomposition:
Page 1 of 3
Product Name: 77BR ULTRA BLUE RTV 3.35OZ TB CG
Item No: 81724
None
Unusual Fire/Explosion Hazards:
Not determined
Lower Explosive Limit:
Not determined
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Wipe or scrape up spill material. Maintain good ventilation for large spills. Place scrap material in a
Spill Procedures:
well-ventilated area and allow to cure to rubber. Clean up spills thoroughly as residue is slippery.
7. HANDLING AND STORAGE
Store in a dry area below 90 degrees F. Keep container closed when not in use.
Storage:
Avoid contact with skin and eyes. Do not inhale vapors.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses or goggles. Avoid contact lenses.
Eyes:
Rubber or plastic gloves
Skin:
General ventilation is usually adequate.
Ventilation:
Not normally necessary. An approved respirator (i.e. NIOSH, etc.) should be worn when exposures
Respiratory Protection:
are expected to exceed the applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Blue paste
Appearance:
MILD
Odor:
Not applicable, polymeric material
Boiling Point (掳F):
Does not apply
pH:
Polymerized
Solubility in Water:
1.34
Specific Gravity:
5.5% by weight; 73.7 g/l
VOC Content(Wt.%):
Less than 5 mm Hg @ 80 degrees F.
Vapor Pressure:
3.0
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR
Hazardous Polymerization:
Polymerized by contact with moisture. Strong oxidizers. Acids, Iron.
Incompatabilities:
Moisture while storing.
Conditions to Avoid:
Oxides of nitrogen, Methyl ethyl ketone, possibly methyl ethyl ketoxime. Silica fume, Oxides of
Hazardous Products Formed by Fire or
carbon. Formaldehyde,
Thermal Decomposition:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Disposal should be made in accordance with federal, state and local regulations.
Recommended Method of Disposal:
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORT INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
DOT Shipping Name: Unrestricted
Hazard Class: NONE
UN/ID Number: None
Marine Pollutant: None
Page 2 of 3
Product Name: 77BR ULTRA BLUE RTV 3.35OZ TB CG
Item No: 81724
IATA
Proper Shipping Name: Unrestricted
Class or Division: None
UN/NA Number: NONE
IMDG
Proper Shipping: Unrestricted
Hazard Class: None
UN Number: None
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical
NONE
CALIFORNIA PROP 65:
WARNING: This product contains a chemical known to the State of California to cause birth defects or other reproductive harm.
TSCA Inventory Status:
All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 1, FLAMMABILITY 1 , REACTIVITY 0
Estimated NFPA Rating:
FLAMMABILITY 1 , REACTIVITY 0 , HEALTH 1
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Prepared By: Denise Boyd Health and Safety Manager
Company: Permatex. Inc. 10 Columbus Blvd. Hartford, CT 06106
Telephone Number: 1-87-Permatex (877) 376-2839
03/01/2001
Revision Date:
Page 3 of 3
|