HYDROSEAL COATINGS INC -- NEW HYDROSEAL NO MERCURY, LAPPER 2
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CGSDN
MSDS NAME: NEW HYDROSEAL NO MERCURY, LAPPER 2
Responsible Party
Name: HYDROSEAL COATINGS CO INC
Address: 1119 E MISSION ROAD
City: FALLBROOK CA 92028
Info Phone: 800-358-5431
Emergency Phone Number: 800-255-3924
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: HYDROSEAL COATINGS CO INC
Address: 1119 E MISSION ROAD
City: FALLBROOK CA 92028
Phone: 800-358-5431
=======================================================
Ingredients
=======================================================
Name: NON-HAZARDOUS INGREDIENTS
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
RTECS #: 9999999VO
Name: VOLATILE ORGANIC COMPOUND (COATING): 0.21 LB/GL (25 G/L); (MATERIAL):
0.12 LB/GL (14 G/L).
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INHALATION: NO HARMFUL EFFECTS EXPECTED FROM
BREATHING VAPORS OR AEROSOLS OF THIS MATERIAL. EYE CONTACT: MISTS MAY CAUSE
IRRITATION. DIRECT CONTACT WITH LIQUID OR AEROSOL EXPOSURE MAY CAUSE BUR
NING, TEARING AND REDNESS. SKIN ABSORPTION: NOT KNOWN TO BE IRRITANT,
HOWEVER, IF ALLOWED TO REMAIN (EFTS OF OVEREXPOS)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HEALTH HAZARDS: ON SKIN WITHOUT BEING
RINSED OFF WITH WATER, A THIN FILM MAY FORM. REMOVAL OF THIS FILM MAY RESULT
IN SLIGHT IRRITATION DEPENDENT ON THE METHOD OF REMOVAL. INGESTION: NO
HARMFUL EFFECT S HAVE BEEN DEMONSTRATED IN ORAL TOXICITY STUDIED OF SIMILAR
MATERIALS.
First Aid: EYE CONT: IF IRRIT/REDNESS FROM EXPOS TO VAPS DEVELOPS, MOVE VICTIM
AWAY FROM EXPOS INTO FRESH AIR. IF IRRIT/REDNESS PERSISTS, SEEK MED HELP. FOR
DIRECT CONT, HOLD EYELIDS APART & FLUSH WITH CLEAN WAT ER FOR AT LEAST 15
MINS. SEEK MED HELP.SKIN CONT: REMOVE CONTAM CLTHG. CLEANSE AFFECTED AREA
THORO BY WASHING W/SOAP & WATER. IF IRRIT/REDNESS DEVELOPS & PERSISTS
SEEK MED HELP. INHAL:IF (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: FLUSH SPILLED MATERIAL INTO SUITABLE RETAINING AREAS
OR CONTAINERS WITH LARGE QUANTITIES OF WATER. SMALL AMOUNTS OF SPILLED
MATERIAL MAY BE ABSORBED INTO AN APPROPRIATE ABSORBANT. KEEP OUT OF DRAINS,
SEWERS AND WATERWAYS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF PRODUCT IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.
Handling And Storage Precautions: KEEP CNTNRS IN COOL & DRY AREA. USE &
STORE PROD W/ADEQ VENT. KEEP PROD CNTNRS CLSD WHEN NOT IN USE. AVOID EXTREME
TEMP VARIATIONS & FREEZING.
Other Precautions: SHOCKING EMULSION WITH LARGE QUANTITIES OF CHEMICALS OR
EXTREME SHEAR MAY CAUSE COAGULATION. CAREFUL HANDLING PRACTICES SHOULD BE
EXERCISED AND UNNECESSARY EXPOSURE AVOIDED. DO NOT WEAR SATURATED CLOT HING
OR SHOES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N). WATER MAY BE USEFUL IN COOLING CONTAINERS EXPOSED TO HEAT AND FLAME.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS EXPOSED TO EXTREME HEAT MAY
RUPTURE DUE TO PRESSURE BUILDUP.
=======================================================
Control Measures
=======================================================
Respiratory Protection: DEPENDING NATURE & CONCENTRATION OF AIRBORNE
MATERIAL, USE A NIOSH APPRVD RESPIRATOR OR GAS MASK WITH APPROPRIATE
CARTRIDGES AND CANISTERS OR SUPPLIED AIR EQUIPMENT.
Ventilation: IF CURRENT VENTILATION PRACTICES ARE NOT ADEQUATE FOR MINIMIZING
EXPOS, ADDITIONAL VENT/EXHST SYSTEMS MAY BE REQUIRED.
Protective Gloves: IMPERMEABLE GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
IMPERVIOUS CLOTHING SHOULD BE WORN AS NEEDED.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: FIRST AID: BREATHING DIFFICULTIES DEVELOP, SEEK
MEDICAL HELP. INGESTION: NO FIRST AID NORMALLY REQUIRED. SEEK IMMEDIATE
MEDICAL ATTENTION (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Density: HVR/AIR
Spec Gravity: 1.5 (H*2O=1)
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: DILUTABLE
Appearance and Odor: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: NO HAZARDOUS REACTIONS ARE EXPECTED TO OCCUR UNDER NORMAL
INDUSTRIAL CONDITIONS.
Hazardous Decomposition Products: COMBUSTION MAY YIELD CARBON MONOXIDE AND/OR
CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: NEW HYDROSEAL NO MERCURY, LAPPER 2
Company: HYDROSEAL COATINGS CO INC
Street: 1119 E MISSION ROAD
City: FALLBROOK CA
Zipcode: 92028
Health Emergency Phone: 800-255-3924
Label Required IND: Y
Date Of Label Review: 03/13/1998
Status Code: C
Label Date: 03/13/1998
Origination Code: G
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYE CONTACT: MISTS MAY CAUSE IRRITATION. DIRECT
CONTACT WITH LIQUID OR AEROSOL EXPOSURE MAY CAUSE BURNING, TEARING AND
REDNESS. SKIN ABSORPTION: IF ALLOWED TO REMAIN ON SKIN WITHOUT BEING RINSE D
OFF WITH WATER, A THIN FILM MAY FORM.REMOVAL OF THIS FILM MAY RESULT IN
SLIGHT IRRITATION. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.