QUICK IDENTIFIER
(as used in label and list)
Ethylene Glycol & Water
MATERIAL SAFETY DATA SHEET
________________________________________________________________________________
SECTION I PRODUCT AND COMPANY IDENTIFICATION
________________________________________________________________________________
COMMON NAME PRODUCT MODEL NUMBER
Ethylene Glycol & Water ETH GLY
PRODUCT FILE NUMBER PRODUCT USE
920:405-ETH GLY-9 Fill Fluid
MANUFACTURER'S NAME EMERGENCY PHONE NUMBERS
Meriam Instrument 1-800-424-9300 (US), 1-703-527-3887 (International)
ADDRESS ENGINEERING CONTROL DATA
10920 Madison Ave. MSDS - A35808, Rev. K, EO 6445
Drawing 鈥? A34038
CITY, STATE, ZIP DATE PREPARED
Cleveland, Ohio 44102 7-07-08
________________________________________________________________________________
SECTION II HAZARDS IDENTIFICATION
________________________________________________________________________________
ACUTE
EYES
Moderately to severely irritating to the eyes. Vapors may cause eye irritation.
SKIN CONTACT
Mildly irritating to the skin and slightly toxic on prolonged or repeat contact.
INGESTION
May be harmful or fatal if swallowed. May produce central nervous system (CNS) depression, kidney and liver damage
which may be fatal.
INHALATION
Vapors are mildly to markedly irritating to the lungs depending on exposure level.
CHRONIC
CHRONIC EFFECTS OF EXPOSURE
Preexisting skin, eye, and respiratory disorders may be aggravated by exposure to this product. Impaired kidney and liver
functions from preexisting disorders may be aggravated by exposure to this product.
QUICK IDENTIFIER 鈥? Ethylene Glycol and Water Page 1 of 6
10920 Madison Avenue 鈾? Cleveland, Ohio 44102 鈾? (216) 281-1100 FAX (216) 281-0228
________________________________________________________________________________
SECTION III COMPOSITION/INFORMATION ON INGREDIENTS
________________________________________________________________________________
1.Chemical Name: Ethylene Glycol *
CAS No: 107-21-1
OSHA/PEL: NE
100mg/m3 (C)
ACGIH/TLV:
%: 68
2.Chemical Name: Water
CAS No: 7732-18-5
OSHA/PEL: NA
ACGIH/TLV: NA
%: 32
鈥? This chemical is listed under SARA title III section 313 toxic chemicals and is identified as a hemolytic agent.
________________________________________________________________________________
SECTION IV FIRST AID MEASURES
________________________________________________________________________________
EYES
Immediately flush eyes with plenty of water for at least 15 minutes while holding eyelids open. Seek medical attention.
SKIN CONTACT
Remove contaminated clothing and wash off skin with soap and water. Wash contaminated clothes. If irritation develops,
contact a physician.
INHALATION
Due to high boiling point, inhalation is not normally a problem. Remove to fresh air.
INGESTION
If conscious, give two glasses of water and induce vomiting by giving 30cc (2 tablespoons) Syrup of Ipecac. If Ipecac is
unavailable induce vomiting by touching finger to the back of victim's throat. Keep victim's head below hips while
vomiting. Take immediately to the hospital.
________________________________________________________________________________
SECTION V FIRE FIGHTING MEASURES
________________________________________________________________________________
FLASH POINT METHOD USED FLAMMABLE LIMITS (in Air % by Vol.) LEL UEL
250 F Closed cup NA NA
AUTO-IGNITION TEMPERATURE EXTINGUISHER MEDIA
Not Determined Water fog, CO2, Dry Chemical, Foam
SPECIAL FIRE FIGHTING PROCEDURES
Evacuate area of all unnecessary personnel. Use NIOSH/MSHA approved self-contained breathing apparatus and other
protective equipment.
UNUSUAL FIRE AND EXPLOSION HAZARDS
Material will not burn unless preheated.
QUICK IDENTIFIER 鈥? Ethylene Glycol and Water Page 2 of 6
10920 Madison Avenue 鈾? Cleveland, Ohio 44102 鈾? (216) 281-1100 FAX (216) 281-0228
_______________________________________________________________________________
SECTION VI ACCIDENTAL RELEASE MEASURES
________________________________________________________________________________
RESPONSE TO SMALL SPILLS
Absorb with non-combustible absorbent material. Dispose of properly, prevent from entering sewers. The product is a
non-hazardous waste when spilled material is disposed of defined in Resource Conservation Recovery Act (RCRA)
regulations (40CFR261).
WASTE DISPOSAL
Place in an appropriate disposal facility in compliance with Federal, State, and Local regulations.
____________________________________________________________________________
SECTION VII HANDLING AND STORAGE
________________________________________________________________________________
HANDLING AND STORAGE: Skin and eye contact should be avoided as good industrial practice. Wearing of protective
gloves and eye protection is recommended. Wash hands and contaminated skin area after handling. Follow all warnings
and precautions even after container is emptied. Wash thoroughly after handling or at the end of the shift.
OTHER PRECAUTIONS: Store in cool dry place away from strong oxidizers and acids. Keep container tightly closed
when not in use. All handling equipment should be properly grounded to prevent the build-up of electrostatic charges.
Storage area should be equipped with a CO2 system. Handle in accordance with good industrial hygiene and safety
practices.
SECTION 7 NOTES: Containers should not be opened until ready for use. Use clean non-sparking equipment and tools
when handling.
________________________________________________________________________________
SECTION VIII EXPOSURE CONTROLS/PERSONAL PROTECTION
________________________________________________________________________________
RESPIRATORY PROTECTION
Not typically required. If exposure exceeds permissible exposure limits wear a self-contained breathing apparatus in
compliance with NIOSH/MSHA specifications. Comply with 29CFR 1910.134.
VENTILATION
General (mechanical) room ventilation is generally satisfactory. Special, local ventilation may be needed at points where
vapors can be expected to exceed exposure limits.
PROTECTIVE GLOVES
For the best protection wear nitrile, neoprene, PVC or natural rubber gloves.
EYE PROTECTION
Wear chemical goggles if there is likelihood of contact with eyes.
ADDITIONAL PROTECTIVE CLOTHING OR EQUIPMENT
Boots, aprons, or chemical suits should be used when necessary to prevent skin contact. Eye wash fountains and safety
showers should be available for emergency use.
QUICK IDENTIFIER 鈥? Ethylene Glycol and Water Page 3 of 6
10920 Madison Avenue 鈾? Cleveland, Ohio 44102 鈾? (216) 281-1100 FAX (216) 281-0228
________________________________________________________________________________
SECTION IX PHYSICAL & CHEMICAL PROPERTIES
________________________________________________________________________________
BOILING POINT SPECIFIC GRAVITY (H2O=1) VAPOR PRESSURE (mmHg)
238 F 1.082 14
VAPOR DENSITY (AIR=1) SOLUBILITY IN WATER REACTIVITY IN WATER
2 complete None
EVAPORATION RATE MELTING POINT pH
less than 0.01% -58 F NA
APPEARANCE & ODOR
colorless and odorless liquid
________________________________________________________________________________
SECTION X STABILITY AND REACTIVITY
________________________________________________________________________________
STABILITY CONDITION TO AVOID
Stable Heat, flames, ignition sources, and other incompatibles.
INCOMPATIBILITY (Materials to Avoid)
Keep away from strong oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS
Carbon monoxide and unidentified organic compounds may be formed during combustion.
HAZARDOUS POLYMERIZATION CONDITIONS TO AVOID
Will not occur NA
________________________________________________________________________________
SECTION XI TOXICOLOGICAL INFORMATION
Chemical Listed as Carcinogen or Potential Carcinogen
National Toxicology Program I.A.R.C. Monographs OSHA
NA NA NA
________________________________________________________________________________
SECTION XII ECOLOGICAL INFORMATION
When released into the soil, this material is expected to readily biodegrade. When released into the soil this material is
expected to leach into groundwater. When released into the soil this material is not expected to evaporate significantly.
When released into the water, this material is not expected to evaporate significantly. When released into the water, this
material is expected to readily biodegrade. When released into the water this material is expected to have a half-life
between 1 and 10 days.
The LC50 96-hour values for fish are over 100 mg/L.
QUICK IDENTIFIER 鈥? Ethylene Glycol and Water Page 4 of 6
10920 Madison Avenue 鈾? Cleveland, Ohio 44102 鈾? (216) 281-1100 FAX (216) 281-0228
________________________________________________________________________________
SECTION XIII DISPOSAL CONSIDERATIONS
Disposal: Dispose of all cleanup materials in accordance with all Local, State, and Federal regulations.
________________________________________________________________________________
SECTION XIV TRANSPORT INFORMATION
Proper Shipping Name: N/A
Hazard Class or Division: N/A
Identification Number: N/A
Packing Group: N/A
Packing Authorization: N/A
IATA Packing Instructions: N/A
________________________________________________________________________________
SECTION XV REGULATORY INFORMATION
TSCA (TOXIC SUBSTANCE CONTROL ACT): Ethylene Glycol is listed.
SARA Section 302 Extremely Hazardous Substances (EHS): This product does not contain any components regulated
under Section 302 (40 CFR 355) as Extremely Hazardous Substances.
SARA Section 304 CERCLA Hazardous Substances: This product does not contain any components regulated under
section 304 (40 CFR 370) as hazardous chemicals for emergency release.
SARA Section 311/312 Hazard Communication Standard (HCS): This product is regulated under Section 311/312.
SARA Section 313 Toxic Chemical List (TCL): This product contains a component listed on the Section 313 Toxic
Chemical List.
Clean Water Act CWA 鈥? Priority Pollutants: Not Provided
STATE REGULATIONS: California Proposition 65: Not Provided
INTERNATIONAL REGULATIONS: Not Provided
_____________________________________________________________________________
SECTION XVI OTHER INFORMATION
________________________________________________________________________________
-THIS PRODUCT IS FOR INDUSTRIAL AND LABORATORY USE ONLY.
-Do not store in open, unlabeled or mislabeled containers.
-Store in cool, dry place with adequate ventilation.
-Keep away from flames and high temperatures.
-For personal hygiene protection, we recommend that employees wash thoroughly after handling product.
Always wash up before eating, smoking, and using toilet facilities.
-Keep out of reach of children.
-HMIS rating HEALTH - 2 FLAMMABILITY - 0 REACTIVITY - 1
QUICK IDENTIFIER 鈥? Ethylene Glycol and Water Page 5 of 6
10920 Madison Avenue 鈾? Cleveland, Ohio 44102 鈾? (216) 281-1100 FAX (216) 281-0228
_______________________________________________________________________________
DISCLAIMER OF LIABILITY
The information contained herein is, to the best of our knowledge and belief, accurate. However, since the conditions of handling and use are beyond our control, we make
no guarantee of the results, and assume no liability for damages incurred by use of this material. All chemicals may present unknown health hazards and should be used
with caution. Although certain hazards are described herein, we cannot guarantee that these are the only hazards which exist. Final determination of suitability of the
chemical is the sole responsibility of the user. User of any chemical should satisfy themselves that the conditions and methods of use assure that the chemical is used
safely. NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE OR ANY
OTHER NATURE ARE MADE HEREUNDER WITH RESPECT TO THE INFORMATION CONTAINED HEREIN OR THE CHEMICAL TO WHICH THE INFORMATION
REFERS. It is the responsibility of the user to comply with all applicable federal, state, local laws and regulations.
________________________________________________________________________________
QUICK IDENTIFIER 鈥? Ethylene Glycol and Water Page 6 of 6
10920 Madison Avenue 鈾? Cleveland, Ohio 44102 鈾? (216) 281-1100 FAX (216) 281-0228
|