Manufacturer Information
Company Name: Warco Products, Inc.
Address: 12505 Herman Rd. Tualatin, OR 97062 USA
Phone: 503.692.3800
Fax: 503.612.1700
Email: info@warcopro.com
24 Hour Emergency Contact: Chemtrec 800-424-9300
PRODUCT INFORMATION
EDP Number: 003070AW
Product Name: Warco Long Life Coolant
DOT Hazard: Non-Hazardous
DOT Ship Name: Anti-freeze Compounds N.O.I.
PHYSICAL DATA
Boiling Pt: N/A
Freeze Point: N/A
Gravity: 1.023@68 DEG F
Vapor Pressure: N/A
Vapor Density: N/A
Evaporation Rate: N/A
% Volatile: <25
Solubility: 100
Odor and Appearance: Clean, Dark Green Liquid
INGREDIENTS
Material Name: Ethylene Glycol
Percentage: <25
TLV: 50PPM
Hazard: Toxic
CAS Number: 107-21-1
NOTE: This chemical is subject to the reporting requirements of SARA TITLE III SECTION 313.
FIRE AND EXPLOSION HAZARD DATA
Flash Point: N/A
LEL: N/A
UEL: N/A
Extinguishing Media: Under normal conditions this product will not support combustion.
Unusual Fire & Explosion Hazard: None
HEALTH HAZARD DATA
Acute Effects: N/A
Swallowing: May cause abdominal discomfort & pain, dizziness, fatigue, vomiting, uremia, and central nervous
system depression.
Inhalation: May cause irritation in throat, headaches, vomiting, nausea, dizziness.
Skin Contact: None currently known.
Eye Contact: Liquid vapors and mists may produce signs of central nervous system effects, particularly dizziness.
Other Hazards: Swallowing may cause severe kidney damage.
MATERIAL SAFETY DATA SHEET
COOLANT
EMERGENCY FIRST AID PROCEDURES
Swallowing: If person is conscious give two glasses of water or milk and induce vomiting. Contact physician
immediately.
Inhalation: Remove to fresh air. Call a physician if discomfort persists.
Skin Contact: Flush skin with water and remove contaminated clothing, launder before re-use.
Eye Contact: Flush with water immediately for a minimum of 15 minutes lifting upper and lower lids occasionally.
Get medical attention.
Primary: Ingestions
Note to Physician: The principal toxic effect of this material when swallowed will be due to the ethylene glycol
content, which causes kidney damage. Early administration of ethanol may blokc the formation of nephrotoxic
metabolites of ethylene glycol in the liver. Ethanol should be given intraveneously, as a 5% solution in sodium
bicarbonate at a rate of 10 ML ethanol per hour. Hemodialysis may be required.
REACTIVITY DATA
Stability: Stable
Conditions to Avoid: None
Materials to Avoid: None
Hazardous Decom Prod: Carbon Monoxide/Carbon Dioxide
Hazardous Polymerization: Will not occure
Additional Cond to Avoid: None
SPILL OR LEAK PROCEDURES
Steps if Spilled: Wear suitable protective equipment. Small spills should be flushed with large quantities of water.
Larger spills should be collected for disposal. Incinerate in a furnace where permitted under appropriate regulations.
Waste Disposal Method: Above in accordance with local, state and federal regulations.
SPECIAL PROTECTION INFORMATION
Respiratory Protection: N/A
Ventilation: Local exhaust
Impervious Gloves: N/A
Other PPE: N/A
SPECIAL PRECAUTIONS
Storage & Handling Precautions: May be fatal if swallowed. Do not breathe mist. Avoid prolonged or repeated
breathing of vapors. Avoid contact with eyes. Wash thoroughly after handling.
Other Precautions: Where heavy concentration of a fine mist is present, a respirator should be used to prevent
inhaling mist particles.
HMIS RATINGS
Health: 2
Flammability: 0
Reactivity: 0
Personal Protective Equipment: B
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE. HOWEVER, NO
WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS TO BE
OBTAINED FROM THE USE THEREOF. VENDOR ASSUMES NO RESPONSIBILITY FOR INJURY TO VENDEE OR
THIRD PERSONS PROXIMATELY CAUSED BY THE MATERIALS IF REASONABLE SAFETY PROCEDURES ARE
NOT ADHERED TO AS STIPULATED IN THE DATA SHEET. ADDITIONALLY, VENDOR ASSUMES NO
RESPONSIBILITY FOR INJURY TO VENDEE OR THIRD PERSONS PROXIMATELY CAUSED BY ABNORMAL USE
OF THE MATERIAL, EVEN IF REASONABLE SAFETY PROCEDURES ARE FOLLOWED. FURTHERMORE, VENDEE
ASSUMES THE RISK IN HIS USE OF THE MATERIAL
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP