Tel: 514-956-7503
Fax: 514-956-7504
Internet: www.megs.ca
Email : support@megs.ca
Montreal St-Laurent Tel : 514-956-7503 Fax : 514-956-7504
Ottawa Nepean Tel : 613-226-4228 Fax : 613-226-4229
Quebec Quebec Tel : 418-834-7447 Fax : 418-834-3774
MSDS: Nitrous Oxide
PRODUCT INFORMATION
PRODUCT: Nitrous Oxide
TRADE NAME: Nitrous Oxide or Nitrous Oxide,
Compressed
CHEMICAL NAME: Nitrous Oxide or Dinitrogen Monoxide
SYNONYMS: Laughing Gas
FORMULA: N2O
CHEMICAL FAMILY: Oxide of Nitrogen
SUPPLIER'S NAME: MEGS Inc.
SUPPLIER'S ADDRESS: 2675 De Miniac
Ville St-Laurent, Qc, H4S 1E5
EMERGENCY PHONE NUMBER: (514) 956-7503
MOLECULAR WEIGHT: 44.01
PRODUCT USE: Various
PRODUCT IDENTIFICATION UN 1070
NUMBER:
HAZARDOUS INGREDIENTS
CHEMICAL ID CONCENTRATION CAS # LD(50) LC(50)
100%
Nitrous Oxide 10024-97-2 None Inhalation-Rat
1068 mg/m鲁/ 4 h
PHYSICAL DATA
PHYSICAL STATE: Liquid and gas under pressure
APPEARANCE: Colorless liquid and gas with slightly
sweet taste and odor
ODOR: See above
ODOR THRESHOLD: Unknown
SPECIFIC GRAVITY (H 2O = 1): @ Boiling Point: 1.22
VAPOR PRESSURE: 4653 kPa @ 15掳C
VAPOR DENSITY (air = 1): 1.53
EVAPORATION RATE: Not applicable
BOILING POINT: -88.47掳C
FREEZING POINT: -90.81掳C
pH: Not applicable
GAS DENSITY: 1.861 kg/m鲁 @ 15掳C, 101.3 kPa
COEFFICIENT OF WATER/OIL @ 15掳C, Bunsen Coefficient = 0.789
DISTRIBUTION:
FIRE OR EXPLOSION HAZARD
CONDITIONS OF FLAMMABILITY: Nonflammable gas
MEANS OF EXTINCTION: For fires with nitrous oxide as the
oxidizer - copious quantities of water.
FLASHPOINT AND METHOD OF Nonflammable gas
DETERMINATION:
UPPER EXPLOSION LIMIT (% BY VOL): Nonflammable gas
LOWER EXPLOSION LIMIT (% BY VOL): Nonflammable gas
AUTO-IGNITION TEMPERATURE: Nonflammable gas
FLAMMABILITY CLASSIFICATION: Nonflammable gas
HAZARDOUS COMBUSTION Nonflammable gas
PRODUCTS:
EXPLOSION DATA: Nonflammable gas
SENSITIVITY TO STATIC DISCHARGE: None
REACTIVITY DATA
CHEMICAL STABILITY: Stable at low and normal
temperatures. Decomposes to O2
and N2 at elevated temperatures.
INCOMPATIBLE MATERIALS: All flammable materials
CONDITIONS OF REACTIVITY: High temperature
HAZARDOUS DECOMPOSITION None
PRODUCTS:
TOXICOLOGICAL PROPERTIES
ROUTES OF ENTRY:
SKIN CONTACT: None
SKIN ABSORPTION: None
EYE: None
INHALATION: Effects of exposure to concentrations sufficient to displace the
oxygen in the air necessary for life are: headaches, dizziness, labored breathing
and eventual unconsciousness, and death.
It is employed as an anesthetic when mixed with oxygen. These mixtures are
generally 80 molar % N2O and 20 molar % O2. The laughter effects seem to
occur after incipient asphyxia is accompanied by the sudden return of adequate
oxygen as in the air.
INGESTION: None
ACUTE OVER EXPOSURE EFFECTS: Nitrous oxide's primary physiological
effect is as a central nervous system depressant. Although slightly narcotic it
lacks substantial toxicity. Therefore, its major hazard is the exclusion of an
adequate supply of oxygen to the lungs. Nitrous oxide abuse can impair an
individual's ability to make and implement life-sustaining decisions.
CHRONIC OVER EXPOSURE EFFECTS: Possible side effects; however no
cause-and-effect relationship has been established. Epidemiological studies also
suggest feto -toxic effects and higher incidences of spontaneous abortions in
exposed personnel.
EXPOSURE LIMITS: TWA = 50 ppm molar; No STEL is established.
IRRITANCY OF PRODUCT: None
SENSITIZATION TO MATERIAL: None
CARCINOGENICITY, REPRODUCTIVE EFFECTS: No carcinogenicity. See
Chronic Over Exposure Effects.
TERATOGENICITY, MUTAGENICITY: None
TOXICOLOGICALLY SYNERGISTIC PRODUCTS: None
PREVENTIVE MEASURES
PERSONAL PROTECTIVE EQUIPMENT: Insulated gloves of any material.
Safety goggles or glasses. Safety shoes.
SPECIFIC ENGINEERING CONTROLS: Nitrous oxide is noncorrosive and may
be used with any common structural material. Nitrous oxide oxidizes some
metals at elevated temperatures. Refer to the MEGS Gas Encyclopedia for
additional information.
LEAK AND SPILL PROCEDURES: EVACUATE ALL PERSONNEL FROM
AFFECTED AREA.
Use appropriate protective equipment. If leak is in user's equipment, be certain to
purge piping with an inert gas prior to attempting repairs. If leak is on container or
container valve, contact the closest MEGS location.
WASTE DISPOSAL: Do not attempt to dispose of waste or unused quantities.
Return in the shipping container properly labeled, with any valve outlet plugs or
caps secured and valve protection cap in place to MEGS for proper disposal. For
emergency disposal, contact the closest MEGS location.
HANDLING PROCEDURES AND EQUIPMENT: USE ONLY IN WELL-
VENTILATED AREAS.
Valve protection caps must remain in place unless container is secured with
valve outlet piped to usage point. Do not drag, slide or roll cylinders. Use a
suitable hand truck for cylinder movement. Use a pressure reducing regulator
when connecting cylinders to lower pressure piping or systems. Do not heat
cylinder by any means to increase the discharge rate of product from the
cylinder. Use a check valve or trap in the discharge line to prevent hazardous
back flow into the cylinder. Do not tamper with (valve) safety device. Close valve
after each use and when empty. Do not use adaptors.
STORAGE REQUIREMENTS: Protect cylinders from physical damage. Store in
cool, dry, well-ventilated area of non combustible construction away from heavily
trafficked areas and emergency exits. Do not allow the temperature where
cylinders are stored to exceed 52掳C. Cylinders must be stored upright and firmly
secured to prevent falling or being knocked over. Full and empty cylinders should
be segregated. Use a "first in - first out" inventory system to prevent full cylinders
being stored for excessive periods of time.
TDG CLASSIFICATION: 2.2 (5.1)
WHMIS CLASSIFICATION: A, C
SPECIAL SHIPPING INFORMATION: Always secure cylinders in an upright
position before transporting them. NEVER transport cylinders in trunks of
vehicles, enclosed vans, truck cabs or in passenger compartments. Transport
cylinders secured in open flatbed or in open pick-up type vehicles.
FIRST AID MEASURES
SPECIFIC FIRST AID PROCEDURES: PROMPT MEDICAL ATTENTION IS
MANDATORY IN ALL CASES OF OVEREXPOSURE TO NITROUS OXIDE.
RESCUE PERSONNEL SHOULD BE EQUIPPED WITH SELF-CONTAINED
BREATHING APPARATUS.
INHALATION: Conscious persons should be assisted to an uncontaminated
area and inhale fresh air. Quick removal from the contaminated area is most
important. Unconscious persons should be moved to an uncontaminated area,
given assisted resuscitation and supplemental oxygen. Further treatment should
be symptomatic and supportive.
EYE CONTACT: In the event of liquid or cold gas exposure, flush contaminated
eye(s) with copious quantities of water. Part eyelids to assure complete flushing.
Continue for a minimum of 15 minutes.
SKIN CONTACT: Frostbite: FLUSH AFFECTED AREAS WITH LUKEWARM
WATER. DO NOT USE HOT WATER. A physician should see the patient
promptly if the cryogenic "burn" has resulted in blistering of the dermal surface or
deep tissue freezing.
PREPARATION INFORMATION
PREPARED BY: Safety Department
DATE PREPARED: 09/01/1999
LAST REVISION DATE: 04/01/2008
THE INFORMATION, RECOMMENDATIONS AND DATA CONTAINED IN THIS
DOCUMENT ARE INTENDED TO BE USED BY PROPERLY TRAINED AND
QUALIFIED PERSONNEL ONLY AND AT THEIR SOLE RISKS AND
DISCRETION. THE INFORMATION, RECOMMENDATIONS AND DATA
HEREIN CONTAINED ARE DERIVED FROM SOURCES WHICH WE BELIEVE
TO BE RELIABLE. HOWEVER, MEGS INC. MAKES NO REPRESENTATION
AND GIVES NO WARRANTY OF ANY KIND WHATSOEVER WITH RESPECT
TO THEIR ACCURACY OR COMPLETENESS AND ASSUMES NO LIABILITY
FOR DAMAGES OR LOSS ARISING DIRECTLY OR INDIRECTLY FROM
THEIR USE, WHETHER PROPER OR IMPROPER.
|