ICI PAINTS -- CATHA-COAT 304V GRAY LIQUID 304B0200
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CLFKP
MSDS NAME: CATHA-COAT 304V GRAY LIQUID 304B0200
Responsible Party
Name: ICI PAINTS
Address: 925 EUCLID AVE
City: CLEVELAND OH 44115
Info Phone: 800-545-2643
Emergency Phone Number: 800-545-2643
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: DEVOE COATINGS
City: N/K NK 00000
Name: ICI PAINTS
Address: 925 EUCLID AVE
City: CLEVELAND OH 44115
Phone: 800-545-2643
=======================================================
Ingredients
=======================================================
Cas: 1070-10-6
Name: 1-HEXANOL, 2-ETHYL-, TITANIUM(4+) SALT
% low Wt: 5.
% high Wt: 10.
------------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
Name: BENZENE, DIMETHYL-; (XYLENE)
% low Wt: 20.
% high Wt: 30.
OSHA PEL: 100 PPM
OSHA STEL: 150 PPM
ACGIH TLV: 434 MG/M3;100 PPM
ACGIH STEL: 651 MG/M3;150 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 107-98-2
RTECS #: UB7700000
Name: 2-PROPANOL, 1-METHOXY-; (1-METHOXY-2-PROPANOL
% low Wt: 5.
% high Wt: 10.
OSHA PEL: 100 PPM
OSHA STEL: 150 PPM
ACGIH TLV: 369 MG/M3;100 PPM
ACGIH STEL: 553 MG/M3;150 PPM
------------------------------
Cas: 14464-46-1
RTECS #: VV7325000
Name: CRISTOBALITE; (CRYSTALLINE SILICA, CRISTOBALITE).
% low Wt: .1
% high Wt: 1.
OSHA PEL: SEE TABLE Z-3
ACGIH TLV: 0.05 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 71-43-2
RTECS #: CY1400000
Name: BENZENE
% low Wt: .01
% high Wt: .1
OSHA PEL: SEE 1910.1028
ACGIH TLV: 32 MG/M3;10 PPM
ACGIH STEL: NOT ESTABLISHED
EPA Rpt Qty: 10 LBS
DOT Rpt Qty: 10 LBS
------------------------------
Cas: 100-41-4
RTECS #: DA0700000
Name: BENZENE, ETHYL-; (ETHYLBENZENE).
% low Wt: 1.
% high Wt: 5.
OSHA PEL: 435 MG/M3;100 PPM
ACGIH TLV: 434 MG/M3;100 PPM
ACGIH STEL: 543 MG/M3;125 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 11099-06-2
Name: ETHYL SILICATE POLYMER
% low Wt: 20.
% high Wt: 30.
------------------------------
Cas: 60676-86-0
RTECS #: VV7328000
Name: SILICA, VITREOUS; (SILICA, FUSED).
% low Wt: 30.
% high Wt: 40.
OSHA PEL: SEE TABLE Z-3
ACGIH TLV: 0.1 MG/M3
ACGIH STEL: NOT ESTABLISHED
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: YES
Effects of Exposure: PRIMARY ROUTES OF EXPOSURE: INHALATION, SKIN CONTACT, EYE
CONTACT, INGESTION. INHALATION: IRRITATION OF RESPIRATORY TRACT. PROLONGED
INHALATION MAY LEAD TO FATIGUE, DROWSINESS, DIZZINESS AND/OR LIGHTH EADNESS,
HEADACHE, UNCOORDINATION, NAUSEA, VOMITING, COUGHING, CENTRAL NERVOUS SYSTEM
DEPRESSION, INTOXICATION, TIGHTNESS OF CHEST, ANESTHETIC EFFECT OR NARCOSIS,
DIFFICULTY OF BREATHING, FEVER AND CH ILLS, SEVERE LUNG IRRITATION OR DAMAGE,
LOSS OF CONSCIOUSNESS, RESPIRATORY FAILURE, ASPHYXIATION, DEATH. SKIN
CONTACT: IRRITATION OF SKIN. PROLONGED OR REPEATED CONTACT CAN CAUSE
DERMATITIS, DEFATTING , BLISTERING, (SIGNS & SYMPTOMS)
Explanation Of Carcinogenicity: THE INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
(IARC) HAS DETERMINED THAT THERE IS SUFFICIENT EVIDENCE FOR THE
CARCINOGENICITY OF BENZENE TO HUMANS AND EXPERIMENTAL ANIMALS (GROUP 1). THE
NATIONAL TO XICOLOGY PROGRAM (NTP) HAS DETERMINED THAT BENZENE IS KNOWN TO BE
CARCINOGENIC. BENZENE IS REGULATED BY OSHA AS A CARCINOGEN. CONTAINS
(TOXICOLOGICAL INFO)
Signs And Symptions Of Overexposure: HEALTH HAZ (CONT'D): ALLERGIC RESPONSE.
POSSIBLE SENSITIZATION TO SKIN. SKIN CONTACT MAY RESULT IN DERMAL ABSORPTION
OF COMPONENT(S) OF THIS PRODUCT WHICH MAY CAUSE DROWSINESS. EYE CONTACT:
IRRITATIO N OF EYES. PROLONGED OR REPEATED CONTACT MAY CAUSE CONJUNCTIVITIS,
BLURRED VISION, TEARING OF EYES, REDNESS OF EYES, SEVERE EYE IRRITATION.
INGESTION: MAY CAUSE LUNG INFLAMMATION AND DAMAGE DUE TO ASP IRATION OF
MATERIAL INTO LUNGS, DROWSINESS, DIZZINESS AND/OR LIGHTHEADNESS,
UNCOORDINATION, NAUSEA, VOMITING, DIARRHEA, GASTRO-INTESTINAL DISTURBANCES,
ABDOMINAL PAIN, DIFFICULTY OF BREATHING.
Medical Cond Aggravated By Exposure: EYE, SKIN, RESPIRATORY DISORDERS, LUNG
DISORDERS, BLOOD DISORDERS, KIDNEY DISORDERS, AND LIVER DISORDERS.
First Aid: INHALATION: REMOVE TO FRESH AIR. RESTORE AND SUPPORT CONTINUED
BREATHING. GET EMERGENCY MEDICAL ATTENTION. HAVE TRAINED PERSON GIVE OXYGEN
IF NECESSARY. GET MEDICAL HELP FOR ANY BREATHING DIFFICULTY. SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSE. FLUSH
FROM SKIN WITH WATER. THEN WASH THOROUGHLY WITH SOAP AND WATER. EYE CONTACT:
FLUSH IMMEDIATELY WITH LARGE AMO UNTS OF WATER, ESPECIALLY UNDER LIDS, FOR AT
LEAST 15 MINUTES. IF IRRITATION OR OTHER EFFECTS PERSIST, OBTAIN MEDICAL
TREATMENT. INGESTION: IF SWALLOWED, OBTAIN MEDICAL ATTENTION IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: COMPLY WITH ALL APPLICABLE HEALTH AND ENVIRONMENTAL
REGULATIONS. ELIMINATE SOURCES OF IGNITION. VENTILATE AREA WITH
EXPLOSION-PROOF EQUIPMENT. COLLECT SPILLS WITH ABSORBENT MATERIALS. USE
NON-SPARKIN G TOOLS. EVACUATE ALL UNNECESSARY PERSONNEL. PLACE COLLECTED
MATERIAL IN PROPER CONTAINER. COMPLETE PERSONAL PROTECTIVE EQUIPMENT MUST BE
USED DURUNG CLEANUP. LARGE SPILLS: SHUT OFF LEAK (STATE REG)
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL,
STATE AND LOCAL REGULATIONS (FP N). AVOID DISCHARGE TO NATURAL WATERS.
Handling And Storage Precautions: STORE BELOW 80F(27C). KEEP AWAY FROM HEAT,
SPARKS AND OPEN FLAME. USE ONLY WITH ADEQUATE VENTILATION. KEEP CONTAINER
TIGHTLY CLOSED IN A WELL-VENTILATED AREA. EMPTY CONTAINERS MAY CONTAIN
HAZARDOUS RE SIDUES. GROUND EQUIPMENT WHEN TRANSFERRING TO PREVENT
ACCUMULATION OF STATIC CHARGE.
Other Precautions: USE ONLY WITH ADEQUATE VENTILATION. AVOID CONTACT WITH SKIN,
EYES, AND BREATHING OF VAPORS. KEEP CONTAINERS TIGHTLY CLOSED AND UPRIGHT
WHEN NOT IN USE. DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHI LDREN. WASH
HANDS THOROUGHLY AFTER HANDLING, ESPECIALLY BEFORE EATING OR SMOKING.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point: =15.6C, 60.F
Extinguishing Media: DRY CHEMICAL OR FOAM WATER FOG. CARBON DIOXIDE.
Fire Fighting Procedures: WATER MAY BE USED TO COOL AND PROTECT EXPOSED
CONTAINERS. FIREFIGHTERS SHOULD USE FULL PROTECTIVE CLOTHING, EYE PROTECTION,
AND NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard: CLOSED CONTRS MAY EXPLODE WHEN EXPOS TO EXTREME
HEAT OR FIRE. VAPS MAY IGNITE EXPLOSIVELY AT AMBIENT TEMPS. VAPS ARE HEAVIER
THAN AIR & MAY TRAVEL LONG DISTANCES TO A SOURCE OF IGNIT & FLASH
BACK. CLO SED CONTR MAY BURST IF EXPOS TO EXTREME HEAT OR FIRE. MAY DECOMP
UNDER FIRE CONDITIONS EMITTING IRRITANT &/OR TOX GASES.
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONTROL ENVIRONMENTAL CONCENTRATIONS BELOW APPLICABLE
STANDARDS. WHERE RESPIRATORY PROTECTION IS REQUIRED, USE ONLY NIOSH APPROVED
RESPIRATORS IN ACCORDANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation: PROVIDE DILUTION VENTILATION OR LOCAL EXHAUST TO PREVENT BUILD-UP
OF VAPORS. USE EXPLOSION-PROOF EQUIPMENT. USE NON-SPARKING EQUIPMENT.
Protective Gloves: IMPERVIOUS GLOVES.
Eye Protection: ANSI APPROVED SAFETY GLASSES OR GOGGLES, AND FACE SHIELD (FP
N).
Other Protective Equipment: EYE WASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). IMPERVIOUS CLOTHING, APRON, BOOTS.
Work Hygienic Practices: WASH CONTAMINATED CLOTHING BEFORE REUSE. WASH HANDS
THOROUGHLY AFTER HANDLING, ESPECIALLY BEFORE EATING OR SMOKING.
Supplemental Safety and Health: DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =80.C, 176.F
B.P. Text: 176-291
VOC Grams/Liter: 392
Appearance and Odor: GRAY LIQUID. NO ODOR SPECIFIED BY MANUFACTURER (FP N).
Percent Volatiles by Volume: 45.11
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELEVATED TEMPERATURES, MOISTURE, CONTACT WITH
OXIDIZING AGENTS, SPARKS, OPEN FLAME, IGNITION SOURCES.
Materials To Avoid: OXIDIZERS, ACIDS, BASES, MONOMERS, AMINES. ALKALIS WATER,
HALOGENATED COMPOUNDS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, OXIDES OF
SILICON, HYDROGEN, TOXIC GASES, ZINC OXIDE, UNIDENTIFIED ORGANIC COMPOUNDS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: CONTAINS A CHEMICAL THAT IS MODERATELY TOXIC BY
INGESTION. OTHER EFFECTS OF OVEREXPOSURE MAY INCLUDE TOXICITY TO LIVER,
KIDNEY, CENTRAL NERVOUS SYSTEM, BLOOD. CONTAINS A CHEMICAL THAT MAY BE
ABSORBED THROUGH SKIN. EXPLANATION OF CARCINOGENICITY (CONT'D): CRYSTALLINE
SILICA WHICH IS CONSIDERED A HAZARD BY INHALATION. IARC HAS CLASSIFIED
CRYSTALLINE SILICA AS CARCINOGENIC TO HUMANS (GROUP 1). CRYST ALLINE SILICA
IS ALSO A KNOWN CAUSE OF SILICOSIS, A NON-CANCEROUS LUNG DISEASE. NTP HAS
CLASSIFIED CRYSTALLINE SILICA A REASONBLY ANTICIPATED HUMAN CARCINOGEN. IN A
2-YEAR INHALATION STUDY CONDUCTED B Y THE NATIONAL TOXICOLOGY (ECOLOGICAL)
=======================================================
Ecological Information
=======================================================
Ecological: N/P. TOXICOLOGY (CONT'D): PROGRAM (NTP), ETHYLBENZENE VAPOR AT 750
PPM PRODUCED KIDNEY & TESTICULAR TUMORS IN RATS, AND LUNG AND LIVER
TUMORS IN MICE. GENETIC TOXICITY STUDIES SHOWED NO GENOTOXIC EFFE CTS. THE
RELEVANCE OF THESE RESULTS TO HUMANS IS NOT KNOWN. NOTICE - REPORTS HAVE
ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE . INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
=======================================================
MSDS Transport Information
=======================================================
Transport Information: PAINT,3, UN1253.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: INGREDIENTS THAT REQUIRE REPORTING UNDER SECTION
302 EHS: NONE. INGREDIENTS THAT REQUIRE REPORTING UNDER SECTION 313: BENZENE,
DIMETHYL-; BENZENE; BENZENE, ETHYL-.
Federal Regulatory Information: CERCLA CHEMICALS: BENZENE, DIMETHYL-; BENZENE;
BENZENE, ETHYL-.
State Regulatory Information: N/P. SPILL/RELEASE PROCEDURES (CONT'D): IF SAFE
TO DO SO. DIKE AND CONTAIN SPILL. PUMP TO STORAGE, SALVAGE VESSELS. USE
ABSORBENT TO PICK UP EXCESS RESIDUE. KEEP SALVAGEABLE MATERIAL AND RINSE
WATER OUT OF SEWERS AND WATER COURSES. SMALL SPILLS - USE ABSORBENT TO PICK
UP RESIDUE AND DISPOSE OF PROPERLY.
=======================================================
Other Information
=======================================================
Other Information::HEALTH-2, FLAMMABILITY-3, REACTIVITY-1. PHYSICAL/CHEMICAL
(CONT'D): WT/GAL: 9.79. GR/LTR: 392.03.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: CATHA-COAT 304V GRAY LIQUID 304B0200
Assigned IND: Y
Company: ICI PAINTS
Street: 925 EUCLID AVE
City: CLEVELAND OH
Zipcode: 44115
Health Emergency Phone: 800-545-2643
Label Required IND: Y
Date Of Label Review: 06/20/2001
Status Code: A
Origination Code: G
Hazard And Precautions: PRIMARY ROUTES OF EXPOSURE: INHALATION, SKIN CONTACT,
EYE CONTACT, INGESTION. INHALATION: IRRITATION OF RESPIRATORY TRACT.
PROLONGED INHALATION MAY LEAD TO FATIGUE, DROWSINESS, DIZZINESS AND/OR LIGHTH
EADNESS, HEADACHE, UNCOORDINATION, NAUSEA, VOMITING, COUGHING, CENTRAL
NERVOUS SYSTEM DEPRESSION, INTOXICATION, TIGHTNESS OF CHEST, ANESTHETIC
EFFECT OR NARCOSIS, DIFFICULTY OF BREATHING, FEVER AND CH ILLS, SEVERE LUNG
IRRITATION OR DAMAGE, LOSS OF CONSCIOUSNESS, RESPIRATORY FAILURE,
ASPHYXIATION, DEATH. SKIN CONTACT: IRRITATION OF SKIN. PROLONGED OR REPEATED
CONTACT CAN CAUSE DERMATITIS, DEFATTING , BLISTERING, (SIGNS & SYMPTOMS)
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|