HEXCEL CORP -- HRH-327 HONEYCOMB CORE
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CJPSF
MSDS NAME: HRH-327 HONEYCOMB CORE
Responsible Party
Name: HEXCEL CORP
Address: 5794 WEST LAS POSITAS BOULEVARD
Box: 8181
City: PLEASANTON CA 94588-8781
Info Phone: 925-847-9500
Emergency Phone Number: 800-433-5072
Resp. Party Other MSDS No.: 439-2673-HRHO-3270-02
Preparer's Name: DAVID R HUFF
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: HEXCEL CORPORATION
Address: 5794 WEST LAS POSITAS BOULEVARD
Box: 8181
City: PLEASANTON CA 94588-8781
Phone: 925-847-9500
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Cas: 65997-17-3
Name: GLASS, OXIDE, CHEMICALS; (FIBERGLASS, SYNTHETIC, VITREOUS, CONTINUOUS,
FILAMENT FIBER.)
% low Wt: 20.
% high Wt: 60.
OSHA PEL: 15 MG/M3 (TOTAL)
ACGIH TLV: 10 MG/M3 (TOTAL)
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: NONE EXPECTED UNDER NORMAL CONDITIONS OF USE. MAY
CAUSE MECHANICAL IRRITATION DURING MACHINING OF THE PRODUCT. SKIN: MAY CAUSE
CUTS AND ABRASIONS DURING HANDLING OF THE PRODUCT. INHALATION: NONE EXPECTED
UNDER NORMAL CONDITIONS OF USE. AVOID BREATHING DUST CREATED FROM THE
MACHINING OR SAWING OF THE PRODUCT. INGESTION: NONE EXPECTED UNDER NORMAL
CONDITIONS. OTHER: DUST FROM MACHINING THE CU RED PRODUCT MAY CAUSE
MECHANICAL IRRITATION OF THE EYES, SKIN, NOSE, THROAT AND UPPER RESPIRATORY
TRACT.
Explanation Of Carcinogenicity: NONE OF THE COMPONENTS PRESENT IN THIS MATERIAL
AT CONCENTRATIONS EQUAL TO OR GREATER THAN 0.1% ARE LISTED OR REGULATED BY
IARC, NTP, OSHA OR ACGIH AS A CARCINOGEN.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: EYES: IN CASE OF EYE CONTACT, IMMEDIATELY FLUSH WITH LARGE AMOUNTS
OF WATER FOR AT LEAST 15 MINUTES, KEEPING THE EYELIDS OPEN. GET MEDICAL
ATTENTION. SKIN CONTACT: NONE NECESSARY OTHER THAN FOR POSSIB LE CUTS OR
ABRASIONS CAUSE FROM HANDLING THE PRODUCT. INHALATION: NOT LIKELY TO OCCUR.
BUT IF DUST IS INHALED, REMOVE TO FRESH AIR. GET MEDICAL ATTENTION.
INGESTION: NONE NECESARY. INGESTION: CALL MD IMMEDIATELY (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NO SPECIAL PRECAUTIONS REQUIRED.
Waste Disposal Methods: MATL FOR DISP SHOULD BE PLACED IN APPROP WASTE CNTNRS.
IT IS THE RESPONSIBILITY OF GENERATOR TO COMPLY W/ALL FED, STATE, PROVINCIAL
& LOCAL LAWS & REGULATIONS. MFR RECOMMEND THAT YOU CONTACT APPROP WA
STE DISP CONTRACTOR & ENVIRONMENTAL AGENCY FOR RELEVANT LAWS &
REGULATIONS. UNDER RCRA, IT IS RESPON SIBILITY OF USER TO PROD TO DETERMINE
AT (SUPDAT)
Handling And Storage Precautions: NO SPECIAL TEMPERATURE PRECAUTIONS REQUIRED.
MAINTAINED SEALED AGAINST CONTAMINATION FROM DIRT OR MOISTURE.
Other Precautions: RATING: HEALTH - 1, FLAMMABILITY - 0, REACTIVITY - 0,
SPECIAL- NONE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: USE WATER-SPRAY, DRY CHEMICAL OR CO*2, TO EXTINGUISH
FIRES.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT ORDINARILY REQUIRED. IF FUMES ARE BEING GENERATED
DURING USE OF THE PRODUCT, USE A NIOSH APPROVED VAPOR RESPIRATOR. IF DUST IS
BEING GENERATED DURING USE OR MACHINING OF THE PRODUCT, USE A NIOSH A PPROVED
DUST RESPIRAOR.
Ventilation: USE LOC EXHST SUFFICIENT TO CONTROL FUMES/DUST GENERATED DURING
USE/MACHINING OF PROD. IF EXHST VENT IS NOT AVAIL/INADEQUATE, USE NIOSH
APPRVD RESP, AS APPROP.
Protective Gloves: IMPERVIOUS GLOVES (FP N).
Eye Protection: ANSI APPROVED CHEMICAL WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPROVED EYE WASH AND DELUGE SHOWER (FP N).
Work Hygienic Practices: GOOD PERSONAL HYGIENE PRACTICES SHOULD BE FOLLOWED AT
ALL TIMES. USE VACUUM EQUIPMENT TO REMOVE PRODUCT DUST FROM CLOTHING AND WORK
AREAS. COMPRESSED AIR IS NOT RECOMMENDED.
Supplemental Safety and Health: WASTE DISP METH: THE TIME OF DISPOSAL, WHETHER
THE PRODUCT MEETS RELEVANT WASTE CLASSIFICATION & TO ASSURE PROPER
DISPOSAL. PHYSICAL DATA: DENSITY (LBS/FT*3) (WATER=62.3): 2.5-9. HAZ DECOMP
PROD: CARB ON MONOXIDE, NITROGEN OXIDES & OTHER UNIDENTIFIED GASES &
VAPORS WHICH MAY BE TOXIC. AVOID INHALATION.
=======================================================
Physical/Chemical Properties
=======================================================
Appearance and Odor: BROWN, COATED FIBERGLASS FABRIC MADE INTO HONEY COMB CORE
W/NO DISTINCTIVE ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: NOT DETERMINED.
Hazardous Decomposition Products: PRODUCTS EVOLVED FROM HEAT OF COMBUSTION OR
DECOMPOSITION: PRODS OF COMBUSTION & DECOMP DEPEND ON OTHER MATLS PRESENT IN
FIRE & ACTUAL CONDITIONS OF FIRE. BURNING WILL PRODUCE CARBON DIOXDE,
(SUPDAT)
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR UNDER NORMAL CONDITIONS OF
USE.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: MATERIAL OR COMPONENT TOXICITY DATA: MEDIAN LETHAL
DOSE (SPECIES): ORAL (LD50), INHALATION (LC50), DERMAL (LD50): NOT
DETERMINED. IRRITATION INDEX, ESTIMATION OF IRRITATION (SPECIES): SKIN, EYES,
INHA LATION: NOT DETERMINED.
=======================================================
Ecological Information
=======================================================
Ecological: NO ECOLOGICAL DATA HAS BEEN DETERMINED.
=======================================================
MSDS Transport Information
=======================================================
Transport Information: DOT AND IATA: PROPER SHIPPING NAME, HAZARD CLASS,
IDENTIFICATION NUMBER, PACKING GROUP: NOT REGULATED. LABEL REQUIRED: NONE.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SECTION 302/304 EXTREMELY HAZARDOUS SUBSTANCE,
SECTION 311 HAZARDOUS CATEGORIZATION, SECTION 313 TOXIC CHEMICALS, NONE
CERCLA SECTION 102(A) HAZARDOUS SUBSTANCE: NONE.
Federal Regulatory Information: W (CANADA): CLASSIFICATION: NONE. INGREDIENT
DISCLOSURE LIST: NONE.
State Regulatory Information: CALIFORNIA SAFE DRINKING WATER AND TOXIC
ENFORCEMENT ACT OF 1986 (PROPOSITION 65): WARNING! THE STATE OF CALIFORNIA
HAS DETERMINED THAT THE FOLLOWING LISTED MATERIAL OR COMPONENT CHEMICALS IN
THIS PRO DUCT MAY CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM:
4,4'-METHYLENEDIANILINE (MDA) CAS# 101-77-9), KNOWN TO CAUSE CANCER, TRACE
AMOUNT. THIS PRODUCT DOES NOT CONTAIN OR IS NOT MANUFACTURED W/OZONE
DEPLETING SUBSTANCES AS IDENTIFIED IN TITLE VI, CLEAN AIR ACT "STROTOSPHERIC
OZONE PROTECTI ON" & THE REGULATIONS SET FORTH IN 40, CFR, PART 82.
=======================================================
Other Information
=======================================================
Other Information: THE NODE ADHESIVES AND COATINGS USED IN THIS PRODUCT HAVE
BEEN CURED AND ARE NOT CONSIDERED HAZARDOUS CHEMICALS AS DEFINED IN OSHA
STANDARD 1910.1200 HAZARD COMMUNICATION. THE EXPOSURE LIMIT EXPRESSED ARE
FOR EACH INDIVIDUAL MATERIAL OR COMPONENT AND NOT FOR THE TOTAL PRODUCT. THE
PRECENTAGE WILL VARY DEPENDING ON THE WEIGHT OF THE FABRIC USED, THE CELL
SIZE AND THE FINAL PRODUCT DENSITY.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: HRH-327 HONEYCOMB CORE
Company: HEXCEL CORPORATION
Street: 5794 WEST LAS POSITAS BOULEVARD
PO Box: 8181
City: PLEASANTON CA
Zipcode: 94588-8781
Health Emergency Phone: 800-433-5072
Label Required IND: Y
Date Of Label Review: 10/13/1999
Status Code: A
Origination Code: F
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES: NONE EXPECTED UNDER NORMAL CONDITIONS OF
USE. MAY CAUSE MECHANICAL IRRITATION DURING MACHINING OF THE PRODUCT. SKIN:
MAY CAUSE CUTS AND ABRASIONS DURING HANDLING OF THE PRODUCT. INHALATIO N:
NONE EXPECTED UNDER NORMAL CONDITIONS OF USE. AVOID BREATHING DUST CREATED
FROM THE MACHINING OR SAWING OF THE PRODUCT. INGESTION: NONE EXPECTED UNDER
NORMAL CONDITIONS. OTHER: DUST FROM MACHINING THE CURED PRODUCT MAY CAUSE
MECHANICAL IRRITATION OF THE EYES, SKIN, NOSE, THROAT AND UPPER RESPIRATORY
TRACT. CHRONIC: NONE SPECIFIED BY MANUFACTURER (FP N).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|
| ALL PAGES On Chemical Property IN THIS GROUP
| | NAME | CAS |
|
0722B800 LUBRICATING OIL,GENERAL PURPOSE PRESERVATIVE
| 8012-95-1 |
|
ECA 2PA
| |
|
MIL-L-6085C AM.1
| |
|
3217 METHYL ALCOHOL
| |
|
FC-104 FLOURINERT BRAND FLASHLUBE COOLANT
| |
|
POITASSIUM CHLORIDE, 7590
| |
|
HYDROSTAR H-5, H-10, H-35 SHIELDING GASES
| 1333-74-0
7440-37-1 |
|
MARINE ADHESIVE SEALANT FAST CURE 5200-WHITE, 05220
| |
|
MARINE ADHESIVE SEALANT FAST CURE 5200-WHITE, 06519
| |
|
SAFETY LAMP PROPRIETARY FUEL, DINE-AGLOW SAFETY LAMP
| 64742-46-7 |
|
MARINE ADHESIVE SEALANT FAST CURE 5200-WHITE, 06525
| |
|
MARINE ADHESIVE SEALANT FAST CURE 5200-WHITE, 06520
| |
|
MOLY OPEN GEAR OIL AEROSOL, CSA-0819A
| 110-54-3
74-98-6
75-28-5 |
|
MARINE ADHESIVE SEALANT FAST CURE 5200-WHITE, 06531
| |
|
REZTORE TOPICAL ANTISTAT
| 111-76-2
68412-54-4
25322-68-3
7732-18-5 |
|
NATURAL RUBBER (ALL GRADES, TSR, SMR, SIR (SUPDAT)
| 127-07-1 |
|
MARINE COUSTIFAB, 50G-NL-SL
| |
|
603 RETAINING COMPOUND HIGH STRENGTH, 21440
| |
|
SIMONIZ CAR WAX, 28695
| 8052-41-3
64742-88-7
8015-86-9
8002-74-2
8008-20-6 |
|
PEEL AWAY 5
| |
|
INTERSHIELD PRORECO 508, MEDIUM BLUE, PRA551
| 110-43-0
13463-67-7
7631-86-9
21645-51-2 |
|
INTERSHIELD PRORECO 508, DESERT BEIGE, PRA558
| 110-43-0
13463-67-7
7631-86-9
21645-51-2 |
|
UNDERWATER REPAIR PUTTY-UW RESIN, 11800
| 1333-86-4
25068-38-6 |
|
UNDERWATER REPAIR PUTTY (UW) HARDENER, 11800
| |
|
FAST CONVERTER FOR D8020 L/F, D7010
| |
|
SUPERFLEX RED HIGH TEMP RTV SILICONE ADHESIVE SEALANT, 30564
| 63148-62-9
7631-86-9
4253-34-3
1309-37-1
64-19-7 |
|
ULTRA BLUE RTV SILICONE GASKET MAKER, 30567
| |
|
CAPTURE SPOT AND SOIL REMOVER
| |
|
HALOBROM MSDT
| |
|
CER-CRO, 810-830
| 1308-38-9
7732-18-5
63231-67-4
1314-20-1
68188-85-2
68188-83-0 |
|
PELCO COLLOIDAL SILVER, 16031
| |
|
RED EPOXY, 12001
| |
|
MILLENIUM 2100 COVE BASE
| |
|
5760, CYAN DEVELOPER
| |
|
SANTOVAC 5 POLYPHENYL ETHER LUBRICANT
| |
|
SUNCOAST SWIMMING POOL GRANULAR CHLORINATOR (CAL-HYPO)
| 7778-54-3 |
|
CHLORINATING TABLETS, 0407A
| 7778-54-3 |
|
DA 6171 REPELL
| 64742-47-8
64742-52-5
79-01-6
124-38-9 |
|
CARBON-OFF CLEANER
| |
|
HRH-327 HONEYCOMB CORE
| 65997-17-3 |
|
MT TONER, P/N 8910-611
| |
|
VCI-386 CLEAR
| |
|
SAFETY ORANGE, PFS500S8055
| |
|
L/M 11540 HI VISC 90 GL, 484497-88412
| |
|
101-55W175,SANTOPRENE THERMOPLASTIC RUBBER GENERAL PURPOSE G
| |
|
101-64, SANTOPRENE THERMOPLASTIC RUBBER GENERAL (SUPDAT)
| |
|
INTERSHIELD PRORECO 609, PRA 610, CLEAR COAT BASE
| 110-43-0
108-10-1
108-65-6
123-86-4 |
|
FLIPS SEAFOAM BREEZE, DN 4870
| 9002-88-4
915-67-3 |
|
INTERSHIELD PRORECO 609, PRA 611, CLEAR COAT CONVERTER
| 3779-63-3
123-86-4 |
|
FLIPS APPLE BLOSSOM, DN 4860
| 9002-88-4
915-67-3 |
|
|