QUICK IDENTIFIER
(as used in label and list)
104 Hi-Vac Red Fluid
MATERIAL SAFETY DATA SHEET
________________________________________________________________________________
SECTION I PRODUCT IDENTIFICATION
________________________________________________________________________________
COMMON NAME PRODUCT MODEL NUMBER
104 Hi-Vac Red Fluid 929DB
PRODUCT FILE NUMBER PRODUCT USE
920:405-929DB-10 Indicating Fluid
MANUFACTURER'S NAME EMERGENCY PHONE NUMBERS
Meriam Instrument 1-800-424-9300 (US), 1-703-527-3887 (International)
ADDRESS ENGINEERING CONTROL DATA
10920 Madison Ave. MSDS - A35798-1, Rev. K, EO 5806
Drawing 鈥? A35315
CITY, STATE, ZIP DATE PREPARED
Cleveland, Ohio 44102 3-2-05
________________________________________________________________________________
SECTION II HAZARDOUS INGREDIENTS
________________________________________________________________________________
1. Chemical Name: Dibutyl Phthalate * 2. Chemical Name: Red Dye
CAS No: 84-74-2 CAS No: 4477-79-6
3
OSHA/PEL: 5mg/m3 OSHA/PEL: NA
ACGIH/TLV: 5mg/m ACGIH/TVL: NA
%: 100 %: Trace
* This component is listed as a SARA title III section 313 toxic chemical.
________________________________________________________________________________
SECTION III PHYSICAL & CHEMICAL DATA
________________________________________________________________________________
BOILING POINT SPECIFIC GRAVITY (H2O=1) VAPOR PRESSURE (20掳C)
340掳C 1.04 @ 26.7掳C 0.00001 mmHg
VAPOR DENSITY (AIR=1) SOLUBILITY IN WATER REACTIVITY IN WATER
9.5 13ng/L NA
EVAPORATION RATE (BuAc=1) MELTING POINT pH
NE -35掳C NA
APPEARANCE & ODOR
Red color, weak aromatic odor
________________________________________________________________________________
10920 Madison Avenue Cleveland, Ohio 44102 (216) 281-1100 FAX (216) 281-0228 Page 1 of 4
www.meriam.com
SECTION IV FIRE & EXPLOSION DATA
________________________________________________________________________________
FLASH POINT METHOD USED FLAMMABLE LIMITS (in Air % by Vol.) LEL UEL
340掳C Closed Cup 0.5 (235掳 C) 2.5
AUTO-IGNITION TEMPERATURE EXTINGUISHER MEDIA
398.8掳C Carbon Dioxide or dry chemical
SPECIAL FIRE FIGHTING PROCEDURES
NA
UNUSUAL FIRE AND EXPLOSION HAZARDS
NA
________________________________________________________________________________
SECTION V REACTIVITY DATA
________________________________________________________________________________
STABILITY CONDITION TO AVOID
Stable Incompatible materials, can explode when heated with chlorine
INCOMPATIBILITY (Materials to Avoid)
Acids, Bases and Oxidizing agents, liquid chlorine, nitrates
HAZARDOUS DECOMPOSITION PRODUCTS
Carbon monoxide, carbon dioxide
HAZARDOUS POLYMERIZATION CONDITIONS TO AVOID
Has not been reported NA
________________________________________________________________________________
SECTION VI HEALTH HAZARDS
________________________________________________________________________________
ACUTE
EYES
May cause irritation, tearing and burning pain
SKIN CONTACT
May cause skin irritation. Skin rabbit LD50: >20mL/kg
INGESTION
May cause gastrointestinal irritation. Oral rat LD50: 8000mg/kg
INHALATION
3
May cause respiratory tract irritation. Inhalation rat LC50:4250 mg/m
CHRONIC EFFECTS OF EXPOSURE
To the best of our knowledge all toxicological properties have not been thoroughly investigated.
CHEMICAL LISTED AS CARCINOGEN OR POTENTIAL CARCINOGEN
National Toxicology Program I.A.R.C. Monographs OSHA
NA NA NA
QUICK IDENTIFIER - 104 Hi-Vac Red Fluid Page 2 of 4
________________________________________________________________________________
SECTION VII EMERGENCY & FIRST AID PROCEDURE
________________________________________________________________________________
EYES
Immediately flush eyes with plenty of water for at least 15 minutes while holding eyelids open. Get medical attention.
SKIN CONTACT
Remove contaminated clothing and wash with soap and water. If irritation occurs, get medical attention.
INHALATION
Remove from exposure. Seek medical attention.
INGESTION
If conscious and alert give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Seek
medical attention immediately.
________________________________________________________________________________
SECTION VIII SPILL OR LEAK PROCEDURES
________________________________________________________________________________
RESPONSE TO SMALL SPILLS
Absorb with absorbent material. Dispose of properly.
WASTE DISPOSAL
Place in an appropriate disposal facility in compliance with Federal, State, and Local regulations.
________________________________________________________________________________
SECTION IX SPECIAL PROTECTION INFORMATION
________________________________________________________________________________
RESPIRATORY PROTECTION
Not typically required in a ventilated area.
VENTILATION
A general exhaust system is recommended to keep employee exposure below airborne limits. Refer to the ACGIH
document, 鈥淚ndustrial Ventilation, A Manual Recommended Practices鈥?, for further information.
PROTECTIVE GLOVES
For the best protection wear compatible chemical resistant gloves.
EYE PROTECTION
Wear chemical goggles if there is likelihood of contact with eyes.
ADDITIONAL PROTECTIVE CLOTHING OR EQUIPMENT
Boots, aprons, or chemical suits should be used when necessary to prevent skin contact. Eye wash fountains and safety
showers should be available for emergency use.
QUICK IDENTIFIER - 104 Hi-Vac Red Fluid Page 3 of 4
______________________________________________________________________________
SECTION X TRANSPORTATION
________________________________________________________________________________
Proper Shipping Name: Environmentally Hazardous Substances, Liquid, n.o.s. (Di-n-butyl Phthalate)
Hazard Class or Division: 9
Identification Number: UN3082
Packing Group: III
Packing Authorization: D.O.T 49 CFR 173.155 & 173.203
IATA Packing Instructions: 914
________________________________________________________________________________
SECTION XI SPECIAL PRECAUTIONS
________________________________________________________________________________
-THIS PRODUCT IS FOR INDUSTRIAL AND LABORATORY USE ONLY
-Do not store in open, unlabeled or mislabeled containers.
-Store in cool, dry place with adequate ventilation.
-Keep away from flames and high temperatures.
-For personal hygiene protection, we recommend washing skin thoroughly with soap and water after handling product.
-Keep out of reach of children.
-HMIS rating HEALTH - 1 FLAMMABILITY - 1 REACTIVITY - 1
_______________________________________________________________________________
DISCLAIMER OF LIABILITY
The information contained herein is, to the best of our knowledge and belief, accurate. However, since the conditions of handling and use are beyond our control, we make no
guarantee of the results, and assume no liability for damages incurred by use of this material. All chemicals may present unknown health hazards and should be used with
caution. Although certain hazards are described herein, we cannot guarantee that these are the only hazards which exist. Final determination of suitability of the chemical is
the sole responsibility of the user. User of any chemical should satisfy themselves that the conditions and methods of use assure that the chemical is used safely. NO
REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE OR ANY OTHER
NATURE ARE MADE HEREUNDER WITH RESPECT TO THE INFORMATION CONTAINED HEREIN OR THE CHEMICAL TO WHICH THE INFORMATION REFERS. It is
the responsibility of the user to comply with all applicable federal, state, local laws and regulations.
________________________________________________________________________________
QUICK IDENTIFIER - 104 Hi-Vac Red Fluid Page 4 of 4
|